Xc90 section group weight(kg/pounds) year month 3 39 2004 04 xc90 2003, xc90 2004, xc90 2005, xc90 2006, xc90 2007, xc90 2008, xc90 2009, xc90 2010 replaces issue: 2002 05 xc90 section group weight(kg/pounds) year month 3 39 2004 04 xc90 2003, xc90 2004, xc90 2005, xc90 2006, xc90 2007, xc90 2008, x...
Required tools a0000162 a0801178 a0000161 r8802817 r3903989 installation instructions, accessories - subwoofer volvo car corporation göteborg, sweden installation instructions, accessories - subwoofer volvo car corporation göteborg, sweden © volvocar corporation, 2004 printed in sweden 9162298 © vol...
Any comments on this publication? Please contact your nearest dealer. Thank you! R3904979 publication no: ma 9162298, issue: 2004-04 comments:.......................................................................................................... ......................................................
Introduction ● note! Read through the whole installation instruction before starting the work. ● the front page gives the date of this edition and the edition it replaces ● the second page shows the tools needed for the installation and the contents of the installation kit ● the illustrations displa...
Caution! The air bag inflation areas must not be obstructed. Never place any objects, such as upholstery or accessories, within these areas. The panels must be able to open in the correct manner at the right time, otherwise there is an increased risk of personal injury in the event of a collision. C...
1 a8800136 preparatory work ● move the left front seat as far forward as possible ● turn the ignition key to position 0 ● disconnect the battery negative lead. Note! Wait at least five minutes before disassembling the connectors or removing other electrical equipment 2a r8902691 2b r8903031 preparat...
3 r8903030 preparatory work ● remove the side floor hatch (a) and the folding side panel (b) on the left-hand side in the cargo compartment. 4 r8504293 preparatory work applies to cars up to and including model year -2004 (ch -133999) applies to cars with two rows of seats ● remove the front storage...
7 r8504309 preparatory work ● remove the panel for the front mounting on the left-hand seat in the second row of seats by pressing down the catch (1) on top and detaching the panel by pulling it forward ● remove the screw underneath. 8 r8504310 preparatory work ● remove the panel for the front mount...
10b r8803236 use a weatherstrip tool. Illustration a ● continue to pull off the sill trim panel until the remaining clips release ● unhook the sill trim panel from the b-post panel. Place the sill trim panel in the cargo compartment ● remove the seat. Note! Lift the seat out of the passenger compart...
● pull the panel backwards to release it. 14 r8504123 preparatory work ● pull off the left-hand d-post panel starting at the top edge. Then pull downwards until the three clips on the inside have released. Do not damage the panel ● remove the panel by pulling upwards slightly and unhooking it from t...
16a r3904162 16b r8504104 preparatory work illustration a ● remove the rear electronic module (rem). First release the catch (1) on the top of the module ● fold the module forwards. Lift it out of the mountings (2) and place it to one side. Illustration b applies to cars with three rows of seats ● r...
19 r8504107 preparatory work ● take the left side panel and carefully cut away the insulation on its reverse to expose an area in front of the subwoofer. 20 r3903725 installing the subwoofer applies to cars with two rows of seats ● take the subwoofer, the four screws and the washer from the kit ● se...
22 r3703055 cable routing and connecting to the fusebox and subwoofer ● take the red cable from the cable harness. Install the cable on the reverse of the fusebox in position 13 and socket 2 as illustrated ● take the 15 amp fuse from the kit. Install the fuse in position 13 in the fusebox. 23 r37029...
26 r3702983 cable routing and connecting to the fusebox and subwoofer ● connect the two connectors on the cable harness to the two sockets underneath the amplifier section of the subwoofer. 27 r3702982 cable routing and connecting to the fusebox and subwoofer ● press the cable harnesses into place o...
29 r3702989 ● press down the catch on top of the largest connector (1) (14-pin). Pull it off the connector in the connector bridge. 30 r3702996 ● depress the catch on the red secondary lock on the connector. Pull the connector out to its limit position. 31 r3702997 ● take the violet cable and instal...
33 r3703449 ● connect the two bound connectors on the cable harness to the two sockets underneath the amplifier section of the subwoofer. 34 r3703438 ● press the cable harness connected to the subwoofer into the existing clamp. 35 r3703393 ● press in the catches on the rear brown connector in the fu...
37 r3703391 ● connect the new red (r) cable to terminal 19 in the connector. If the car is prepared for rear air conditioning (a/c) there is already a cable installed in this terminal. Disconnect the cable. Insulate the cable. Secure the cable. Press in the new red (r) cable instead ● press the conn...
41 r3702977 ● remove the fibre cable (1) from the connector (2). First carefully pry up the locking tab (3) and at the same time pull off the fibre optic cable. Note! Do not open the locking tab more than is necessary as it is fragile and easy to break. 42 r3702978 ● take the pre-routed cable harnes...
44 r8803234 finishing work ● reinstall the fibre optic cables and secure the two loose connectors at the existing cable harness. Use tape or tie straps from the kit. ● remove the shim under the polystyrene insulation and then reinstall. (applies to cars up to and including model year -2004 (ch -1339...
(applies to cars up to and including model year -2004 (ch -133999)) ● re-position the seats ● reinstall the folding panel. Note! Check that the seat belt is securely positioned by jerking the belt upwards. 45 a8800137 finishing work ● turn the ignition key to position ii ● reconnect the battery nega...
