1. DL manuals
  2. U-Line
  3. Refrigerator
  4. 2000 SERIES
  5. Use And Care Manual

U-Line 2000 SERIES Use And Care Manual

Summary of 2000 SERIES

  • Page 1

    ? 2000 series clear ice models clear combo ® models use and care guide clear combo® models clear ice the built-in undercounter leader since 1962 u-line.Com u-clr2160b-00 u-clr2160sod-00 u-clr2160b-40 u-clr2160sod-01 u-clr2160s-00 u-clr2160sod-40 u-clr2160s-01 u-clr2160sod-41 u-clr2160s-40 u-clr2160w...

  • Page 2

    Introduction to u-line for product assistance, call 1-800-779-2547 milwaukee, wi u.S.A. Serial/serie: model/modele: high side design pressure 300 psi low side design pressure 140 psi refrigerator and/ btl listed 674r or freezer household u c l r us www.U-line.Com 1 2 introduction congratulations on ...

  • Page 3

    U-line use and care table of contents 1 - safety precautions .....................................................................................................................................................1 safety alert definitions ..................................................................

  • Page 4

    1 precautions important important • please read all instructions before installing, operating, or servicing the appliance. • proper installation procedures must be followed when completing an installation or relocation of a unit. Consult the installation guide before any installation begins. U-line ...

  • Page 5

    U-line combo model and ice maker features 2 model features: high daily ice production and storage. The clr2160 produces up to 60 pounds of ice per day and stores up to 30 pounds. While the clrco2175 can produce up to 40 pounds of ice per day and store up to 15 pounds. Electronic control module. Auto...

  • Page 6

    3 u-line product operation air flow important important the unit requires proper air flow to perform at its highest efficiency. Do not block the front grille or internal fans at any time, or the unit will not perform as expected. Do not install the unit behind a door. Initial startup all u-line cont...

  • Page 7

    U-line product operation 4 checking product temperature to check the actual product temperature in the unit. 1. Partially fill a plastic (nonbreakable) bottle with water. 2. Insert an accurate thermometer. 3. Tighten the bottle cap securely. 4. Place the bottle in the desired area for 24 hours. 5. A...

  • Page 8

    5 u-line product operation electronic control quick guide task touch touch display comment turn on/off hold 5 seconds release when °f flashes. Or adjust temperature clrco2175 or touch and release or touch to change temperature °f flashes after first touch, set-point saved after 5 seconds of inactivi...

  • Page 9

    U-line ice makers 6 clear ice maker cleaning cycle units with a serial number beginning with an 09 or greater have an automatic clean alert function. Cleaning cycles should be run as notified. Otherwise, to maintain operational efficiency the unit should be cleaned every three months. Depending on w...

  • Page 10

    7 u-line ice maker important important • discard all ice produced in the first harvest. • should power to the unit be interrupted during the self-clean cycle, it will be necessary to repeat the complete cleaning cycle after power is restored. Refresh kit due to variations in water quality or inadequ...

  • Page 11

    U-line combo® models and ice makers maintenance 8 1 5 maintenance for models with adjustable leveling feet: 1. Use a level to check the levelness of the unit from front to back and from side to side. Place the level along top edge and side edge as shown (1). 2. If the unit is not level, rotate the a...

  • Page 12

    9 u-line combo® models and ice makers maintenance removing and installing door shelves for models equipped with door shelves: to remove the door shelf: 1. Grasp shelf in center, and lift until the shelf notches (1) clear the pins (2). 2. Carefully pull the shelf away from the door. To install the do...

  • Page 13

    U-line self closing doors 10 door alignment and adjustment align and adjust the door if it is not level, or is not sealing properly. If the door is not sealed the unit may not cool properly, or excessive frost may form in the interior. Important important • properly aligned, the door’s gasket should...

  • Page 14

    11 u-line self closing doors reversing black or white doors • the hinge hardware will be removed and reinstalled on the opposite side of the cabinet. • the top hinge hardware will be reinstalled on the bottom of the opposite side of the cabinet. • the bottom hinge hardware will be reinstalled on the...

  • Page 15

    U-line self closing doors 12 remove preexisting bottom hinge. 1. Remove the preexisting bottom hinge (three screws) (2). Reinstall hinge to top opposite. 1. Install the hinge just removed from the bottom to the top opposite side of the cabinet (three screws) (2). Reinstall hole plugs. 1. Install pla...

  • Page 16

    13 u-line self closing doors 3. Grasp outer edge of stainless frame and firmly press inside edge of glass in while pulling stainless frame in opposite direction. 4. Unhinge frame from door. Assemble stainless frame 1. Prop frame against solid surface, handle side down and away 2. Insert door, logo f...

  • Page 17

    U-line self closing doors 14 remove existing bottom hinge. 1. Remove the existing bottom hinge (three screws) (2). Reinstall hinge to top opposite. 1. Install the hinge just removed from the bottom to the top opposite side of the cabinet (three screws) (2). Reinstall hole plugs. 1. Install plastic s...

  • Page 18

    15 u-line combo® models and ice maker cleaning . Exterior cleaning vinyl clad (black or white) models: • clean surfaces with a mild detergent and warm water solution. Do not use solvent-based or abrasive cleaners. Use a soft sponge and rinse with clean water. Wipe with a soft, clean towel to prevent...

  • Page 19

    U-line combo® models and ice maker cleaning 16 condenser cleaning interval - every three months to maintain operational efficiency, keep the front grille free of dust and lint, and clean the condenser every three months. Depending on environmental conditions, more or less frequent cleaning may be ne...

  • Page 20

    17 u-line combo® models and ice makers service 8 service problem possible cause and remedy unit does not operate. Electronic display blank no electrical supply. Plug unit in or check circuit breaker. No interior light clrco2175, tighten or replace bulb, see maintenance) clr2160, contact service. Dis...

  • Page 21: Use and Care Guide

    ? use and care guide ©2009 u-line corporation publication number 30268 07/2012 rev. F the built-in undercounter leader since 1962 u-line.Com building on three generations of innovation for nearly five decades and three generations, u-line continues to be the leader in innovation, quality and value i...