Valtra T151eLS Operator's Manual - page 5
---4---
A. Detailed table of contents
A. Detailed table of contents
Serial numbers of your tractors
1
. . . . . . . . . . . . . . . . .
Main table of contents
2
. . . . . . . . . . . . . . . . . . . . . . . . . .
To the operator
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
A. Detailed table of contents
4
. . . . . . . . . . . . . . . . . . . .
B. Safety precautions
7
. . . . . . . . . . . . . . . . . . . . . . . . . .
B 1. Safety rules
7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C. General description
11
. . . . . . . . . . . . . . . . . . . . . . . . .
C 1. Illustration, VALTRA T151eLS, T61LS, T171LS,
T191LS
11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C 2. Service
15
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C 3. Engine
15
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C 3.1. Electronic engine management (EEM)
16
. . . . .
C 3.2. Common rail system engine
16
. . . . . . . . . . . . . .
C 4. Power transmission
17
. . . . . . . . . . . . . . . . . . . . . . . .
C 4.1. HiTech power shuttle
17
. . . . . . . . . . . . . . . . . . . .
C 4.3. Powershift
17
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C 5. Brakes
19
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
C 6. Steering system
19
. . . . . . . . . . . . . . . . . . . . . . . . . . .
C 7. Hydraulic system
20
. . . . . . . . . . . . . . . . . . . . . . . . . .
D. Instruments and controls
22
. . . . . . . . . . . . . . . . . . . .
D 1. Introduction
22
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 1.1. Pedals
22
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 1.2. Instrument panel
23
. . . . . . . . . . . . . . . . . . . . . . .
D 1.3. Right--- side panel / arm rest controls
24
. . . . . .
D 1.3.1. Tractor terminal
24
. . . . . . . . . . . . . . . . . . . . . .
D 1.3.2. Driving
25
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 1.3.3. Linkage/ Power take---off
26
. . . . . . . . . . . . . .
D 1.3.4. Auxiliary hydraulics
27
. . . . . . . . . . . . . . . . . . .
D 1.3.5. Other controls
28
. . . . . . . . . . . . . . . . . . . . . . .
D 1.4. Rear side controls
28
. . . . . . . . . . . . . . . . . . . . . .
D 1.5. Controls on LH side
29
. . . . . . . . . . . . . . . . . . . . .
D 1.6. Front roof console
29
. . . . . . . . . . . . . . . . . . . . . .
D 1.7. Right hand side roof console
30
. . . . . . . . . . . . .
D 1.8. Driver’s seat
31
. . . . . . . . . . . . . . . . . . . . . . . . . . .
D 1.9. Other controls
31
. . . . . . . . . . . . . . . . . . . . . . . . . .
D 2. Instruments and controls, more detail
32
. . . . . . . . .
D 2.1. Pedals
32
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 2.2. Instrument panel
33
. . . . . . . . . . . . . . . . . . . . . . .
D 2.2.3. Shuttle--- and parking brake lever
33
. . . . . . .
D 2.2.4. Pre---programming switch of Powershift
34
.
D 2.2.12. Proline---instrument panel
37
. . . . . . . . . . . .
D 2.2.12.7. Indicator lights on instrument panel
38
.
D 2.2.12.8. LCD---display unit (liquid crystal display)
in Proline instrument panel
39
. . . . . . .
1. Fixed displays
39
. . . . . . . . . . . . . . . . . . . . . . . . .
2. Displays chosen with change over switch
39
. .
3. Proline instrument panel LCD display (liquid
crystal display) setting switch
43
. . . . . . . . . . . . . . .
4. Changing the parameters of the Proline
instrument panel LCD display
(liquid crystal display)
43
. . . . . . . . . . . . . . . . . . . . .
D 2.3. Right---side panel / arm rest
48
. . . . . . . . . . . . . .
D 2.3.1.1. Control buttons
48
. . . . . . . . . . . . . . . . . . .
D 2.3.1.2.Main menu
49
. . . . . . . . . . . . . . . . . . . . . . .
1. Large drive display
49
. . . . . . . . . . . . . . . . . . . . .
2. Split screen drive display
52
. . . . . . . . . . . . . . . .
3. Settings for the auxiliary hydraulics
56
. . . . . . . .
4. Tractor information
58
. . . . . . . . . . . . . . . . . . . . . .
D 2.3.1.3.Resetting parameters
63
. . . . . . . . . . . . . .
1. Changing selection of driving start--- and
shuttle---automatic ON/OFF
63
. . . . . . . . . . . . . . . .
2. Resetting driving speed / tyre parameters
65
. .
3. Rear PTO engaging speed
65
. . . . . . . . . . . . . . .
4. Changing temperature unit of outdoor
temperature display
66
. . . . . . . . . . . . . . . . . . . . . . .
5. Changing driving speed unit
66
. . . . . . . . . . . . .
6. Calibrating speed sensors
67
. . . . . . . . . . . . . . .
D 2.3.2. Driving
68
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 2.3.2.7. Switch for Powershift---automatics
71
. . .
D 2.3.2.10. U---Pilot headland automatics
73
. . . . . .
1. General
73
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2. Range
74
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3. Switches
74
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4. Display
74
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5. Programming
75
. . . . . . . . . . . . . . . . . . . . . . . . . .
6. Example 1
76
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
7. Example 2
76
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
8. Use
76
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9. Error codes
77
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 2.3.3. Linkage /PTO
80
. . . . . . . . . . . . . . . . . . . . . . .
D 2.3.3.1. Rear linkage
80
. . . . . . . . . . . . . . . . . . . . . .
Drive balance control switch
81
. . . . . . . . . . . . . . . . .
Slip control
81
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radar
81
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D 2.3.3.2. Front linkage
82
. . . . . . . . . . . . . . . . . . . . .
D 2.3.3.3. Rear power take---off
82
. . . . . . . . . . . . . .
D 2.3.3.4. Front PTO
84
. . . . . . . . . . . . . . . . . . . . . . . .
D 2.3.4. Auxiliary hydraulics
85
. . . . . . . . . . . . . . . . . . .
D 2.3.5. Other controls
88
. . . . . . . . . . . . . . . . . . . . . . .
D 2.4. Controls on rear side
91
. . . . . . . . . . . . . . . . . . . .
D 2.5. Controls on LH side
91
. . . . . . . . . . . . . . . . . . . . .
D 2.6. Roof console on the front side
91
. . . . . . . . . . . .
D 2.7. Roof console on the right side
92
. . . . . . . . . . . .
D 2.8. Driver’s seat
93
. . . . . . . . . . . . . . . . . . . . . . . . . . .
D 2.9. Other controls
94
. . . . . . . . . . . . . . . . . . . . . . . . . .
E. Starting and running
95
. . . . . . . . . . . . . . . . . . . . . . . . .
E 1. Points to note during the first 50 hours running
95
.
E 2. Starting the engine
95
. . . . . . . . . . . . . . . . . . . . . . . . .
E 2.1. Normal start/cold start
95
. . . . . . . . . . . . . . . . . . .
E 2.2. Starting gas
96
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 2.3. Starting with an auxiliary battery
(jump starting)
96
. . . . . . . . . . . . . . . . . . . . . . . . .
E 3. Driving start
96
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 3.1. Accelerator pedal/ hand throttle
96
. . . . . . . . . . .
E 4. Driving
97
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 4.1. HiShift switch
97
. . . . . . . . . . . . . . . . . . . . . . . . . .
E 4.2. Power shuttle
97
. . . . . . . . . . . . . . . . . . . . . . . . . . .
E 4.2.1. Programming of Powershift
98
. . . . . . . . . . . .
E 4.3. Automatic traction control
98
. . . . . . . . . . . . . . . .
E 4.4. Powershift
98
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 4.4.1. Powershift---automatics
99
. . . . . . . . . . . . . . .
E 4.5. Cruise control
99
. . . . . . . . . . . . . . . . . . . . . . . . . .
E 4.6. Brakes
100
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 4.7. Differential lock
100
. . . . . . . . . . . . . . . . . . . . . . . . .
E 4.8. Four wheel drive
100
. . . . . . . . . . . . . . . . . . . . . . . .
E 4.9. Engine speed range selector (ECO), T151eLS 101
E 5. Stopping
101
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 6. Action to be taken during use
101
. . . . . . . . . . . . . . . .
E 6.1. Permitted driving inclinations for a tractor on a
slope (continuous driving) to ensure sufficient
lubrication
101
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E 6.2. Using chains
101
. . . . . . . . . . . . . . . . . . . . . . . . . . .
E 6.3. Off---road driving
102
. . . . . . . . . . . . . . . . . . . . . . . .
E 6.4. Door limiting
102
. . . . . . . . . . . . . . . . . . . . . . . . . . .
E 6.5. Rear mudguards adjustment
102
. . . . . . . . . . . . .
E 6.6. Front mudguards
102
. . . . . . . . . . . . . . . . . . . . . . .
E 6.7. Towing the tractor
102
. . . . . . . . . . . . . . . . . . . . . . .
F. Operating instructions
103
. . . . . . . . . . . . . . . . . . . . . . .
F 1. Power take---off (PTO)
104
. . . . . . . . . . . . . . . . . . . . . .
F 1.1. Sigma Power
105
. . . . . . . . . . . . . . . . . . . . . . . . . . .
F 1.2. Power take---off shafts
105
. . . . . . . . . . . . . . . . . . .
F 1.3. Proportional ground speed PTO
105
. . . . . . . . . . .
F 1.4. Checking the transmission ratio of a PTO driven
trailer for use with proportional ground
speed PTO
106
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
F 2. Trailer
106
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
F 2.1. Trailer socket
106
. . . . . . . . . . . . . . . . . . . . . . . . . . .
F 3. Three---point linkage
107
. . . . . . . . . . . . . . . . . . . . . . .