1. DL manuals
  2. Taski
  3. Floor Machine
  4. ergodisc 1200
  5. Instructions Of Use

Taski ergodisc 1200 Instructions Of Use

Other manuals for ergodisc 1200: Instructions Of Use
Manual is about: Ultra High Speed

Summary of ergodisc 1200

  • Page 1

    Ergodisc 1200 attention! Before first start-up, it is essential that you read the instructions of use and the safety notes carefully. Keep the instructions of use in a good and easily accessible place so that it can be consulted at any time. Instructions of use.

  • Page 2: Content

    2 content safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 machine installation. . . . . . . . . . . . . . . . . . . ...

  • Page 3: Safety Instructions

    3 safety instructions due to their design and construction, taski machines comply with health and safety requirements of the ec guidelines and therefore carry the ce sign. Important! Switch the machine off when you: • e.G., carry out cleaning, maintenance or repair work, replace components or change...

  • Page 4

    4 regularly check the power cord for tearing or aging, and do not put the machine into operation if it is not in an flawless condition, but have it repaired by an authorised specialist! Repairs to mechanical or electrical parts of the machine must only be undertaken by johnsondiversey authorised cus...

  • Page 5: Overview

    5 overview 1 machine handle 2 cord strain relief 3 power outlet max. Strain 700w 4 power cord 5 guide rod 6 cable mount 7 pad holder 8 additional equipment holder 9 transport wheels 10 protecting ring 11 castor 12 motor covering 13 motor ventilation 14 guide rod 15 safety switch 16 right lever (moto...

  • Page 6: Machine Installation

    6 machine installation insert pad check: • that there there is no point on the pad that has a thickness less than the minimum thickness of 1 cm. • that there are no foreign bodies on the pads before putting it into use (e.G., sand grains). • that the pad is mounted. Could cause damage to floor surfa...

  • Page 7: Start Up Procedure

    7 start up procedure t remove the pad. T mount or replace the pad and fasten the retainer disk to it. Always tighten the retainer disk properly, could cause damage to the floor when neglected. T slowly bring machine into upright position. T stand behind the machine. T press the adjustment lever at t...

  • Page 8: Recommended Chemicals

    8 recommended chemicals please only use the recommended taski chemical products the correct dosage is recommended on the product's packaging and on the "taski product information sheet". Application technique beginning work begin cleaning operation caution: using other chemicals (e.G. Chemicals cont...

  • Page 9: Stair Transport

    9 stair transport t connect the power plug into the wall socket. The indicators light up. T lead the power cord with your hand. Make sure that the power cord does not touch the tool. T hold on to the machine. T push the safety switch and press the actuating lever at the same time. By doing this the ...

  • Page 10: End of Operation

    10 end of operation after cleaning t release the action lever. T do this by pulling the plug out of the socket. T stand behind the machine. T pull the adjustment lever and slowly lift the guide rod until it is in the upright position. T when getting go of the adjustment lever, the guide rod snaps in...

  • Page 11: Finishing Work

    11 finishing work emptying solution disposal of solution must by in accordance with the national regulations. Clean the pad t mount or replace the pad and fasten the retainer disk to it. Always tighten the retainer disk properly, could cause damage to the floor when neglected. T slowly bring machine...

  • Page 12: Cleaning The Machine

    12 cleaning the machine store the machine service, maintenance and care maintenance t rinse out the solution tank and the spray unit thuroughly with warm water. When the cleaning solution dries up, it could cause faults. Caution: never clean the machine with a high water pressure or a water hose. Th...

  • Page 13: Service Intervals

    13 the machine's maintenance is a pre-condition for trouble-free running and a long life. Service intervals taski machines are build to the highest quality standards . This is supported by internationally regonized quality control procedures. Electrical and mechanical parts are subject to wear or ag...

  • Page 14: Malfunctions

    14 malfunctions technical data malfunction possible causes troubleshooting page machine does not run no power supply t connect the power plug into the wall socket. Guide rod in upright position t place machine in working position 7 safety switch defect t call for technical service on the last page o...

  • Page 15

    15 rated power 1300 w rated power(integrated socket) 700 w frequency 50 hz power cord length 25 m brush rpm 1200 min-1 brush pressure 0.03 n/cm 2 assessed sound level lpa according to en 60704-1 57 db(a) the assessed effective acceleration value according to iso 5349 0.4 m /s2 splash water protectio...

  • Page 16: Accessories

    16 accessories transport article 1200 8504 380 suction aggregate 230v x 8504620 suction aggregate 120v x 8505100 double filter paper sack for suction aggregate ergodisc (10 pieces per pack) x 8505110 double filter paper sack for suction aggregate ergodisc (5 pieces per pack) x 8505180 hepa filter fo...

  • Page 17: Disposal

    17 make sure that the machine is fastened and secured within the transportation vehicle. Disposal when placed out of service, the machine and its accessories must be disposed of according to the national regulations. Your taski partner can support you with this upon notification. Index a accessories...

  • Page 18: Eu Declaration of Conformity

    18 eu declaration of conformity we johnsondiversey switzerland ch-9542 münchwilen hereby declare that the product described below both in this basic design and construction and in the version marketed by us conforms to the relevant safety- and health-related requirements of the appropriate eu direct...

  • Page 19

    19 at johnsondiversey austria trading gmbh guglgasse 7-9 1030 wien tel (43) 1 605 57 0 fax (43) 1 605 57 1908 be johnsondiversey haachtsesteenweg 672 1910 kampenhout tel (32) 16 617 802 fax (32) 16 605 395 ch johnsondiversey eschlikonerstrasse 9542 münchwilen tel (41) 71 969 27 27 fax (41) 71 969 22...

  • Page 20

    V0 10 / 12088-35 0601 pt johnsondiversey z. Ind. Abrunheira 2714-505 sintra tel (351) 2 191 57 000 fax (351) 2 192 50 615 ro johnsondiversey romania s.R.L. Baneasa business center, etaj 5 sos. Bucuresti - ploiesti 17-21 sector 1, bucaresti tel (40) 21 233 3894 fax (40) 21 233 3896 ru johnsondiversey...