1. DL manuals
  2. Taylor
  3. Ice Cream Maker
  4. Freezemaster 336
  5. Operating Instructions Manual

Taylor Freezemaster 336 Operating Instructions Manual

Other manuals for Freezemaster 336: Operating Instructions Manual, Service Manual
Manual is about: 300 series; 700 series Soft Serve Ice Cream Machine

Summary of Freezemaster 336

  • Page 1

    Models 336, 338 & 339 freezemaster 300 series original operating instructions 036029--m 4/16/09 (original publication) (updated 3/18/13).

  • Page 2

    Complete this page for quick reference when service is required: taylor distributor: address: phone: service: parts: date of installation: information found on the data label: model number: serial number: electrical specs: voltage cycle phase maximum fuse size: a minimum wire ampacity: a e april, 20...

  • Page 3: Table Of Contents

    Table of contents models 336, 338 & 339 table of contents section 1 to the installer 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Section 2 to the operator 4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Compressor ...

  • Page 4

    Models 336, 338 & 339 table of contents table of contents -- page 2 disassembly 23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Brush cleaning 23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

  • Page 5: Section 1

    1 models 336, 338 & 339 to the installer section 1 to the installer the following are general installation instructions. For complete installation details, please see the checkout card. Installer safety in all areas of the world, equipment should be installed in accordance with existing local codes....

  • Page 6

    2 models 336, 338 & 339 to the installer 101012 water connections (water cooled units only) an adequate cold water supply must be provided with a hand shut--off valve. On the underside rear of the base pan, two 1/2” i.P.S. Water connections for inlet and outlet have been provided for easy hook--up. ...

  • Page 7

    3 models 336, 338 & 339 to the installer 130318 supply cords used with this unit shall be oil-resistant, sheathed flexible cable not lighter than ordinary polychloroprene or other equivalent synthetic elastomer-sheathed cord (code designation 60245 iec 57) installed with the proper cord anchorage to...

  • Page 8: Section 2

    4 models 336, 338 & 339 to the operator section 2 to the operator the freezer you have purchased has been carefully engineered and manufactured to give you dependable operation. The taylor soft--serve models covered in this manual consist of the following: 336, 338 and 339. These units, when properl...

  • Page 9: Section 3

    5 models 336, 338 & 339 safety 130318 section 3 safety we at taylor company are concerned about the safety of the operator when he or she comes in contact with the freezer and its parts. Taylor has gone to extreme efforts to design and manufacture built--in safety features to protect both you and th...

  • Page 10

    6 models 336, 338 & 339 safety 130318 s do not allow untrained personnel to operate this machine. S do not operate the freezer unless all service panels and access doors are restrained with screws. S do not remove any internal operating parts (examples: freezer door, beater, scraper blades, etc.) un...

  • Page 11: Section 4

    7 models 336, 338 & 339 operator parts identification 111101 section 4 operator parts identification model 336 figure 1 item description part no. 1 cover a.--hopper x37963--ser 2 pan--drip 17--1/4” long 027504 3 panel--upper side left 028740 4 orifice 022465--100 5 o--ring 3/8 od x .070 w 016137 6 t...

  • Page 12

    8 models 336, 338 & 339 operator parts identification model 338 figure 2 item description part no. 1 cover a.--hopper--standard x38458--ser 2 gasket--hopper cover 20 qt. 038474 3 orifice 022465--100 4 o--ring 3/8 od x .070 w 016137 5 tube a.--feed ss 5/32 hole x29429--2 6 o--ring .643 od x .077 w 01...

  • Page 13

    9 models 336, 338 & 339 operator parts identification 111101 model 339 figure 3 item description part no. 1 cover a.--hopper--standard x38458--ser 2 gasket--hopper cover 20 qt. 038474 3 orifice 022465--100 4 o--ring 3/8 od x .070 w 016137 5 tube a.--feed ss 5/32 hole x29429--2 6 o--ring .643 od x . ...

  • Page 14

    10 models 336, 338 & 339 operator parts identification three spout door figure 4 item description part no. 1 seal--drive shaft 032560 2 shaft--beater 033235 3 beater a.--2.8 qt. Helicore x35466 4 blade--scraper--plastic 035480 5 bearing--front 050216 6 gasket--door ht 4” double 048926 7 o--ring 3/8 ...

  • Page 15

    11 models 336, 338 & 339 operator parts identification 110825 accessories figure 5 item description part no. 1 tool--o--ring removal 048260--wht 2 brush--rear bearing 1” d x 2”l 013071 3 brush--double ended 013072 4 brush--draw valve 1” x 2” x 17” 013073 5 brush--mix pump body 3” x 7” white 023316 *...

  • Page 16: Section 5

    12 models 336, 338 & 339 important: to the operator section 5 important: to the operator item description 1 power switch 2 mix refrigeration button 3 standby button 4 wash button 5 auto button 6 indicator light “mix low” 7 reset button symbol definitions the following chart identifies the symbol def...

  • Page 17

    13 models 336, 338 & 339 important: to the operator power switch when placed in the “on” position, the power switch allows softechr control panel operation. Indicator light -- “mix low” located on the front of the machine is a mix level indicating light. When the light is flashing, it indicates that...

  • Page 18

    14 models 336, 338 & 339 important: to the operator 091030 reset button the reset button is located in the service panel. The reset protects the beater motor from an overload condition. If an overload occurs, the reset mechanism will trip. To properly reset the freezer, press the “auto” button to ca...

  • Page 19: Section 6

    15 models 336, 338 & 339 operating procedures section 6 operating procedures each unit stores mix in a hopper. The mix then flows by gravity through an air tube down into the freezing cylinder. They all have 2.8 quart (2.6 liter) capacity freezing cylinders. All models have 20 quart (18.9 liter) mix...

  • Page 20

    16 models 336, 338 & 339 operating procedures step 2 take one of the scraper blades and slip it under the hook at the front of the beater. Wrap the blade around the beater following the helix and pushing the blade down onto the helix as you wrap. At the back end of the beater, slip the blade under t...

  • Page 21

    17 models 336, 338 & 339 operating procedures insert the prime plugs into the holes in the top of the freezer door, and push down. Figure 14 step 4 install the freezer door. Insert the baffle rods through the opening in the beaters and seat the door flush with the freezing cylinder. With the door se...

  • Page 22

    18 models 336, 338 & 339 operating procedures slide the fork over the bar in the slot of the draw valve. Secure with pivot pin. Note: the models 336, 338 and 339 have three draw handles. Slide the fork of the draw handle in the slot of the draw valve, starting from the right. Slide the pivot pin thr...

  • Page 23

    19 models 336, 338 & 339 operating procedures slide the small o--ring into the groove of the air orifice. Do not lubricate the o--ring. Figure 24 note: make sure the hole in the air orifice is clean and is not clogged. If the hole in the air orifice should become clogged, use soap and hot water to c...

  • Page 24

    20 models 336, 338 & 339 operating procedures figure 28 step 4 place the power switch in the “on” position. Figure 29 step 5 press the “wash” button. This will cause the sanitizing solution in the freezing cylinder to agitate. Allow it to agitate for five minutes. Figure 30 step 6 place an empty pai...

  • Page 25

    21 models 336, 338 & 339 operating procedures step 9 assemble the hopper gasket around the top edge of the mix hopper. Stand the air tube in the corner of the hopper. Figure 33 repeat steps 1 through 9 for the other side of the freezer. Priming step 1 with a pail beneath the door spout, lower the dr...

  • Page 26

    22 models 336, 338 & 339 operating procedures step 5 press the “auto” button. The “auto” light will come on indicating the main refrigeration system is operating. When the unit cycles off, the product will be at serving viscosity. Figure 37 note: the mix refrigeration light will come on, indicating ...

  • Page 27

    23 models 336, 338 & 339 operating procedures cleaning step 1 prepare a pail of approved 100 ppm cleaning solution (examples: 2--1/2 gal. [9.5 liters] of kay--5r or 2 gal. [7.6 liters] of stera--sheenr). Use warm water and follow the manufacturer’s specific- ations. Step 2 push down the prime plug. ...

  • Page 28

    24 models 336, 338 & 339 operating procedures step 4 remove the o--rings from the air tubes and air orifices. Step 5 return to the freezer with a small amount of cleaning solution. Brush clean the rear shell bearings at the back of the freezing cylinders with the black bristle brush. Figure 38 step ...

  • Page 29: Section 7

    25 models 336, 338 & 339 important: operator checklist 111213 section 7 important: operator checklist during cleaning and sanitizing cleaning and sanitizing schedules are governed by federal, state, or local regulatory agencies, and must be followed accordingly. If the unit has a “standby mode”, it ...

  • Page 30

    26 models 336, 338 & 339 important: operator checklist j 7. If your machine is equipped with an auxiliary refrigeration system, check the auxiliary condenser for accumulation of dirt and lint. Dirty condensers will reduce the refrigeration capacity of the mix hopper. Condensers must be cleaned month...

  • Page 31: Section 8

    27 models 336, 338 & 339 troubleshooting guide section 8 troubleshooting guide problem probable cause remedy page ref. 1. No product is being dispensed with draw valve open and the machine in the “auto” mode. A. Freeze--up in mix inlet hole. A. Call service technician to adjust the mix hopper temper...

  • Page 32

    28 models 336, 338 & 339 troubleshooting guide problem probable cause remedy page ref. 5. The mix in the mix hopper is too warm. A. The temperature is out of adjustment. A. Call service technician to adjust the mix hopper temperature. ------ b. Missing or defective mix hopper gasket. B. Replace/inst...

  • Page 33

    29 models 336, 338 & 339 troubleshooting guide problem probable cause remedy page ref. 10. No freezer operation after pressing the “auto” button. A. Unit is unplugged. A. Plug into wall receptacle. ------ b. The circuit breaker is off or the fuse is blown. B. Turn the breaker on, or replace the fuse...

  • Page 34: Section 9

    30 models 336, 338 & 339 parts replacement schedule section 9 parts replacement schedule part description every 3 months every 6 months annually drive shaft seal x scraper blade x freezer door gasket x front bearing x draw valve o--ring x pivot pin o--ring x prime plug o--ring x air tube o--ring x a...

  • Page 35: Section 10

    31 models 336, 338 & 339 warranty explanation 121015 section 10 warranty explanation class 103 parts the warranty for new equipment class 103 parts is one year from the original date of unit installation, with a replacement parts warranty of three months. Class 212 parts the warranty for new equipme...

  • Page 36: Section 11

    Section 11 parts list + available separately 32 parts list models 336, 338 & 339 121031 de s cri p t io n part num be r 336 qty . 338 qty . 339 qty . W arr. Cl as s re m arks accumulator- c opper 2" di a 10" 047062 1 103 adaptor a. -c aster x18915 4 4 103 beari ng- front 050216 2 2 2 000 beari n g- ...

  • Page 37

    33 + available separately models 336, 338 & 339 parts list 121031 de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r cable- ri bbon- 14c- 40" l- di p/ di l 069474- 40 1 103 cable- ri bbon- pw r/ relay- 66 in 069474- 66 2 103 cap- desi g n -1 .010" id -6 po in t 01...

  • Page 38

    + available separately 34 parts list models 336, 338 & 339 de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r +gasket- h opper cover- 2 0 q t 038474 1 1 000 +knob- mi x cover 025429 2 2 103 decal- dec- taylo r 336- so ftech 038337 1 000 decal- dec- taylor- ss 0329...

  • Page 39

    35 + available separately models 336, 338 & 339 parts list de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r +g ui de- f il ter *336* 054497 1 103 fi lter- a ir -18. 00lx13. 50hx. 70w 052779- 3 1 000 +g ui de- f il ter* 444* 632s* (8) 754ac 053784 1 103 gear a. *...

  • Page 40

    + available separately 36 parts list models 336, 338 & 339 de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r tool- o -ri ng removal 048260- w h t 1 1 000 label- d oor- m ove part 032749 1 1 1 000 label- w arn- cover 051433 5 5 6 000 label- sw itch- pow er *off/ o...

  • Page 41

    37 + available separately models 336, 338 & 339 parts list de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r panel a. -si d e r ig ht x48596 1 103 upper panel- si d e- ri ght 048487 1 103 lo w e r panel- r ear 051600 1 103 panel a. -f ront x32956 1 103 panel- r e...

  • Page 42

    + available separately 38 parts list models 336, 338 & 339 de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r starter- 1 phase- 4. 5 t o 7 a 041950- 27k 2 2 2 103 208- 230v 60hz 1 ph overload- t hermal 047150- 27k 2 2 2 103 starter- 3 phase- 3 t o 5 am 041950- 33j...

  • Page 43

    39 + available separately models 336, 338 & 339 parts list de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r swi t ch- toggl e- 4 p dt* o n- none- o n 037394 1 1 1 103 tray- dri p 16- 7/ 8l x 5 -1 /8 020157 1 103 tray- dri p 22- 7/ 8l x 5 -1 /8 w 014533 1 1 103 t...

  • Page 44

    + available separately 40 parts list models 336, 338 & 339 de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r hose- rubber 1/ 2 id x 7/ 8 o d r50200 5' 5' 10' 000 + c l a m p -h o s e 3 /4 id c o n s t t e n s n 067113 4 4 000 new s tyle autom o ti ve + c l a m p ...

  • Page 45

    41 + available separately models 336, 338 & 339 parts list de s cri p t io n re m arks w arr. Cl as s 339 qty . 338 qty . 336 qty . Part num be r compressor c s18k6e- tf5- 2 3 052397- 33 1 1 512 220- 240v 50hz 3 ph / 380- 415v 50hz 3 n~ compressor - copeland 052397- 40 1 512 220- 240v 50hz 1 ph +cap...

  • Page 46

    Model 336 038333 rev. 7/12.

  • Page 47

    Model 336 038333-33 rev. 7/12.

  • Page 48

    Model 336 038333-62 rev. 7/12.

  • Page 49

    Model 338 051624--27 rev. 8/11.

  • Page 50

    Model 338 051624--33 rev. 8/11.

  • Page 51

    Model 339 046585--27 rev. 8/11.

  • Page 52

    Model 339 046585--33 rev. 8/11.

  • Page 53

    Model 339 046585-62 rev. 8/11.