- DL manuals
- VENGEANCE
- Motorcycle
- Banshee 2005
- Owner's Manual
VENGEANCE Banshee 2005 Owner's Manual - Engine Break-In Period
V E N G E A N C E M O T O R C Y C L E S O W N E R S M A N U A L
- 45 -
Vengeance Motorcycles, Mira Loma, CA USA • 866-483-6432 • www.VengeanceMotorcycles.com
© 2004 Vengeance Performance Products, LLC All Rights Reserved • VOM 2nd Edition Rev 2.0 11/03
Engine Break-in Period
Qualified Vengeance Motorcycles factory technicians prepare your motorcycle to be ridden upon delivery. Besides
initiating the critical engine break-in period, a check of proper systems operations has been performed and any observed
deficiencies corrected. However, to prolong the life of the engine and other components, it is required that you complete
the critical engine break-in period and follow the break-in guidelines below. These procedures are required to maintain
the factory warranty and improper break-in may void your Vengeance Motorcycles Limited Warranty.
CAUTION: SYNTHETIC MOTOR OIL SHOULD NOT BE USED IN YOUR ENGINE UNTIL AFTER THE BREAK-IN
PROCEDURE IS COMPLETE. DO NOT MIX PETROLEUM-BASED, MINERAL AND SYNTHETIC MOTOR OILS.
THE FIRST 50 MILES
The first 50 miles are the most critical for new rings and piston break-in. Most engine damage will initially occur during this period.
1. Keep the heat down by not exceeding 2500 RPM.
2. Vary the engine speed; do not operate the motorcycle at a constant speed for sustained periods.
3. Pay close attention to gearshift speeds, do not lug or over-rev the engine and never rev the engine in neutral gear.
CAUTION: LUGGING, OVER-REVVING OR OPERATING THE ENGINE AT HIGH RPM'S DURING THE BREAK-IN
PERIOD MAY RESULT IN DAMAGE TO THE PISTONS AND/OR OTHER ENGINE COMPONENTS. IF THE
ENGINE IS NOT PROPERLY BROKEN IN, YOUR WARRANTY WILL BECOME VOID. IT IS YOUR
RESPONSIBILITY TO CONTINUE TO BREAK IN YOUR ENGINE PROPERLY AFTER PURCHASE.
THE NEXT 500 MILES
For the next 500 miles, you must do the following to ensure proper break-in:
1. Do not exceed 3500 RPM or 50-55 mph during this period.
2. As above, continue to vary the speed, especially during long rides.
3. Pay close attention to gearshift speeds, do not lug or over-rev the engine and never rev the engine in neutral gear.
4. Avoid running the engine in 4
th
or 5
th
gear at very low rpm.
5. Avoid aggressive starts or racing from a stop with the engine throttle wide open.
6. Change the engine oil and filter at an authorized Vengeance Motorcycles Dealer or Service Center.
CAUTION: YOU MUST HAVE THE COMPLETE 500-MILE SERVICE PERFORMED AT AN AUTHORIZED
VENGEANCE MOTORCYCLE COMPANY SERVICE FACILITY TO CONTINUE YOUR WARRANTY IN FORCE.
FAILURE TO DO SO WILL VOID YOUR WARRANTY.
THE FIRST 1,000 MILES
For the balance of the first 1,000 miles, observe the following guidelines:
1. Continue to operate the engine at varying speeds making sure not to exceed 70 mph.
2. Vary the engine speeds.
3. Avoid engine overheating.
4. Keep speed at or below 65 mph.
5. Change engine oil and filter.
THE NEXT 1,000 MILES
When the break-in period is between 1,000-2,500 miles, continue to follow the same procedures as before.
1. The RPM range can be slightly higher than 3500 RPM or 50-55 mph, if needed.
2. Avoid over-revving and continue to observe the gear shift speeds.
3. Avoid overheating the engine or putting any hard strain on it (such as drag racing, trailer towing, etc.).
2,500 + MILES
After following the above procedures, when you reach the 2,500 mile mark, you have properly broken in your
motorcycle. Complete the 2,500 mile service at an authorized Vengeance Motorcycles Dealer or Service Center,
enjoy your motorcycle, have fun, and drive safely.
Summary of Banshee 2005
Page 1
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 1 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 • vengeance warrior • vengeance raider • vengean...
Page 2
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 2 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 3: Welcome
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 3 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 welcome we thank you for your purchase of a veng...
Page 4
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 4 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 notes, warnings and cautions the notes, warnings...
Page 5: Table of Contents
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 5 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 table of contents welcome..........................
Page 6
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 6 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 break-in procedures ...............................
Page 7
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 7 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 you and your motorcycle: riding tips forward the...
Page 8
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 8 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 what to wear when you ride proper gear is essent...
Page 9
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 9 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 gloves always wear gloves. Even on a hot day. Th...
Page 10
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 10 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 know your motorcycle to be a safe rider, get to...
Page 11
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 11 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 the time to take your left foot off the peg and...
Page 12
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 12 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 maintenance there’s not much to maintain on a d...
Page 13
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 13 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 highway, byway, street and alley this is what i...
Page 14
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 14 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 and a little behind you who’s moving across the...
Page 15
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 15 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 the distance between you and the vehicle in fro...
Page 16
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 16 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 you might be in one of those two-mile-per-hour ...
Page 17
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 17 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 animals the biggest problem is with domestic an...
Page 18
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 18 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 group riding & passengers as we said earlier, m...
Page 19
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 19 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 lean as well. So have them look over your shoul...
Page 20
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 20 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 motorcycle skill test practice guide introducti...
Page 21
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 21 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 what to bring bring six small objects that you ...
Page 22
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 22 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 3. Close the throttle before braking. Squeeze t...
Page 23
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 23 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 exercise 5 - normal turns practicing this exerc...
Page 24
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 24 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 exercise 6b - sharp turns from a stop practicin...
Page 25
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 25 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 2. Straighten up the motorcycle and square the ...
Page 26
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 26 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 familiarization – major components know your mo...
Page 27
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 27 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 frame design and construction the frame is one ...
Page 28
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 28 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 suspension system the suspension system (both f...
Page 29
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 29 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 powertrain the powertrain of your vengeance mot...
Page 30
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 30 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 more speed. This pairing of different size gear...
Page 31
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 31 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 braking system the brake system is a hydraulic ...
Page 32
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 32 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 electrical system vengeance motorcycles are des...
Page 33: Controls And Operations
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 33 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 controls and operations ignition - light key sw...
Page 34
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 34 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 instrument cluster various indicator lights are...
Page 35
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 35 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 speedometer the speedometer provides a continuo...
Page 36
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 36 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 function switch the function switch is used for...
Page 37
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 37 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 headlamp hi/lo switch the headlight switch is l...
Page 38
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 38 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 engine stop switch the engine off/ run switch i...
Page 39
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 39 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 throttle control grip the throttle control grip...
Page 40
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 40 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 fuel enrichener controls the fuel enrichener le...
Page 41
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 41 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 brake system the front brake lever is on the ri...
Page 42
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 42 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 gear shift lever the gear shift lever is locate...
Page 43
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 43 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 using rear viewing mirrors is an excellent habi...
Page 44: Starting Your Motorcycle
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 44 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 starting your motorcycle the following starting...
Page 45: Engine Break-In Period
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 45 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 engine break-in period qualified vengeance moto...
Page 46: Operation
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 46 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 operation shifting gears there is more to shift...
Page 47: Braking And Stopping
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 47 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 braking and stopping proper braking technique i...
Page 48: Fuel Requirements
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 48 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 fuel requirements it is recommended that only p...
Page 49: Service And Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 49 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 service and maintenance you have purchased a hi...
Page 50
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 50 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 transmission oil check inspect the transmission...
Page 51
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 51 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 8. Refill the transmission through the side cov...
Page 52
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 52 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 2. Start and run the engine for approximately 1...
Page 53
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 53 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 front brakes the brake fluid level in the front...
Page 54
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 54 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 tire inflation pressure vengeance motorcycles o...
Page 55
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 55 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 fasteners check for loose or missing nuts, bolt...
Page 56
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 56 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 battery the battery is located underneath the s...
Page 57
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 57 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 warranty and regulations information your warra...
Page 58
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 58 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 vengeance motorycle company - limited warranty ...
Page 59
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 59 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 3. Limited liability a. The liability of vengea...
Page 60
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 60 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 noise control system maintenance vengeance moto...
Page 61: Reporting Safety Defects
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 61 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 reporting safety defects if you believe that yo...
Page 62: Limited Warranty
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 62 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 vengeance motorcycle company limited warranty t...
Page 63
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 63 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 transmission case is covered if damaged by the ...
Page 64
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 64 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 limited liability – legal rights • claims resul...
Page 65: Torque Specifications
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 65 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 torque specifications axle nuts.(front)...........
Page 66
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 66 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 engine service intervals and specifications eng...
Page 67: 500-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 67 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 500-mile maintenance change engine oil and oil ...
Page 68
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 68 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 69: 2,500-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 69 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 2,500-mile maintenance change engine oil and oi...
Page 70
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 70 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 71: 5,000-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 71 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 5,000-mile maintenance ٱ change engine oil and ...
Page 72
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 72 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 73: 7,500-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 73 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 7,500-mile maintenance ٱ change engine oil and ...
Page 74
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 74 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 75: 10,000-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 75 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 10,000-mile maintenance ٱ change engine oil and...
Page 76
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 76 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 77: Warranty Registration Form
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 77 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 warranty registration form to register this war...
Page 78
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 78 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 79
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 79 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 successive owner warranty registration form to ...
Page 80
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 80 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.