User’s manual ：wy50qt-58 preface thanks for your purchasing the motorcycle wy50qt-58 , and sincerely welcome you to be our motorcycle user. To enjoy a more safe and pleasurable driving, firstly please familiarity with the manual must carry on before driving. Your personal safety depends not only on ...
The important points to attention l the driver and passenger this motorcycle is limited to one driver. Never exceed the max load capacity of motorcycle. L for the safety, avoid driving the motorcycle in atrocious weather or cold weather (under -12℃). L for the road condition only drive on the highro...
Contents Ⅰ. Notice for safe driving rules for safe driving …………………………1 payload…………………………………………2 Ⅱ . Various parts name and instruction parts & subassemblies……… … ………………3 meter and indicator…… … ……………………5 ignition switch………………………………5 fuel meter …………………… … ……………6 lighting switchs ………… …………… ……6 starti...
- 2 - payload l admonition: only put light goods in sundry boxes or other deposited place. The deposited shouldn’t be overweighted according to the following blank 1: blank 1 deposited weight (kg) carrier 5kg rear box 5kg l the max payload of this motorcycle is 75kg, including the weight of the driv...
- 4 - the broken line（……）indicate the parts unseen in the picture fig2 - 5 - meter and indicator（fig3） ⑴fuel meter: indicate the fuel volume in the fuel tank ⑵right turning signal : sparkling when the button turns right ⑶odometer: record the mileage ⑷speedometer: show the speed when the vehicle runn...
- 6 - fuel meter（fig5） • fuel meter (1) indicate the fuel volume in the fuel tank. When the needle points to (f), it indicates that the effective residue fuel is 5l. When the needle points at red section, it indicates the remainder of fuel is 1.2l lighting switches （1） （fig6） lights, a total of thre...
- 8 - cushion lock（ fig 10） • insert the key 1 into the key hole 2, then turn the key clockwise to open the cushion. • press down the cushion until a closedown voice is heard. Pull up the cushion’s rear side to make sure the cushion is locked well, then take out the key. Fig8 fig9 fig10 - 9 - Ⅲ. Ope...
- 10 - inspection of engine oil inspect the engine oil level（fig12、fig13） 1. Keep the motor steady on the ground, screw up the oil dip rod and clean it, then reinsert and inspect oil. 2. If the oil level reach to down limit sign (2), replenish the standard oil to the level below upper limit sign(3),...
- 12 - abrasion mark of the brake （ fig 16） （1） reference marks （2） indicate marks. If fully brake. Change the brake block when reference marks and indicate marks are situated in a straight line. Notice : once maintenance for brake system is needed, find the nearest professional repair department . ...
- 14 - drive motorcycle: warning: • the temperature of exhaust pipe is much high during driving, you will be injured if touching with it carelessly, evn within little time after stopping, the tempreture can also cause injury, so wear trousers to protect your legs against injury. • wear helmet, glass...
- 16 - fig18 2. Front brake and rear brake work at the same time notice： when driving down on a cliffy brae, close the accelerograph entirely and use both of the brake system to make the speed lower . Don’t do brake operation continuously to make it too hot, which will affect the performance of brak...
- 18 - Ⅳ、maintenance and service maintenance periodic form this maintenance is based on the odometer , see the maintenance periodic form as an important guide for your motor’s maintenance on schedule. You should increase the frequency of maintenance if you use the motor at a high speed in a bad situ...
- 20 - blank3 continue speedometer（×1000km） cyc item every month 1 4 8 12 ref page ﹡ rotate the belt c/1000km i, if need:r ﹡ gearbox engine oil （note3） （300km）r i 26 brake system i i i i 11 brake cock i i i ﹡ head light i i i ﹡ hanging system i i i ﹡ the nuts\bolts （note2） i i *﹡ wheel, tyre i i i 1...
- 22 - blank 4 continue trouble phenomenon trouble reason solution the octane value of the fuel is too low change flue oil path blocked clean oil path ignition in wrong time check wire and change cdi spark too weak or flameout check ignition and clear out mixed air too dense or too thin clean adjust...
- 24 - idle speed adjustment （fig22、fig23） the carburetor has been adjusted to the best situation before selling out. If it is not well adjusted, ask a professional person to adjust it as the following instruction . • warm up several minutes after engine starts • screw the bolt 1 in slightly to incr...
- 26 - change gear oil （fig 25） we suggest oil octane number: sae 80w/90（ you can use antifreezing oil in very cold area） oil capacity changing capacity : 0.1l • place the vehicle by the main stand. • screw out the immersion bolt 1 and oil-drain bolt 2. • notice ： when draining the oil, the engine n...
- 28 - v . Vehicle storage storage if the vehicle hasn’t been used for a long time, some steps should be taken to prevent malfunction and damage to the parts. Besides, before the long-time storage, proper repairs should also be done. • change the engine oil. • drain out the fuel in the fuel tank and...
- 30 - Ⅶ. Tool set toolbox （fig28） is placed in the luggage box under the saddle, and toolbox contains the following tools: wrench 8x10mm wrench 12×14mm screwdriver hexagonal wrench handle of screwdriver sleeve wrench 18.5×17mm fig28 - 31 - Ⅷ. Main technique parameter table5 item parameter item para...
- 32 - add table5 item parameter item parameter lubricating way press and splash fuse 15 a rated power r/min 2.2/7500 headlight 12v 18w/18w×2 max torque r/min 3.0/7500 tail light/stop light 12v 5w/21w compression ratio 10.5：1 license plate light 12v 5w specification of spark plug c7hsa(ngk)or a7tc、a...
- 34 - Ⅹ. Emission control system warranty statement wangye usa co., llc is pleased to explain the emission control system warranty on highway motorcycle. New highway motorcycle must be designed, built and equipped to regulations and standards of the united states environmental protection agency and...
- 36 - service inspections; (vii). Pre-delivery inspection and assembly; (viii). Damage from theft, fire, vandalism, explosion, water or acts of god. 4. Restriction this warranty is in addition to, and not a modification of, any legal warranty required by the laws of any state of us. Subject to any ...
