- DL manuals
- Webasto
- Heater
- Dual Top Evo 6
- Operating Instructions Manual
Webasto Dual Top Evo 6 Operating Instructions Manual
Summary of Dual Top Evo 6
Page 1
Integrated heater operating instructions dual top evo 6.
Page 2
Content dual top evo 6 content 1 introduction ............................................................................................ 3 2 maintenance and safety information ................................................... 4 3 function description ................................................
Page 3
Dual top evo 6 introduction 3 1 introduction dear customer, thank you for choosing the dual top evo 6 integrated air and water heater system from webasto. We hope that this product brings you years of reliable comfort and enjoyment during your travels. The dual top evo 6 heater has been designed as ...
Page 4
Maintenance and safety information dual top evo 6 4 2 maintenance and safety information 1 the heater has been type-tested and approved in accordance with ece-r 10 (emc) and ece-r122 (heater) with the following ece permit numbers: e1 03 5000 (emc) e1 00 0195 (heating) note the regulations of these g...
Page 5
Dual top evo 6 maintenance and safety information 5 16 the heat exchanger and water boiler on dual top evo 6 heaters are exposed to very high thermal stress and must be replaced by genuine webasto spare parts ten years after these are used for the first time. 17 the diesel fuel specified by the vehi...
Page 6
Function description dual top evo 6 6 3 function description the dual top evo 6 integrated heater from webasto combines the benefits of an interior heater with a water boiler and contributes to a gas-free motor home. Due to its outside installation and it operation with diesel fuel, the dual top evo...
Page 7
Dual top evo 6 function description 7 3.2 winter mode (heating without hot water production) the desired interior temperature can be adjusted with the interior temperature selector (5 to 35 ºc). The device automatically selects the burner setting modulating between 1,500 w and 6,000 w depending on t...
Page 8
Operating instructions dual top evo 6 8 4 operating instructions 4.1 general the operating instructions and the "maintenance and safety information" must always be observed before the start! The vehicle owner is responsible for the correct operation of the appliance. Before using for the first time,...
Page 9
Dual top evo 6 operating instructions 9 4.1.2 interior temperature sensor to measure the room temperature, a remote interior temperature sensor is located in the vehicle. The location of the sensor is determined by the installer, and is depended on the vehicle type and interior layout. Note the remo...
Page 10
Operating instructions dual top evo 6 10 4.2.2 winter mode (heating without hot water production) 1 move interior temperature selector (b) on the control panel to desired thermostat setting for interior temperature. 2 move mode selector knob (a) to winter mode, heating without hot water production (...
Page 11
Dual top evo 6 operating instructions 11 no water control when winter mode (heating with hot water production) is selected, but the boiler is without water, there will be a warning on the control panel. The green led with the winter mode icon, heating without hot water production (3), will flash. In...
Page 12
Operating instructions dual top evo 6 12 4.3 frost there are several features that protect the water supply system against frost. • drain water contents manually when there is risk of frost and when storing the vehicle for a longer period. See paragraph 4.3.1: "draining the boiler manually". • the b...
Page 13
Dual top evo 6 operating instructions 13 the drainage outlet of the electrical safety/drainage valve must always be kept clear (free from dirt, ice, leaves etc.)! To avoid water loss and to protect the heater and boiler against frost, select the frost protection mode (5). Note when the frost protect...
Page 14
Operating instructions dual top evo 6 14 4.4 switching off move mode selector knob (a) to "off" (7) to switch off. The fan can continue to run after switching off in order to cool down the heater. After this, the green indicator (c) goes off. Always drain the boiler if there is a risk of frost!.
Page 15
Dual top evo 6 filling the boiler 15 5 filling the boiler fill the vehicle fresh water tank with your own hose, which is kept and stored clean. Before filling the tank rinse the hose thoroughly (approx. 30 seconds). Warning always fill the tank with drinking water only and prevent dirt from getting ...
Page 16
Fault message output dual top evo 6 16 6 fault message output if a fault occurs, a fault message is output on the control panel/fault message display (c) with flashing pulses. After a series of 5 fast green flashing pulses, the fault message output will be a repeated sequence of long red flashing pu...
Page 17
Dual top evo 6 maintenance 17 7 maintenance correct maintenance of a webasto dual top evo 6 integrated heater is important to ensure years of trouble free safe use and enjoyment. We recommend taking the vehicle to your authorised webasto dealer for periodic service and inspection. It is very importa...
Page 18
Maintenance dual top evo 6 18 for disinfection use a solution of sodium hypochlorite (naocl), dilution 5 %, 30 to 40 ºc (e.G. Certisil ® , puriclean). Other products can harm your health and/or the dual top evo 6. Carefully follow all instructions of the naocl supplier. Carefully follow all instruct...
Page 19
Dual top evo 6 troubleshooting 19 8 troubleshooting if a fault occurs, first check the fuses and plug connections to ensure that they are in perfect condition and connected correctly. If the action described below does not rectify the fault, have the heater checked by webasto-trained personnel. To r...
Page 20
Troubleshooting dual top evo 6 20 fault message output on control panel number of red flashing pulses meaning remedy 00 no communication between control panel and heater, or control panel error first, remove fuses 15 a (red cable) and 5 a. Then put in fuse 15a (red cable), followed by fuse 5 a. Chec...
Page 21
Dual top evo 6 troubleshooting 21 note number of red flashing pulses 0 to 15: heater shuts off automatically. 17 red flashing pulses: no shut-off, but the flashing pulses indicate a failure. 8.1 fuses the dual top evo 6 is equipped with 3 fuses: 5 a, 15 a and 15 a. Each fuse must be connected to the...
Page 22
Worldwide warranty dual top evo 6 22 9 worldwide warranty the following worldwide warranty is extended to cover the integrated dual top evo 6 air and water heater, manufactured or supplied by webasto and is subject to qualifications indicated. Webasto warrants for the period set forth below that pro...
Page 23: Warranty Certificate
Installed in vehicle type max. Permissable weight date of installation date of initial registration of vehicle self-adhesive label stamp of installing workshop validation & commissioning approved report available warranty certificate.
Page 24: Control Card
Installed in vehicle type max. Permissable weight date of installation date of initial registration of vehicle self-adhesive label stamp of installing workshop validation & commissioning approved report available control card.
Page 25
In multilingual versions the german language is binding. The telephone number of each country can be found in the webasto service center leaflet or the website of the respective webasto representative of your country. Iden t-nr . 9 026373b • 12/12 • err o rs and omissions e xcepted • © w e basto the...