1. DL manuals
  2. Watts Premier
  3. Water System
  4. PUR-TEK
  5. Installation, Operation And Maintenance Manual

Watts Premier PUR-TEK Installation, Operation And Maintenance Manual

Summary of PUR-TEK

  • Page 1

    Page 1 installation, operation and maintenance manual 5 sv deluxe watts premier 25 cro-tfm-5sv ultra 5 ro-tfm-4sv ro-tfm-5sv pur-tek refer to enclosed warranty for operating parameters to ensure proper use with your water supply. Watts premier, inc. 1725 w. Williams drive c-20 phoenix, az 85027 phon...

  • Page 2: Table of Contents

    Page 2 thank you for your purchase of a premier reverse osmosis system. With proper installation and mainte- nance, this system will provide you with high quality water for years to come. All of premier's water enhance- ment products are rigorously tested by independent laboratories for safety and r...

  • Page 3: Operational Parameters

    Page 3 hardness: recommended hardness not to exceed 10 grains per gallon, or 120ppm. System will operate with hardness over 10 grains but the membrane life may be shortened. Addition of a water softener may lengthen the membrane life. Do not use with water that is microbiologically unsafe or of unkn...

  • Page 4

    Page 4 note: make sure the surroundings of the sink are cooled before mounting the faucet to the sink after drilling. Remove all sharp edges with a file. Step 3 step 4 determine desired location for the faucet on your sink and place a piece of masking tape on location where the hole is to be drilled...

  • Page 5: Wave Faucet Installation

    Page 5 • faucet assembly • black shank nut • slotted washer • gasket • 3' blue tube if using the wave air gap faucet (included), a 1 1/4" hole will be required. If using a wave non air gap faucet, a 3/4” hole will be required. Wave faucet installation remove black stem nut and insert the three tubes...

  • Page 6

    Page 6 ag-ss with monitor faucet installation step 6 step 7 step 8 gather and identify the m-500 faucet pieces. Step 10 note: a dripping or gurgling sound may be heard coming from the air gap hole on the faucet or the drain when the system is running. This is normal and in compliance with upc (unive...

  • Page 7: Adapta Valve Installation

    Page 7 adapta valve installation turn off the cold water supply to the faucet by turning the angle stop valve completely off. Reverse osmosis module mounting step 13 determine best location for the ro module to be mounted to allow for future system maintenance. The parts bag has 2 self tapping screw...

  • Page 8: Drain Saddle Installation

    Page 8 drain saddle fits standard 1 ¼” – 1 ½” drain pipes drain saddle installation step 14 step 15 step 16 thread the brass tee (supplied in the parts bag) onto the brass connection on the top of tank. Tighten using an adjustable wrench. Step 17 step 18 teflon tape must be applied in a clockwise di...

  • Page 9: Green Tube Connection

    Page 9 green tube connection drape the green tube connected to the 90° inlet white plastic elbow on the left side of the reverse osmosis module over to the adapta valve attached to the cold water sink faucet or attached to the angle stop valve, leaving a gentle curve in the tubing. Cut to desired le...

  • Page 10: Black Tube Connection

    Page 10 black tube connection measure the black tube from faucet to the black drain saddle and make a straight cut with a sharp knife though tube. Remove black plastic nut from drain saddle. Slip black tube through black nut. Insert black tube into the opening in the drain saddle and tighten the bla...

  • Page 11

    Page 11 thread the 2 white plastic connectors into the final filter and tighten. Step 29 to install the 6" filter cut the blue tube from the faucet approximately in half. Insert the blue tube attached to the faucet into the “out” port of the filter. The flow arrow should be pointing toward the fauce...

  • Page 12: Start Up Instructions

    Page 12 start up instructions fill out postage paid warranty card (phone no. Is necessary for registration) and drop it in the mail. Premier uses this information to provide a free filter change reminder service. Pre-filters should be changed every six months. You may also register your warranty via...

  • Page 13: 6 Month System Maintenance

    Page 13 √ one 10” sediment filter √ two 10” carbon filters √ bucket to catch water from filter housings. √ wrench to loosen filter bowls. (watts premier also sells a double sided wrench). Clean all filter housings (bowls) with a mild soap solution and rinse with water. Check o-rings and lubricate wi...

  • Page 14: Annual Maintenance

    Page 14 important: follow step 10 – 11 only if you have gac (hard plastic carbon filter.) if carbon particles are not rinsed out they may clog the flow restrictor which could then foul the membrane. The carbon block filter does not need to be flushed. Perform steps 4, 5 and 6 in the start up instruc...

  • Page 15: Membrane Maintenance

    Page 15 membrane maintenance membranes have a life expectancy of between 2 and 5 years, depending on the incoming water conditions and the amount of use of the ro system. Normally, a membrane would be replaced during a semiannual or annual filter change. However, if at any time you notice a reductio...

  • Page 16

    Page 16 to be properly seated the tip of the membrane must be below the housing edge. After replacing membrane housing into clips, attach the green tube to the elbow on cap using 5/8" wrench. The flow restrictor must be changed each time you change the membrane. Replace the existing flow restrictor ...

  • Page 17: Trouble Shooting

    Page 17 trouble shooting m e l b o r p e s u a c s n o i t u l o s n o i t c u d o r p w o l s / w o l . 1 e r u s s e r p r e t a w w o l . E r u s s e r p r e t a w g n i m o c n i i s p 0 4 f o m u m i n i m a e r u s s a s i e r u s s e r p r e t a w e m o h f i p m u p r e t s o o b a s l l e s...

  • Page 18

    Page 19 item # part # description 16 125041 uni-pl-1/4cx1/4c 17 131002 nut-br-1/4c” 18 131012 sleeve-delrin-1/4" 19 131017 insert-br-1/4" 20 131021 hex nipple-br-1/4 heavy duty 21 131023 tee-tank-br-1/4cx1/4cx1/4f 22 134002 valve-shut off 1/4mpt (res.) 23 a 134007 valve-adapta valve 24 134011 valve-...

  • Page 19: California Certification

    Page 19 california certification.

  • Page 20

    Page 20 recommended replacement parts and change intervals: note: depending on incoming feed water conditions replacement time frame may vary. Description change time frame price sediment pre-filter: #5m-10 6 months $4.50 carbon pre-filter: #gac-410-56/#5mcb 6 months $9.00/10.50 final carbon filter ...

  • Page 21

    Page 21 watts premier has other fine water filtration products and accessories to enhance your water and to compliment your existing ro system. Listed on the next several pages are only a few of the items we offer. Visit our website at www.Wattspremier.Com or call our customer service representative...

  • Page 22

    Page 22 wave faucets by watts premier allow for a variety of choices to match your kitchen decor. Available colors include: part no. 116022 chrome $30.95 part no. 116010 white $27.95 part no. 116026 black $27.95 part no. 116021 almond $27.95 part no. 116002 black on chrome $25.95 part no. 116006 whi...

  • Page 23

    Page 23 filtered showers...”you can feel the difference” chlorine in your shower…. It kills germs, bacteria and other microorganisms. It also readily passes through cell walls, and attaches to fatty acids in the cell, disrupting life-sustaining functions. The human body is composed of billions of si...

  • Page 24

    Page 24.

  • Page 25: 4 Ways to Register

    Page 25 4 ways to register 1. Online at www.Wattspremier.Com 2. Call in your information 1-800-752-5582 3. Fax in your information 623-931-0191 first name:_________________________ last name:____________________________ address: ________________________________________ city: ____________________ sta...

  • Page 26: Warranty Registration

    Page 26 warranty registration please fill out and keep for your records insert into envalope and return to watts premier first name:_________________________ last name:____________________________ address: ________________________________________ city: ____________________ state: ___________________...

  • Page 27: Service Record

    Page 27 service record date of purchase:__________ date of install:___________ installed by:__________________ e t a d e g a t s t s 1 t n e m i d e s ) s h t n o m 6 ( e g a t s d n 2 n o b r a c ) s h t n o m 6 ( e g a t s d r 3 n o b r a c ) s h t n o m 6 ( e n i l - n i n o b r a c r e t l i f l...

  • Page 28: Limited Warranty

    Page 28 limited warranty what your warranty covers: if any part of your watts premier reverse osmosis system is defective in workmanship (excluding replaceable filters and membranes), return unit after obtaining a return authorization (see below), less tank, within 3 year of original retail purchase...