Volcano 20-200 Instructions For Use Manual - page 8
8
To Light Wood/Charcoal Fuel Source
Step 1 #20-200, #20-300 GRILLS
• Install the bottom grate.
• Place wood or charcoal on the
bottom grate.
NOTE:
Do no overfill with
wood. Overfilling will void
the warranty.
• Light wood/charcoal with
preferred method.
NOTE:
On first use, smoke may appear from the cooking cham-
ber. This is normal and is the result of burning off the lubricant that
protects the stoves during shipment.
• If grilling, clean the top grill with
mild detergent before first use.
• Turn off gas supply completely
• If using wood or charcoal, make
sure any hot coals or debris are
extinguished.
• Let the unit cool completely.
Before Cooking
After Cooking
To Light Propane Fuel Source
Step 1 #20-300 GRILL
• Place a match in the provided
match lighting apparatus.
• Do not lean over stove while lighting
Step 2
• Remove all appliances from the
burner (including top grill) to create
a free flow of air.
• Turn regulator control valve to OFF
position.
• Fully open LP bottle valve.
• Light match and place it over burner .
Slowly turn ON the regulator control
valve. Do NOT stand with head or
arms over cooker.
• If ignition does not occur in five seconds, turn off gas supply and
wait 5 minutes before trying again.
• If flame is accidentally extinguished, turn off gas supply com-
pletely and wait 5 minutes.
NOTE:
On first use, smoke may appear from the cooking cham-
ber. This is normal and is the result of burning off the lubricant that
protects the stoves during shipment.
Turn regulator control valve to OFF position. Turn LP tank OFF by
turning hand-wheel clockwise to a full stop.
Attached to gas valve
Step 3
Burner Flame Check
• Light burner, turn regulator
control valve from high to
low. You should see a smaller
flame in low position than
seen on high. Always check
flame prior to each use.
A good flame should be blue
with minimal yellow tip. Some
yellow tips on flames are ac-
ceptable as long as no carbon or soot deposits appear.
Turning the LP Stove Off
Hose Check
• Before each use, check to see if hoses are cut or worn.
• Replace damaged hose assembly before using appliance. Use
only valve/hose/regulator specified by manufacturer. See product
sheet for hose and regulator information.