User’s manual ：wy50qt-10 preface thanks for your purchasing the motorcycle wy50qt-10, and sincerely welcome you to be our motorcycle user. To enjoy a more safe and pleasurable driving, at first please familiarity with the manual must carry on before driving. Your personal safety depends not only the...
The important points to attention Ÿ the driver and passenger this motorcycle was limited to one driver and one passenger (except children younger than 12 years old). Never exceed the max load capacity of motorcycle. Ÿ for the safety, avoid driving the motorcycle in atrocious weather or cold weather ...
- 1 - Ⅰ. Motorcycle safe drive rule for safe drive only the driver can be sure the motorcycle safety. 1、 the motorcycle happens many accidents; all reasons are that the car drivers didn’t look at the motorcycle drivers. So the motorcycle drivers must: ※wear the bright color clothes. ※avoid driving a...
- 3 - ii. The parts & subassemblies and use manual parts & subassemblies （fig1、fig2） fig 1 meter and light fr .Brake handle battery luggage main stand production label - 4 - the broken line（……）indicate the parts unseen in the picture 。 fig2 rr.Brake handle oil box air cleaner seat lock starter side ...
- 5 - meter and indicator light （fig3） ⑴ odometer：records vehicle mileage。 ⑵speedometer ：when the vehicle, the speed of the vehicle。 ⑶fuel meter：show gasoline stocks。 ⑷ right turning indicate light： when turning lights when clicked, right button right turn indicator will shine。 ⑸headlight indicate l...
- 7 - fig 9 high-low beam switch 1（fig7） press “ ” button，to get high beam；press“ ”button，to get low beam. Turning light switch 2（fig7） when the switch is on“ ”, turn left; when the switch is on“ ” button, turn right. Press it down the light turn off. Horn switch 3（fig7） press this button, the horn ...
- 9 - iii. The operation ·inspection before riding make routine check-up before riding to insure the vehicle perform well and safe driving. Gasoline volume turn on the ignition switch and check the fuel meter, replenish gasoline when the pointer is close to red section, moreover, check the fuel tank...
- 11 - the free path of rear brake handle（fig14、fig16） measure the free path of rear brake handle before the detent function. The free path should be within （10～20）mm from the end of brake handle to calculate. • adjust nut： （a）increase the free path. （b）decrease the free path. After adjust, the axle...
- 13 - tyre check the tyre pressure periodically and adjust it if necessary. • check the tire pressure only when it is cooled. • check if there any metal trash or gravel in the groove of tyres，repair the tyre if leaking. • check if any metal trash or gravel in the groove of tires. If any impair plea...
- 15 - drive the motorcycle: warning: • wear the trousers to avoid touching with exhaust pipe and was burnt. • all the device must be installed according to requirement of the traffic rule. • take the license to ride. • each equipment of the motorcycle should accord with the traffic law of local gov...
- 17 - stopping engine（ fig 19、 fig 20） • close oil: revolve to the lowest place according to picture. (loosen the throttle grip in normal situation, and the engine is under idling speed mode) • turn the ignition switch to （ ） stop operation: when stop the motorcycle, put the key to（ ）position, put ...
- 19 - maintenance periodic table（table3） check before driving must be conducted while periodical maintenance (refer to page 9) i: check-up and adjustment if needed. C：clean r：change table3 speedometer（×1000km） 1 4 8 12 cycle item running in period ref page ﹡ fuel pipe i i i i ﹡ operation of the thr...
- 21 - obviate the simple trouble（table4） table4 trouble phenomenon trouble reason solution spark plug wear out change ignition wire wear out change cdi wear out change ignition switch wear out change spark plug no spark ignition come off or become flexible connect well or firm spark plug gap too sm...
- 23 - cleaning air filter （ fig 20） • take out air cleaner cover • screw up the blot. • take apart the core from air cleaner box. • compress air or use dry brush clean the filter element or put a new filter in the air clean box. • do the above opposite to reinstall the air filter. Notice： • do not ...
- 25 - oil replacement、machine oil oil filler strainer's clean change the oil（fig25） when replaces the machine oil, should when engine's temperature not yet cools, the automobile body carries on by the jiffy stand support reliable condition, guaranteed that fast and complete puts the machine oil cle...
- 27 - changing oil from gear box（fig25） proposal oil trademark sae 80w/90（using prevent frostbite oil in the very cooled area） oil capacity resolving capacity ：0.10l changing capacity ：0.09l place the vehicle by the main stand. • screw out the leaking bolt 1 and oil-drain bolt 2. Warning ： when lea...
- 29 - Ⅴ.Vehicle storage stockpile for the motorcycle not to be used for a long time, some steps should be taken to prevent malfunction and damage to the parts. Besides, before the long-time storage, proper repairs should also be done. • change the engine oil. • drain out the fuel in the fuel tank a...
- 31 - Ⅷ. Main technique parameter blank5 item parameter item parameter l×w×h mm 1690×645×1055 front tire 3.00-10 wheel base mm 1195 rear tire 3.00-10 ground clearance mm 135 pressure front tire kpa 180 dry weight kg 85 pressure reartire kpa 200 max payload kg 75 transmission automatic cvt turning a...
- 33 - Ⅸ. Circuit diagram - 34 - x. Emission control system warranty statement wangye usa co., llc is pleased to explain the emission control system warranty on highway motorcycle. New highway motorcycle must be designed, built and equipped to regulations and standards of the united states environme...
- 35 - the owner’s manual; (ii). Give notice to dealer approved by wangye usa co., llc or other qualified service facility of any and all apparent defects immediately upon discovery, and make the entire motorcycle available at the time for inspection and repair at the dealer’s place of business; (ii...
