- DL manuals
- VENGEANCE
- Motorcycle
- Banshee 2005
- Owner's Manual
VENGEANCE Banshee 2005 Owner's Manual - Service And Maintenance
V E N G E A N C E M O T O R C Y C L E S O W N E R S M A N U A L
- 49 -
Vengeance Motorcycles, Mira Loma, CA USA • 866-483-6432 • www.VengeanceMotorcycles.com
© 2004 Vengeance Performance Products, LLC All Rights Reserved • VOM 2nd Edition Rev 2.0 11/03
SERVICE AND MAINTENANCE
You have purchased a high performance, heavyweight V-Twin motorcycle. Like any other high performance vehicle,
your motorcycle requires more frequent care, attention, adjustment, service, and maintenance than a typical
passenger vehicle. With a passenger vehicle, you can usually wait until something goes wrong and then fix it. When
something goes wrong with the motorcycle, it may cause an accident.
Like all mechanical devices, constant wear and tear on motorcycle parts and assemblies is a normal result of use.
Recommended periodic inspection, topping off or changing of fluids, and replacement of worn parts and assemblies is
the only way to ensure continuous, safe operation of your high performance motorcycle.
GENERAL MAINTENANCE PROCEDURES
Maintaining you motorcycle in a continuously safe operating condition and assuring optimal performance and
longevity, requires a coordinated effort between the owner and a professional, knowledgeable service staff. Service
and Maintenance is a strategic mix of owner pre-ride inspections, recommended service procedures, and authorized
“technician-performed” maintenance inspections, tests, and processes.
RIDER PRE-RIDE INSPECTION
1. Check engine oil, transmission, and both brake reservoir fluid levels.
2. Inspect brake components, brake hydraulic lines and fittings for leaks or damage, and brake pads and rotors
for excessive and/or uneven wear.
3. Test operation of brake lever, pedal, and calipers.
4. Check tires for proper inflation and general inspection of tire surfaces for uneven wear, excessive tread wear,
cuts or abrasions.
5. Check final drive belt for proper tension and condition.
6. Check headlight, taillight, brake light, and front and rear directional lights for proper operation.
7. Test throttle controls and steering for proper movement. Ensure all operating cables are in good condition and
free from interference.
8. Once the engine is started, verify proper engine idle speed and that throttle and choke controls are correct.
WARNING
TO MAINTAIN A SAFE OPERATING MOTORCYCLE, IT IS CRITICAL THAT THE RECOMMENDED
INSPECTION, MAINTENANCE, AND SERVICE PROCEDURES DESCRIBED IN THIS MANUAL ARE
STRICTLY ADHERED TO AND DOCUMENTATION BE MAINTAINED. FAILURE TO FOLLOW THESE
PROCEDURES COULD RESULT IN SERIOUS INJURY TO THE DRIVER, DAMAGE TO THE VEHICLE,
AND/OR LOSS OF THE LIMITED WARRANTY.
WARNING
STOP THE ENGINE AND SUPPORT THE MOTORCYCLE SECURELY BEFORE PERFORMING ALL SERVICE
PROCEDURES. SERVICE SHOULD BE PERFORMED USING PROPER TOOLS, IN AN ADEQUATELY LIT AND
VENTILATED WORK AREA. WHEN WORKING ON THE MOTORCYCLE, DO NOT SUPPORT THE
MOTORCYCLE BY PLACING SUPPORTS UNDER THE BRAKE PEDAL. DAMAGE TO THE BRAKE SYSTEM
COULD OCCUR, CAUSING POSSIBLE MALFUNCTION AND PERSONAL INJURY.
WARNING
FOR YOUR PERSONAL SAFETY, ALL THE LISTED SERVICE AND MAINTENANCE RECOMMENDATIONS
SHOULD BE FOLLOWED BECAUSE THEY MAY AFFECT THE SAFE OPERATION OF YOUR MOTORCYCLE.
Summary of Banshee 2005
Page 1
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 1 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 • vengeance warrior • vengeance raider • vengean...
Page 2
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 2 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 3: Welcome
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 3 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 welcome we thank you for your purchase of a veng...
Page 4
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 4 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 notes, warnings and cautions the notes, warnings...
Page 5: Table of Contents
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 5 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 table of contents welcome..........................
Page 6
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 6 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 break-in procedures ...............................
Page 7
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 7 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 you and your motorcycle: riding tips forward the...
Page 8
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 8 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 what to wear when you ride proper gear is essent...
Page 9
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 9 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 gloves always wear gloves. Even on a hot day. Th...
Page 10
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 10 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 know your motorcycle to be a safe rider, get to...
Page 11
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 11 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 the time to take your left foot off the peg and...
Page 12
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 12 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 maintenance there’s not much to maintain on a d...
Page 13
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 13 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 highway, byway, street and alley this is what i...
Page 14
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 14 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 and a little behind you who’s moving across the...
Page 15
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 15 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 the distance between you and the vehicle in fro...
Page 16
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 16 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 you might be in one of those two-mile-per-hour ...
Page 17
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 17 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 animals the biggest problem is with domestic an...
Page 18
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 18 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 group riding & passengers as we said earlier, m...
Page 19
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 19 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 lean as well. So have them look over your shoul...
Page 20
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 20 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 motorcycle skill test practice guide introducti...
Page 21
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 21 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 what to bring bring six small objects that you ...
Page 22
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 22 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 3. Close the throttle before braking. Squeeze t...
Page 23
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 23 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 exercise 5 - normal turns practicing this exerc...
Page 24
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 24 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 exercise 6b - sharp turns from a stop practicin...
Page 25
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 25 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 2. Straighten up the motorcycle and square the ...
Page 26
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 26 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 familiarization – major components know your mo...
Page 27
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 27 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 frame design and construction the frame is one ...
Page 28
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 28 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 suspension system the suspension system (both f...
Page 29
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 29 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 powertrain the powertrain of your vengeance mot...
Page 30
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 30 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 more speed. This pairing of different size gear...
Page 31
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 31 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 braking system the brake system is a hydraulic ...
Page 32
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 32 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 electrical system vengeance motorcycles are des...
Page 33: Controls And Operations
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 33 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 controls and operations ignition - light key sw...
Page 34
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 34 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 instrument cluster various indicator lights are...
Page 35
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 35 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 speedometer the speedometer provides a continuo...
Page 36
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 36 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 function switch the function switch is used for...
Page 37
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 37 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 headlamp hi/lo switch the headlight switch is l...
Page 38
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 38 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 engine stop switch the engine off/ run switch i...
Page 39
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 39 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 throttle control grip the throttle control grip...
Page 40
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 40 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 fuel enrichener controls the fuel enrichener le...
Page 41
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 41 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 brake system the front brake lever is on the ri...
Page 42
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 42 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 gear shift lever the gear shift lever is locate...
Page 43
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 43 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 using rear viewing mirrors is an excellent habi...
Page 44: Starting Your Motorcycle
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 44 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 starting your motorcycle the following starting...
Page 45: Engine Break-In Period
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 45 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 engine break-in period qualified vengeance moto...
Page 46: Operation
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 46 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 operation shifting gears there is more to shift...
Page 47: Braking And Stopping
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 47 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 braking and stopping proper braking technique i...
Page 48: Fuel Requirements
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 48 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 fuel requirements it is recommended that only p...
Page 49: Service And Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 49 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 service and maintenance you have purchased a hi...
Page 50
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 50 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 transmission oil check inspect the transmission...
Page 51
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 51 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 8. Refill the transmission through the side cov...
Page 52
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 52 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 2. Start and run the engine for approximately 1...
Page 53
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 53 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 front brakes the brake fluid level in the front...
Page 54
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 54 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 tire inflation pressure vengeance motorcycles o...
Page 55
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 55 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 fasteners check for loose or missing nuts, bolt...
Page 56
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 56 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 battery the battery is located underneath the s...
Page 57
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 57 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 warranty and regulations information your warra...
Page 58
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 58 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 vengeance motorycle company - limited warranty ...
Page 59
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 59 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 3. Limited liability a. The liability of vengea...
Page 60
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 60 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 noise control system maintenance vengeance moto...
Page 61: Reporting Safety Defects
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 61 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 reporting safety defects if you believe that yo...
Page 62: Limited Warranty
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 62 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 vengeance motorcycle company limited warranty t...
Page 63
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 63 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 transmission case is covered if damaged by the ...
Page 64
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 64 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 limited liability – legal rights • claims resul...
Page 65: Torque Specifications
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 65 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 torque specifications axle nuts.(front)...........
Page 66
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 66 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 engine service intervals and specifications eng...
Page 67: 500-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 67 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 500-mile maintenance change engine oil and oil ...
Page 68
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 68 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 69: 2,500-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 69 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 2,500-mile maintenance change engine oil and oi...
Page 70
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 70 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 71: 5,000-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 71 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 5,000-mile maintenance ٱ change engine oil and ...
Page 72
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 72 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 73: 7,500-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 73 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 7,500-mile maintenance ٱ change engine oil and ...
Page 74
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 74 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 75: 10,000-Mile Maintenance
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 75 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 10,000-mile maintenance ٱ change engine oil and...
Page 76
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 76 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 77: Warranty Registration Form
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 77 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 warranty registration form to register this war...
Page 78
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 78 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.
Page 79
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 79 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03 successive owner warranty registration form to ...
Page 80
V e n g e a n c e m o t o r c y c l e s o w n e r s m a n u a l - 80 - vengeance motorcycles, mira loma, ca usa • 866-483-6432 • www.Vengeancemotorcycles.Com © 2004 vengeance performance products, llc all rights reserved • vom 2nd edition rev 2.0 11/03.