1. DL manuals
  2. Wayne-Dalton
  3. Garage Door Opener
  4. 105/110
  5. Installation Instructions And Owner's Manual

Wayne-Dalton 105/110 Installation Instructions And Owner's Manual

Summary of 105/110

  • Page 1

    Garage doors & openers part no. Important notices! Wayne-dalton highly recommends that you read and fully under- stand the installation instructions and owner’s manual before you attempt this installation. To avoid possible injury, read the enclosed instructions carefully before installing and opera...

  • Page 2

    2 please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com a. Track rollers (as required): a1. Short stem track ...

  • Page 3: Warning

    Important safety instructions definition of key words used in this manual: warning warning indicates a potentially hazardous situation which; if not avoided, could result in severe or fatal injury. Caution: property damage or injury can result from failure to follow instructions. Important: required...

  • Page 4

    Cable drums rh/lh torsion springs rh/lh cotter pin (as required) 5/16” x 1-1/4” clevis pin (as required) center bearing bracket assembly (as required) center bearing bracket assembly (as required) (2) cable sheaves key shafts (as required) hinges half center hinges (as required) strut clips (as requ...

  • Page 5: Warning

    Graduated end hinge schedule 6 section high door 2” top n/a intermediate iv 5# intermediate iii 4# intermediate ii 3# intermediate i 2# bottom 1# 3” top n/a intermediate iv 7# intermediate iii 6# intermediate ii 5# intermediate i 4# bottom 3# 7 section high door 2” top n/a intermediate v 6# intermed...

  • Page 6

    Door height track manual lift motor operated 6’0” to 7’0” 15” radius 102” (2591 mm) 125” (3175 mm) 7’1” to 8’0” 114” (2896 mm) 137” (3480 mm) 8’1” to 9’0” 126” (3200 mm) 168” (4267 mm) 9’1” to 10’0” 138” (3505 mm) 168” (4267 mm) 10’1” to 12’0” 162” (4115 mm) * headroom requirements track type space ...

  • Page 7: Warning

    Installation before installing your door, be certain that you have read and followed all of the instruc- tions covered in the pre-installation section of this manual. Failure to do so may result in an improperly installed door. Important: wood doors must be completely finished (3 total coats, includ...

  • Page 8

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com typical left hand bottom corner bracket bottom section ...

  • Page 9

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com the upper leg of strut to the bottom section using (1) ...

  • Page 10

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com weather seal level bottom section wooden shims (if nece...

  • Page 11: Warning

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com side. Important: the dimension between the flag angles ...

  • Page 12: Warning

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com first, then through the rear support bracket and the 5/...

  • Page 13: Warning

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com 1a. Center bearing bracket torsion shaft or torsion key...

  • Page 14

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com torsion keyed shafts horizontal track end bearing brack...

  • Page 15: Warning

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com locking pliers perforated angle rear back hang assembly...

  • Page 16

    Please do not return this product to the store. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a dealer section online at www.Wayne-dalton.Com 6.) clamp locking pliers onto track and rewind springs....

  • Page 17: Warning

    Door arm hookup tools: needle nose pliers at the center of the top section, measure horizontally from the top of center hinge to the bottom of strut. Using that dimension, measure and cut (2) pieces of perforated angles. Assemble the (2) pieces together using (2) 3/8” bolts and nuts (supplied by oth...

  • Page 18: Warning

    Cleaning your garage door important: do not use a pressure washer on your garage door! An annual inspection of all the surfaces of your garage door(s) will reveal the extent of weather- ing and the possible need for refinishing. When the finish becomes eroded or thin, clean and prime any areas showi...

  • Page 19

    3. Lubrication: the door should open and close smoothly. Ensure the door track rollers are rotating freely when opening and closing the door. If track rollers do not rotate freely, clean the door tracks, removing dirt and any foreign substances. Clean and lubricate (use a non-silicon based lubricant...

  • Page 20

    Limited warranty wayne wood, raised panel, 105/110, 310/311 subject to the terms and conditions contained in this limited warranty, wayne-dalton (“manufacturer”) warrants the sections of the door, against defects in material and workmanship, for a period of one (1) year from the time of delivery pro...

  • Page 22

    After installation is complete, fasten this manual near the garage door. Please do not return this product to the store thank you for your purchase. Contact your local wayne-dalton dealer. To find your local wayne-dalton dealer, refer to your local yellow pages business listings or go to the find a ...