1. DL manuals
  2. Verine
  3. Indoor Fireplace
  4. VLF45NG
  5. Installation, User And Servicing Instructions

Verine VLF45NG Installation, User And Servicing Instructions

Manual is about: VESTA LOG FIRE Manual & Remote Operated Models

Summary of VLF45NG

  • Page 1

    Vesta log fire vlf45ng, vlf45ng, vlf45p, vlf45p manual & remote operated models this is not a ‘do-it-yourself’ product this appliance must be installed by a corgi registered person installation, users and servicing instructions these products are approved to the european gas directive article i. Ple...

  • Page 2

    2 contents page no. List of components 3 appliance data 3 g eneral i nstallation r equirements 3 fitting the appliance 4 fitting the appliance into the optional radiant firebox 5 additional notes for handset remote control model 6 assembling the fire & the placing of the logs 8 c ommissioning 10 che...

  • Page 3

    3 before fitting this appliance, ensure that the following list of components are enclosed (a) vesta burner unit (b) 1 set ceramic base pieces (1 base, 1 lh side, 1 rh side, 1 front, 1 burner.) (c) 1 log set (4 pieces) (d) installation, user & servicing instructions (e) for handset remote models onl...

  • Page 4

    4 2 fireplace see figure 1 the radiant fireboxes can be fitted to fireplaces which meet the dimensional requirements shown in figure 1. Basket installations require a fireplace large enough to accommodate the basket chosen. Decorative frets should have a minimum of 50cm 2 (8 sq. Ins.) of free air sp...

  • Page 5

    5 if it is being drawn into the chimney proceed with the installation. If not, preheat the chimney over the period of a few minutes and recheck. If there is any doubt about the soundness of the chimney a smoke pellet should be used after preheating the flue and if smoke still fails to clear, further...

  • Page 6

    6 8 cut and form a section of 8mm pipe, only rigid or semi-rigid tube is acceptable, and run this into the fireplace opening. If a concealed fitting is required, care must be taken to sleeve the supply pipe when passing it through masonry. Exposed pipe within the fire opening should be wrapped, pain...

  • Page 7

    7 5 charging the battery pack the charger supplied with the battery pack is a true charger and will not overcharge the batteries. The charger has a built in switch so that it will switch off when the batteries in the pack are fully charged. The red led on the front face of the charger will light whe...

  • Page 8

    8 figure 5 7 ir signal receiver the signal receiver should be placed on the hearth just behind the ash pan cover such that it is visible to the user operating the remote control handset. If the receiver is covered in any way the fire will not operate. The receiver is secured to a bracket with a scre...

  • Page 9

    9 caution all the ceramic components are fragile and should be handled with care. 1 the burner tray and base ceramics are illustrated in figure 6. Position the burner ceramic making sure that the holes are aligned with the burner ports. Take the front ceramic and place it on the burner tray in front...

  • Page 10

    10 c ommissioning when commissioning your appliance, remove the cap from the isolator fitting and unscrew the plug all the way out. Replace the cap making sure that the tab engages with the slot in the top of the plug. Tighten cap securely. Light the appliance in accordance with the instructions rel...

  • Page 11

    11 u sers g uide useful tips and recommendations once your fire has been fitted, the following recommendations are made to ensure you enjoy the best results from your purchase; 1 the installation of this appliance must be carried out by a qualified installer and in accordance with the requirements o...

  • Page 12

    12 2 when the fire is first lit, the flames tend to be rather blue in colour. Once the core of the fire becomes hot, the flames will become yellow and more lifelike. During this initial warm-up period it is recommended that the control remains in the ‘max’ or ‘high’ position. This permits the fire t...

  • Page 13

    13 remote appliances 9 using the handset when using the handset make sure that it is pointed at the infra red signal receiver located under the front of the fire (the small black pad). Unlike a tv control the fire does not react to a quick press on the button on the handset control. The buttons must...

  • Page 14

    14 14 replacing the batteries as stated above, the batteries are of the nickel – metal - hydride type which have a long life and are able to be re-charged many times. Eventually, due to age and use, a point will come when they need recharging at inconveniently short intervals and they will have to b...

  • Page 15

    15 service and maintenance warning this product uses fuel effect pieces containing refractory ceramic fibre (rcf), which is man-made vitreous silicate fibres along with fibrous glass and mineral wool. Excessive exposure to these materials may cause temporary irritation to eyes, skin and respiratory ...

  • Page 16: Description

    16 spare parts list in the event of a part requiring replacement the parts list is as follows description verine part number oxygen depletion pilot assembly (natural gas only). P47 oxygen depletion pilot assembly (l.P.G. Propane only). P48 gas control bm valve (natural gas manual) inc. Piezo & ht le...

  • Page 17

    17 guarantee. 1. The appliance is guaranteed for one year from the date of purchase. 2. This guarantee is given subject to the following provisions:- a) the installation is carried out by a corgi registered person. B) that the fireplace conforms to the requirements given in the installation instruct...

  • Page 18

    18 installation & service record please ensure that installer completes the installation record below installation record appliance supplied by: ………………………….... Installation date: ……………serial no.: ….……... Installed by: …………..…...Corgi no.: …..…… signed by installer: ……………………………..… record of 1 st serv...

  • Page 19

    19.

  • Page 20: Verine Limited

    20 verine limited 52 broton drive trading estate halstead, essex co9 1hb tel: (01787) 472551 fax: (01787) 476589 email: sales@verine.Co.Uk website: www.Verine.Co.Uk log/1006/ii&ui this booklet contains 20 pages.