- DL manuals
- VAL Avionics
- Transceiver
- COM 2KR
- Installation And Operator's Manual
VAL Avionics COM 2KR Installation And Operator's Manual - page 2
V A L A V I O N I C S L T D
C O M 2 K R – R E M O T E V H F T R A N S C E I V E R
I N S T A L L A T I O N A N D O P E R A T O R ’ S M A N U A L
Revision 3
Page 2 of 27
March 2013
Revision History:
September 2012 – Initial Printing
December 2012 – Updated Appendix B wiring diagram to show RS-232 connection.
Added dimensional drawings of COM 2KR case.
Figure 1 updated to current design.
Figure 3 & 4 Removed, as they are no longer accurate.
March 2013-
corrected typographical errors.
Corrected Table 4
Corrected Figure 3
Summary of COM 2KR
Page 1
Val avionics ltd com 2kr remote vhf transceiver installation and operator’s manual revision 3 march 2013 p/n 172201-3.
Page 2
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 2 of 27 march 2013 revision history: september 2012 – initial printing december 2012 – updated appendix b wiring diagram to show rs-232 conn...
Page 3
V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 3 of 27 march 2013 table of contents 1 section i - general information ................................................................................
Page 4
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 4 of 27 march 2013 1 section i - general information 1.1 introduction thank you for purchasing our com 2kr – remote vhf transceiver . Here a...
Page 5
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 5 of 27 march 2013 1.4 fcc the com 2kr transceiver is a voice-modulated communications device utilizing amplitude modulation, with a maximum...
Page 6
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 6 of 27 march 2013 1.5 specifications table 1: specifications specifications characteristics environmental: (rtca/do160d) minimum performanc...
Page 7
V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 7 of 27 march 2013 1.6 equipment supplied table 2: equipment supplied qty description part number 1 com 2kr – 760 channel radio 0800106 1 installati...
Page 8: Section Ii -
V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 8 of 27 march 2013 2 section ii - installation 2.1 general information 2.1.1 scope this section of the manual will provide the needed information to...
Page 9
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 9 of 27 march 2013 conductor shielded mil-c-27500 or equivalent wire must be used where indicated. Use amp contact crimping tool (amp p/n 60...
Page 10: Section Iii -
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 10 of 27 march 2013 3 section iii - operation 3.1 general information 3.1.1 scope this section will provide detailed operating instructions ...
Page 11: Section Iv -
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 11 of 27 march 2013 4 section iv - warranty and service 4.1 limited warranty the equipment delivered with this standard factory warranty is ...
Page 12: Appendix A
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 12 of 27 march 2013 5 appendix a – installation drawings and connector layout figure 1: physical dimensions figure 2: p1 connector pin out.
Page 13
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 13 of 27 march 2013 table 4: rear connector pin functions pin functoin i/o 1 rs-232 in input 2 aux in 2 input 3 speaker ground 4 headphone g...
Page 14: Appendix B
V a l a v i o n i c s l t d c o m 2 k r – r e m o t e v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 14 of 27 march 2013 6 appendix b – wiring diagrams figure 3: com 2k basic wiring diagram.
Page 15: Appendix C –
V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 15 of 27 march 2013 7 appendix c – certifications 7.1 faa acceptability: this device has been tested and found to meet the specification of tso-c169...
Page 16: Appendix D
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 16 of 27 march 2013 8 appendix d – instructions for continued airworthiness 8.1 maintenance instructions maintenance of the com 2k...
Page 17: Appendix E –
V a l a v i o n i c s l t d c o m 2 0 0 0 r – v h f t r a n s c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 17 of 27 march 2013 9 appendix e – rs-232 command interface this appendix includes the interface specifications for the rs-232 serial port. The rs-2...
Page 18
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 18 of 27 march 2013 9.5 message formats all messages will conform to the nmea 0183 proprietary message format as follows. All char...
Page 19
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 19 of 27 march 2013 9.6 message definitions 9.6.1 input messages request data output this input is used to request an output messa...
Page 20
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 20 of 27 march 2013 set active vor/loc frequency and receiver function this message is used to set the standby vor or localizer fr...
Page 21
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 21 of 27 march 2013 set standby comm frequency and transreceiver function this message is issued to set the standby com frequency....
Page 22
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 22 of 27 march 2013 this message is used to set the obs value used by the ins 429 as the elected radial for computing the course d...
Page 23
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 23 of 27 march 2013 9.6.2 output messages reset status this message is sent to indicate to the host that the ins 429 / com 2000 is...
Page 24
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 24 of 27 march 2013 this message indicates a full left cdi deflection (-127), a full up gsi deflection (127), both the gsi and nav...
Page 25
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 25 of 27 march 2013 communications error this message is used to indicate a communication error. Message format: “v” ................
Page 26
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 26 of 27 march 2013 “35” .................... Message identifier. Mk ...................... Active frequency: m = mhz, where m = d...
Page 27
V a l a v i o n i c s l t d i n s 4 2 9 i n t e g r a t e d n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l revision 3 page 27 of 27 march 2013 message format: "v".............. Message class - vhf nav message "72"............. Message identifier "ms" .....