- DL manuals
- RAIS
- Wood stove
- 2:1
- User Manual
RAIS 2:1 User Manual
Summary of 2:1
Page 1
English rais - manual for rais 800 1 u s e r m a n u a l rais 800
Page 2
W e cannot be held r esponsible for any misprints..
Page 3
English rais - manual for rais 800 3 rais 800 date: december 2009 modified: 0 introduction .................................................................................................................................. 4 warranty ......................................................................
Page 4
English rais - manual for rais 800 4 introduction thank you for purchasing a rais wood burning stove. A rais wood burning stove is more than just a heat source: it also shows that you care about design and quality in your home. To make the most of your wood burning stove it is important that you rea...
Page 5
English rais - manual for rais 800 5 rais 800 nominal output (kw): 5 min./max. Output(kw): 4,7 - 5,5 heating area (m 2 ) ca. 100 stove’s width/depth/height (mm) 541-490-1227 combustion chamber’s width/depth/height (mm) 370-380-411 recommended amount of wood when fuelling (kg): (distributed on 2-3 lo...
Page 6
English rais - manual for rais 800 6 convection rais stoves are convection stoves. This means that the stove’s back and side panels are not over-heated. Convection means that there is a circulation of air, which ensures that the heat is distributed more evenly throughout the entire room. The cold ai...
Page 7
English rais - manual for rais 800 7 installation instructions the following pages give instructions for the safe and proper installation of this heating appliance in the uk. These instructions cover the basic principles of installation, although detail may need slight modification to suit particula...
Page 8
English rais - manual for rais 800 8 chimney the chimney is the driving force which makes the stove function. In order for the stove to perform satisfactorily the chimney height must be sufficient to ensure the correct draught of 14 to 18 pa so as to clear the products of combustion and prevent prob...
Page 9
English rais - manual for rais 800 9 if it is found that there is excessive draught in the chimney then either an adjustable flue damper or alternatively a draught stabiliser should be fitted. The adjustable flue damper should not close off the flue entirely but should in its closed position leave a...
Page 10: Rais 800
English rais - manual for rais 800 10 manufacturer’s plate for rais 800 installation it is prohibited to carry out unauthorised alterations to the stove. There must be plenty of fresh air in the room where the stove is being installed, in order to ensure proper combustion. Note that any mechanical e...
Page 11
English rais - manual for rais 800 11 installation of stove: note: decision to be taken concerning the placement of the inlets and outlets of the convection system. The area requirements for convection holes to be kept. Miscolouring of the wall above the doors and the convection air outlets may occu...
Page 12
English rais - manual for rais 800 12 a -a b -b a a b b 550 min . Mm afs tan d ti l b ræ ndb art 328 min . Mm afs tan d ti l b ræ ndb art m in . K on ve kt io ns ar ea l ov er o vn . 1 00 0c m ² ( ka n fo rd el es ) m in . K on ve kt io ns ar ea l un de r o vn . 6 60 cm ² 30 0 m in . M m a fs ta nd ...
Page 13
English rais - manual for rais 800 13 combustible material min. 150 min. 150 combustible material min. 300
Page 14
English rais - manual for rais 800 14 a -a b -b a a b b m in . K on ve kt io ns ar ea l 3 75 cm ² ov er o vn (k an fo rd el es ) m in . K on ve kt io ns ar ea l 2 25 cm ² un de r o vn m øb le rin gs af st an d m in . 1 10 0m m afs tan d ti l b ræ ndb art min . 5 70m m afs tan d ti l b ræ ndb art min...
Page 15
English rais - manual for rais 800 15 damage on brick walls may occur if the necessary convection are not obtained. Brændbart materiale / brennbart materiale combustible material combustible material min. 150 min. 150 min. 300
Page 16
English rais - manual for rais 800 16 using not insulated smoke pipe, the minimum distance to combustible wall must be 225 mm from smoke pipe. Installation distance in case of non-combustible wall we recommend a minimum distance to non-combustible material of 50 mm (f) for clean- ing considerations....
Page 17
English rais - manual for rais 800 17 for the installer finally before firing the stove for the first time a check should be made to ensure that the assembly and stove installation has been satisfactory and that there are no leaks in any seals in the appliance and appliance connections to the chimne...
Page 18
English rais - manual for rais 800 18 operating instructions fuel the stove is designed and approved in accordance with en 13240 and ns 3058 for stok- ing split, dried firewood. The firewood must have a water content of 15-22% and its max. Length should be the length of the combustion chamber minus ...
Page 19
English rais - manual for rais 800 19 drying and storage drying wood takes time: proper air drying takes approx. 2 years. Here are some tips: store the wood sawn, split and stacked in an airy, sunny place, which is protected against rain (the south side of the house is particularly suitable). Store ...
Page 20
English rais - manual for rais 800 20 using the wood burning stove adjustment of the air damper. The damper has 3 settings. Control if the ash is white and the walls in the combustion chamber sott-free after the stove has been used, the air regulation was set correctly and the wood was sufficiently ...
Page 21
English rais - manual for rais 800 21 first usage a careful start pays off. Start with a small fire, so that the wood burning stove can get accustomed to the high temperature. This gives the best start and any damage is avoided. Be aware that a strange but harmless odour and smoke concoction may ema...
Page 22
English rais - manual for rais 800 22 lighting and fuelling tips before firing up: open a door or window close to the wood burning stove. If there is a “storm” in the stove coming from the chimney, it is advisable to place a screwed-up piece of newspaper between the upper baffle plate and the chimne...
Page 23
English rais - manual for rais 800 23 when the flames are clear - after approx. 5-10 min. - close the door. Damper - see adjustment of air damper. After approx. 10-20 min. - when you have a good bed of glowing embers - add 2-3 pieces of wood. Leave the door ajar until the fire has caught on properly...
Page 24
English rais - manual for rais 800 24 cleaning and care the wood burning stove and the chimney must be serviced by a chimney sweep twice a year. During cleaning and care, the stove must be cold. If the glass is sooty: - moisten a piece of paper or newspaper, dip it in the ash, and rub the sooty glas...
Page 25
English rais - manual for rais 800 25 cleaning of the flue ways remove the smoke converter plate by tilting it to one side and turning it a little slantwise. Pull out the plate carefully. Then remove the smoke impediment by lifting it up and moving it forward. Carefully lift out the smoke impediment...
Page 26
English rais - manual for rais 800 26 interruption of operation smoke spillage around door: could be due to too low draught in the chimney - check whether the flue or chimney is blocked - check whether the extraction hood is switched on; if it is, switch it off and open a win- dow/door in the proxim...
Page 27
English rais - manual for rais 800 27 accessories and spare parts if spare parts other than those recommended by rais are used, the warranty is voided. All replaceable parts can be bought as spare parts from your rais distributor. See the following spare parts diagrams for the individual products. A...
Page 28
English rais - manual for rais 800 28 reservedelstegning - rais 800 pos./ref. Quantity item no./description 1 1 5401090/95 door 2 1 54000990/95 air-system 3 1 5302200 fire brick set 4 - 5305500 seal set.
Page 29
English rais - manual for rais 800 29 1 2 3 4.
Page 30
English rais - manual for rais 800 30
Page 31
English rais - manual for rais 800 31.
Page 32
Rais a/s industrivej 20 dk-9900 frederikshavn www.Rais.Dk.