Summary of WY50QT-58
Page 3: User’S Manual
User’s manual preface thanks for your purchasing the motorcycle wy50qt-58 , and sincerely welcome you to be our motorcycle user. To enjoy a more safe and pleasurable driving, firstly please familiarity with the manual must carry on before driving. Your personal safety depends not only on the vigilan...
Page 4
The important points to attention the driver and passenger this motorcycle is limited to one driver and one passenger (except children younger than 12 years old). Never exceed the max load capacity of motorcycle. for the safety, avoid driving the motorcycle in atrocious weather or cold weather (...
Page 5
Warning not following the operation instruction in this manual may cause great damage to you. Attention not following the operation instruction in this manual may cause injury to both you and vehicle. Regard this manual as a permanent part, even when transfering the vehicle to a new owner, transfer ...
Page 6
Contents Ⅰ. Notice for safe driving rules for safe driving …………………………1 payload ………………………………2 Ⅱ . Various parts name and instruction parts & subassemblies……… … ………………3 meter and indicator…… … ………………5 ignition switch………………………………5 fuel meter …………………………………6 headlight switch………………6 starting switch ………………...
Page 7
- 1 - Ⅶ、 tool set ……………………………28 Ⅷ、 main technique parameter … ……………29 Ⅸ. Circuit diagram ……………………31 Ⅹ.After sales service……………………32.
Page 8
- 1 - Ⅰ notice for safe driving rules for safe driving 1. Many traffic accidents are caused by the inability of car driver to notice the motorcyclist, so the motorcyclist should try his best to be noticed by other driver put on the coat in bright color. drive with great caution in the place with...
Page 9
- 2 - payload admonition: only put light goods in sundry boxes or other deposited place. The deposited shouldn’t be overweighted according to the following blank 1: blank 1 deposited weight (kg) carrier 5kg rear box 5kg the max payload of this motorcycle is 75kg, including the weight of the driv...
Page 10
- 3 - Ⅱ. Various parts name and instruction parts & subassemblies （fig1、fig2） front brake grip meter & indicator ignition switch luggage box battery main stand fig1.
Page 11
- 4 - lable rearbrake grip rear luggage carrier fuel trank cushion lock air filter kick start side stand fig2.
Page 12
- 5 - the broken line（……）indicate the parts unseen in the picture meter and indicator（fig3） ⑴fuel meter: indicate the fuel volume in the fuel tank ⑵right turnning signal : sparkling when the button turns ight ⑶odometer: record the mileage ⑷speedometer: show the speed when the vehicle running. ⑸high ...
Page 13
- 6 - engine is started and do not pull out the key. ⑵close( )—when the switch turns to this position, engine is stopped and take out the key . ⑶lock( )—when the switch turns to lock（ ） position, take out the key, don’t turn the handlebar, and don’t start the engine or turn on any light. Fuel meter（...
Page 14
- 7 - lighting switches （1） （fig6） lights, a total of three position switch ，is “ ” 、“ ”and “ ” “ ” in this position, headlight, position lamps, rear lamps and instrument lights “ ” in this position, the position lamps, rear lamps and instrument lights. “ ” in this position, the headlight, rear lamp...
Page 15
- 8 - horn switch 3（fig7） press switch, the horn make sound. Steering lock（ fig 8、 fig 9） turn handle left to end, press down ignition key to （ ）,the steering setting are locked. Do the above opposite, it is unlocked..
Page 16
- 9 - cushion lock（ fig 10） insert the key 1 into the key hole 2, then turn the key clockwise to open the cushion. Press down the cushion until a closedown voice is heard. Pull up the cushion’s rear side to make sure the cushion is locked well, then take out the key. Ⅲ. Operation instruction check u...
Page 17
- 10 - when the pointer or fuel meter is close to red section, replenish oil. And check whether the tank and the carburetor are in good condition. Gasoline tank container：4.5l turn the tank cover anti-clockwise to open the fuel tank (fig11） proposal gasoline, octane number is 90 above do not repleni...
Page 18
- 11 - 2. If the oil level reach to down limit sign (2), replenish the standard oil to the level below upper limit sign(3), then insert and screw down the lid back. Check if it’s in good situation suggested engine number: sae-15w/40 fig13 the free path of rear brake handle（ fig 14、 fig 15） measure t...
Page 19
- 12 - adjust nut： （a）increase the distance of free path. （b）reduce the distance of free path after adjust, the axle pin (2) should touch closely with nut (1) groove after adjust. Fig15 fig14 （10-20）mm ）.
Page 20
- 13 - abrasion mark of the brake （ fig 16） （1） reference marks （2） indicate marks. If fully brake. Change the brake block when reference marks and indicate marks are situated in a straight line. Notice : once maintenance for brake system is needed, find the nearest professional repair department . ...
Page 21
- 14 - it is dangerous to use a worn tire because the friction between tyre and road will be affected which will possibly bring trouble to driving or even cause an accident. Start engine ( fig 17) put the key into the key hole and turn to “ ”. Electric starter: press start button (1) to start engine...
Page 22
- 15 - drive motorcycle: warning: the temperature of exhaust pipe is much high during driving, you will be injured if touching with it carelessly, evn within little time after stopping, the tempreture can also cause injury, so wear trousers to protect your legs against injury. Wear helmet, glasses ,...
Page 23
- 16 - control the speed according to blank 2 blank 2 log（km） 0～200 200～500 500～1000 speed (km/h) ≤20 ≤30 ≤35 driving operation release main-stand and sit on the saddle ,step on the ground by left foot to make motorcycle plumb with floor . Turn the throttle when veh start, put your left leg back to ...
Page 24
- 17 - brake operation: 1. Control the throttle grip you must control the throttle grip and use both of the brake systems to slow down notice： drive with care when driving in bad situation like on moist or runny road, in a rainy day. Do brake operation, speedup operation or turning operation careful...
Page 25
- 18 - fig20 turn the ignition switch to （ ） parking operation: when parking, tun the key to（ ）position, put down the support and lock the handle well.（see p7） admonition：park the motor on a smooth ground, or it may fall down and cause injury. Fig21.
Page 26
- 19 - notice for anti-theft lock the steering and do not leave key in the key hole before you leave. Park the motor in a carbarn if possible. Mount a alarm system for your motor. Ⅳ、maintenance and service maintenance periodic form this maintenance is based on the odometer , see the maintenance peri...
Page 27
- 20 - quality as ours for replacement. Otherwise, the performance and operation function will be affected. Warning: for the safety of personnel, no matter whaterve maintenance work carries on, fisrt power off the engine , park the motor on a good ground and support the motor with stands well notice...
Page 28
- 21 - item every month 6 12 18 page ﹡ fuel pipe i i i i ﹡ throttle operation i i i i 15 21 ﹡ core of the air cleaner （note1） c/1000km, if need:r 22 ﹡ spark plug c/2000km, if need:r 26 ﹡ valve i i i i ﹡ engine oil （300km）r r （3000 km）r 24 ﹡ engine oil filter when change oil:c if need r 24 ﹡ the carb...
Page 29
- 22 - cyc item speedometer（×1000km） 1 4 8 12 ref page every month 6 12 18 ﹡ hanging system i i i ﹡ the nuts\bolts a 紧 （note2） i i ﹡ wheel, tyre i i i 12 ﹡ turning bearing i i * unless you are an expert on machine and hold a full set of tools and maintenance data, or leave your motor to a mechanic p...
Page 30
- 23 - solution for troubles（blank 4） blank 4 trouble phenomenon reason solution cann’t start the engine spark plug no spark spark plug wear out change ignition wire wear out change cdi wear out change ignition switch wear out change ignition come off or become flexible connect well or firm and tigh...
Page 31
- 24 - strength low valve seat washer worn out polish the piston-ring or the cylinder block worn seriously change them the piston-ring is broken or stored up the carbon to hinder very much change piston-ring or clear carbon blank 4 continue trouble phenomenon trouble reason solution the vehicle has ...
Page 32
- 25 - unsteady tyre pressure not enough pump front and rear axle released screw up nut the brake does not work the brake block wear and tear superlatively change brake cam wear and tear change brake cable is broken change free path too big adjust clean the air filter （fig20） take down the fixing bo...
Page 33
- 26 - notice：never take apart upper cover of the electrolyte. If you don’t use the motor for a long time. Please take off the battery and keep it in a ventilated and dry place if the peg of battery is corroded. Please take it off and clean.(use boiled water) notice: turn off the ignition switch bef...
Page 34
- 27 - minimum torque. After adjusting the idle speed, adjust free path of the throttle to 2-4mm. After adjusting, the engine speed can transit steadily when suddenly apply the throttle instead of turning off. Change oil （fig24） change oil only when the engine is not cooled yet and the vehicle is ...
Page 35
- 28 - minutes, then turn it off. Measure the oil volume of engine again to make sure it does not leak . Change gear oil （fig 25） we suggest oil octane number: sae 80w/90（ you can use antifreezing oil in very cold area） oil capacity resolving capacity: 0.10l changing capacity : 0.09l place the vehic...
Page 36
- 29 - spark plug （fig26） spark plug specification standard： c7hsa(ngk) or a7t、a7rt disconnect the joint of the spark plug cover and take apart the spark plugwith special spanner check if there is any burnning ash or accumulated dirt on electrode or porcelain head, if it singed badly, replace the sp...
Page 37
- 30 - use the brass wires to replace the fuse. Ⅴ. Vehicle storage storage if the vehicle hasn’t been used for a long time, some steps should be taken to prevent malfunction and damage to the parts. Besides, before the long-time storage, proper repairs should also be done. Change the engine oil. Dra...
Page 38
- 31 - oil on other metal parts. Cover the vehicle and put it in a cool place. Use the vehicle after long-time storage take off the cover and clean the vehicle. You should change the oil after 4 months above storage. Charge the battery if necessary, and fix it on. Check all the parts before driving ...
Page 39
- 32 - Ⅵ. Vehicle identification . Position of the model code, vehicle identification number and label （ fig 27） provide the numbers above when register to get the license ,do yearly inspection, and enjoy the after-service . The rivet for fixing name plate is on the right side of main stand . Vehicl...
Page 40
- 33 - Ⅶ. Tool set toolbox （fig28） is placed in the luggage box under the saddle, and toolbox contains the following tools: wrench 8x10mm wrench 12x14mm screwdriver hexagonal wrench handle of screwdriver sleeve wrench 18.5x17 fig28.
Page 41
- 34 - Ⅷ. Main technique parameter table5 item parameter item parameter l×w×h (mm) 1905×705×1160 front tire 120/70-12 wheel base (mm) 1315 rear tire 120/70-12 ground clearance (mm) 140 pressure of front tire kpa 180 dry weight kg 92 pressure of rear tire (kpa) 200 max payload kg 75 derailleur auto s...
Page 42
- 35 - inclination -1.3% battery 12v 7ah start model electric/kick oil capacity l 4.5 add table5 item parameter item parameter lubricating way press and splash fuse 15 a rated power 2.2/7000 r/min headlight 12v 18w/18w×2 max torque 3.0/6000 r/min tail light/brake light 12v 5w/21w compression ratio 1...
Page 43
- 36 - Ⅸ. Circuit diagram.
Page 44
- 37 - x. After sales service.
Page 45
- 38 - Ⅰ.General rules: after your buying the wangye motorcycle, please drive and maintain it as the manual instruction. According the regulation of document no. (1997) 205, we guarantee you the following services in one year or 6000km when you show us the warrants. Ⅱ.Guaranteed service 1. Free-repa...
Page 46
- 39 - within 7days of sales; the malfunctions occur in the regulation of document no. (1997) 205. 3.2 the user can ask for returning if the malfunctions are accord with the change service but we haven’t the same model. 3.3 if the malfunctions are accord with the change service, and we have the same...
Page 47
- 40 - after-service: 0576-84067902 0576-84359612 sales tel: 0576-84067899.