1. DL manuals
  2. VAL Avionics
  3. Transceiver
  4. COM 2KR
  5. Installation And Operator's Manual

VAL Avionics COM 2KR Installation And Operator's Manual

Manual is about: Remote VHF Transceiver

Summary of COM 2KR

  • Page 1

    Val avionics ltd com 2kr remote vhf transceiver installation and operator’s manual revision 3 march 2013 p/n 172201-3.

  • Page 2

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 2 of 27 march 2013 revision history: september 2012 – initial printing december 2012 – updated appendix b wiring diagram to show rs-232 conn...

  • Page 3

    V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 3 of 27 march 2013 table of contents 1 section i - general information ................................................................................

  • Page 4

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 4 of 27 march 2013 1 section i - general information 1.1 introduction thank you for purchasing our com 2kr – remote vhf transceiver . Here a...

  • Page 5

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 5 of 27 march 2013 1.4 fcc the com 2kr transceiver is a voice-modulated communications device utilizing amplitude modulation, with a maximum...

  • Page 6

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 6 of 27 march 2013 1.5 specifications table 1: specifications specifications characteristics environmental: (rtca/do160d) minimum performanc...

  • Page 7

    V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 7 of 27 march 2013 1.6 equipment supplied table 2: equipment supplied qty description part number 1 com 2kr – 760 channel radio 0800106 1 installati...

  • Page 8: Section Ii -

    V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 8 of 27 march 2013 2 section ii - installation 2.1 general information 2.1.1 scope this section of the manual will provide the needed information to...

  • Page 9

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 9 of 27 march 2013 conductor shielded mil-c-27500 or equivalent wire must be used where indicated. Use amp contact crimping tool (amp p/n 60...

  • Page 10: Section Iii -

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 10 of 27 march 2013 3 section iii - operation 3.1 general information 3.1.1 scope this section will provide detailed operating instructions ...

  • Page 11: Section Iv -

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 11 of 27 march 2013 4 section iv - warranty and service 4.1 limited warranty the equipment delivered with this standard factory warranty is ...

  • Page 12: Appendix A

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 12 of 27 march 2013 5 appendix a – installation drawings and connector layout figure 1: physical dimensions figure 2: p1 connector pin out.

  • Page 13

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 13 of 27 march 2013 table 4: rear connector pin functions pin functoin i/o 1 rs-232 in input 2 aux in 2 input 3 speaker ground 4 headphone g...

  • Page 14: Appendix B

    V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 14 of 27 march 2013 6 appendix b – wiring diagrams figure 3: com 2k basic wiring diagram.

  • Page 15: Appendix C –

    V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 15 of 27 march 2013 7 appendix c – certifications 7.1 faa acceptability: this device has been tested and found to meet the specification of tso-c169...

  • Page 16: Appendix D

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 16 of 27 march 2013 8 appendix d – instructions for continued airworthiness 8.1 maintenance instructions maintenance of the com 2k...

  • Page 17: Appendix E –

    V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 17 of 27 march 2013 9 appendix e – rs-232 command interface this appendix includes the interface specifications for the rs-232 serial port. The rs-2...

  • Page 18

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 18 of 27 march 2013 9.5 message formats all messages will conform to the nmea 0183 proprietary message format as follows. All char...

  • Page 19

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 19 of 27 march 2013 9.6 message definitions 9.6.1 input messages request data output this input is used to request an output messa...

  • Page 20

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 20 of 27 march 2013 set active vor/loc frequency and receiver function this message is used to set the standby vor or localizer fr...

  • Page 21

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 21 of 27 march 2013 set standby comm frequency and transreceiver function this message is issued to set the standby com frequency....

  • Page 22

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 22 of 27 march 2013 this message is used to set the obs value used by the ins 429 as the elected radial for computing the course d...

  • Page 23

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 23 of 27 march 2013 9.6.2 output messages reset status this message is sent to indicate to the host that the ins 429 / com 2000 is...

  • Page 24

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 24 of 27 march 2013 this message indicates a full left cdi deflection (-127), a full up gsi deflection (127), both the gsi and nav...

  • Page 25

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 25 of 27 march 2013 communications error this message is used to indicate a communication error. Message format: “v” ................

  • Page 26

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 26 of 27 march 2013 “35” .................... Message identifier. Mk ...................... Active frequency: m = mhz, where m = d...

  • Page 27

    V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 27 of 27 march 2013 message format: "v".............. Message class - vhf nav message "72"............. Message identifier "ms" .....