Summary of Portable Skid Toilet
Page 1
Portable skid toilet patents pending operations manual revised 13 may 2005.
Page 2
Startup before using, turn on air compressor in the control cabinet (shown on page 6) and fill water tank (page 3). Flush a few times until water completely fills the system (twice usually does the job). Flush by pushing and momentarily holding the flush button at the rear of the stool. Toilet is re...
Page 3
Cleaning the toilet use microphor’s micro-clean organic spray cleaner, p/n 24542 or equivalent. Note: sanitizers like lysol, pine-sol, hezol or ammonia base products should never be used. These sanitizers when flushed into the treatment tank can stop the biological action. Never use any anti-bacteri...
Page 4
(microphor #39014 bare or #95008 valve w/fittings) if the a/w sequence valve becomes erratic the following trouble shooting action can be taken: a. Flush button sticks: if the flush button becomes sticky and does not press down and return freely, apply silicone lubricant directly onto the shaft, pre...
Page 5
Chlorinator in the microphor process, the effluent from the treatment tank flows through the chlorinator which is to be kept full of chlorine slugs. The chlorinator is located on the side of the treatment tank. Chlorinator the chlorinator should be filled as full as possible with chlorine slugs whil...
Page 6
Secondary chlorinator the secondary chlorinator is a contact chamber designed to hold effluent long enough to give the chlorine an opportunity to kill the bacteria contained in the effluent. Effluent is displaced from the secondary chamber into an evaporation pan under the treatment tank to avoid pu...
Page 7
Solar panel 7 fcm’s portable skid mount toilet is powered by compressed air which is furnished by the 1.5 cfm air compressor located in the control cabinet. A deep cycle battery powers the compressor and the solar panel keeps the battery charged. For best results keep the solar panel faced to the so...
Page 8
8 troubleshooting your microflush toilet is designed to give you years of trouble-free operation. Please check the following before beginning any service or repair. Water supply: 1. Is the water shut-off valve turned to “on” position? Air system: 1. Is compressed air attached (on rail unit)? 2. Is a...
Page 9: Material Safety Data Sheet
9 material safety data sheet microphor chlorinating slugs i - product identification product: trichloroisocyanuric acid chemical family: chloroisocyanurate synonym: microphor chlorinating slugs formula: c3cl3n3o3 cas number: 87-90-1 epa registration number: 69681-5-50754 california epa registration ...
Page 10
10 conditions to avoid: do not package in paper or cardboard. Note: contact with small amounts of water may result in an exothermic reaction with the liberation to toxic fumes. Heating above 225°c. Incompatibility: organic materials, reducing agents, nitrogen containing materials, other oxidizers, a...
Page 11
11 precautions to be taken in handling and storage: handling: avoid bodily contact. Do not take internally. Upon contact with skin and eyes, wash off with water. Storage: store in a dry, cool, well-ventilated area away from incompatible materials (see "materials to avoid"). Product has an indefinite...
Page 12: Material Safety Data Sheet
12 this product is toxic to fish and aquatic organisms. Do not contaminate water by cleaning of equipment or disposal of wastes. Do not discharge effluent containing this product into lakes, streams, ponds, estuaries, oceans, or other waters unless in accordance with the requirements of a national p...
Page 13
13 aggravation of pre-existing conditions: kidney disorders. Iv - first aid measures inhalation: remove to fresh air. Not expected to require first aid measures. Ingestion: not expected to require first aid measures. Give several glasses of water to drink to dilute. If large amounts were swallowed, ...
Page 14
14 wear protective gloves and clean body-covering clothing. Eye protection: use chemical safety goggles. Maintain eye wash fountain and quick-drench facilities in work area. Ix - physical and chemical properties appearance: clear oily liquid. Odor: odorless. Solubility: miscible in water. Specific g...
Page 15
15 xiv - transport information not regulated. Xv - regulatory information --------\chemical inventory status - part 1\--------------------------------- ingredient tsca ec japan australia ----------------------------------------------- ---- --- ----- --------- propylene glycol (57-55-6) yes yes yes y...