1 volcano collapsible stove 20-200 and 20-300 grills instructions for use for outdoor use only important “this instruction manual contains important information necessary for the proper assembly and safe use of the appliance.” “read and follow all warnings and instructions before assembling and usin...
2 contents general safety informa- tion p. 2-3 maintenance p. 10 to set up p. 6 troubleshooting p. 11 leak check p. 4-5 service p. 11 operation p. 7-8 things you should know p. 11 to light p. 8 replacement parts list p. 12 before cooking p. 8 contents p. 6 & 13 after cooking p. 8 accessories p. 14 t...
3 15. When frying, slowly submerse food products into the oil or grease. Do not drop. 16. Do not place an empty cooking vessel on burner while in opera- tion. Use caution when placing anything in the cooking vessel while burner is in operation. 17. In the event of rain, hail, sleet or other forms of...
4 lp tank valve must have: • type 1 outlet compatible with regulator or appliance. • safety relief valve. • ul listed overfill protection device (opd). This opd safety fea- ture is identified by a unique triangular hand wheel. Use only tanks equipped with this type of valve. • cylinders need to be u...
5 step 1 #20-300 grills • remove plastic cap from top of pro- pane cylinder. Save cap for use in storing. Screw regulator onto propane cylinder. Be careful not to cross-thread. Hand tighten only. • be sure regulator is tightly con- nected to lp tank. • make sure propane burner valve is off. Step 2 •...
6 to set up consumer notice: these assembly instructions are designed for stove models 20-200 and 20-300. Features shown may not be in more than one stove and will not be provided by this company or at the place you purchased your stove. Step 1 #20-300 grill • remove unit and regulator from packagin...
7 installing propane attachment step 1 • stand unit upright. • remove all grills and grates from the stove. • the venting system must be in the “open” position before installing the propane burner. Step 2 • place the propane burner in the bottom of the cooking chamber. • attach the brass tube end of...
8 to light wood/charcoal fuel source step 1 #20-200, #20-300 grills • install the bottom grate. • place wood or charcoal on the bottom grate. Note: do no overfill with wood. Overfilling will void the warranty. • light wood/charcoal with preferred method. Note: on first use, smoke may appear from the...
9 note: spiders and small insects can spin webs and build nests in- side the burner. This especially occurs in late summer and fall before frost when spiders are most active. These nests can obstruct gas flow and cause a fire in and around the burner and orifice. Such a fire can cause operator injur...
10 tear down/clean for wood/charcoal cont storage maintenance • clean out cooking chamber with mild detergent and soft cloth. • do not use abrasives. • disconnect regulator from cylinder. If stored indoors, detach and leave cylinder outdoors. • store propane tank in safe manner. Follow all local sto...
11 troubleshooting things you should know service 1. It is unsafe and illegal in some places to store or use propane cylinders of greater than 1.14 kg (2.5 lbs..) water capacity (ap- proximately 1 lb. Propane) in occupied enclosures. 2. If using refillable propane cylinder, use only manufacturers pa...
12 replacement parts - volcano collapsible stove 7 8 9 11 12 16 13 14 15 parts list item no . Description note qty 1 inner body 1 20 outer body 1 3 leg 3 4 vent adjusting bar must be open for propane use 1 5 vent adjusting ring 1 6 bail handle 1 7 top grill 1 8 heat deflector plate 1 9 bottom grate ...
13 volcano collapsible stove contents - 20-200 grill contents - 20-300 grill (1) volcano stove (1) instruction manual (1) bottom grate (1) top grill (1) heat diffuser plate (1) storage bag (1) volcano stove (1) propane burner (1) instruction manual (1) bottom grate (1) top grill (1) heat diffuser pl...
14 accessories the following accessories are available: volcano cookbook and technical manual # 30-600 volcano storage bag # 30-510 propane valve adaptor # 30-390 volcano lid # 30-700 trivet # 30-010 middle grill # 30-091 volcano flexible skewer # 30-800 handy handle # 30-020 roast rack # 30-050 vis...
15 notes.
16 warranty your volcano cook stove is covered by a one (1) year limited warranty from the original date of purchase against any manufacturing or material defects (exclud- ing paint). During this period of time, manufacturer will correct any defects or flaws associated with your cook stove by replac...
