1. DL manuals
  2. Webasto
  3. Water Heater
  4. Thermo Top V
  5. Operation And Maintenance Instructions

Webasto Thermo Top V Operation And Maintenance Instructions

Manual is about: Volkswagen Touran Diesel

Summary of Thermo Top V

  • Page 1

    Bedienungs- und wartungsanweisung operation and maintenance instructions thermo top v mercedes benz e-klasse (br 212) / e-class (mr 212).

  • Page 2: Content

    D content general information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 maintenance and safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 heater unit operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Page 3: General Information

    21 d operation and maintenance instructions thermo top v for mercedes benz e-class (mr 212) general information dear webasto customer, we assume that the operation of your new heater unit was explained to your complete satisfaction by the workshop/service station that installed it. In these operatin...

  • Page 4: •

    22 d maintenance and safety instructions within the scope of the european directive 70/156/ewg type approvals have been granted for the thermo top v water heating unit in accordance with directives 2001/56/eg (heating) and 72/245/ewg (emc). The unit must be installed in accordance with the accompany...

  • Page 5: The Heater Unit Must Not:

    23 d the heater unit must not: the heater unit must: • be exposed to temperatures higher than 120°c (storage temperature). Exceeding this can cause permanent damage to the electronics. • be operated without at least 20% share of an anti-freeze approved by the manufacturer in the coolant of the heat ...

  • Page 6: Liability Waiver:

    24 d liability waiver: • not following the installation instructions and the information contained therein release webasto from liability. This also applies for non-specialist repairs or when original spare parts are not used. This will result in voiding the type approval of the heater unit and cons...

  • Page 7: Heater Unit Operation

    25 d heater unit operation the heater unit can be operated by a tip switch or radio control remote telestart t91. The heater unit can also be operated via the telephone with the webasto thermo call option. The function "parked-car ventilation" is not available for the e class (mr 212). Note: we reco...

  • Page 8: Temperature “Hi”

    26 d the following settings must be made before leaving the vehicle: it is not necessary to pre-select the blower speed. Temperature “hi” air outlet “top”.

  • Page 9: Note:

    27 d note: after the settings are made, another approx. 20 sec. Must be waited before the ignition is switched off so that the vehicle saves the settings. On vehicles with a factory-installed alarm system with passenger compartment monitoring, the alarm system must be deactivated before leaving the ...

  • Page 10: Use

    28 d use with the webasto telestart t91, the heater unit can be switched on and off wirelessly at a range of up to 600 m. When switching on and off, the transmitter should be held as high as possible and vertical. When transmitting, do not cover the antenna with your hand. The maximum range is incre...

  • Page 11: Note:

    29 d if you determine from the lack of feedback that the operating signal has not reached the vehicle, then you must change your position by a few metres. A higher altitude can also increase the range. The heater will automatically switch off when the selected operating period has elapsed. Note: whe...

  • Page 12: Note:

    30 d programming telestart transmitter 1. Place batteries into the battery compartment of the transmitter. 2. Remove fuse 1a (black) from the heater's fuse holder (voltage interruption). 3. Wait at least 5 seconds. 4. Replace fuse in heater's fuse holder and within 5 seconds press the off button on ...

  • Page 13: Switching On The Heater

    31 d switching on the heater hold the transmitter with the aerial upright and press the on button until the led lights up (approx. 1 second). Feedback of the telestart receiver to the hand-held transmitter. The led on the hand-held transmitter indicates whether the switch-on signal has been received...

  • Page 14: Switching Off The Heater

    32 d feedback from the transmitter upon turning on/off switching off the heater hold the transmitter with the aerial upright and press the off button until the led lights up (approx. 1 second). The transmitter will send a feedback signal. Switching off using the pushbutton switch if the heater was a...

  • Page 15: Indication

    33 d indication when the auxiliary heating is switched on with the tip switch or the telestart t91, the tip switch lights as an indicator. Note: when switched on with the button, the operating period last used with the telestart t91 is always selected..

  • Page 16: Note:

    34 d checking and setting the operating time the operating time of the heater can be preset on the transmitter in increments of 10 minutes. The operating time is factory-set at 30 minutes. Note: the function "parked-car ventilation" is not available for the e class (mr 212). We recommend setting the...

  • Page 17: Note:

    35 d checking the operating time simultaneously actuate the on and off buttons within one second three times in rapid succession. Note: the first coded flashing signal that is emitted immediately upon the third actuation of both buttons has to be included into the count. The led flashes in accordanc...

  • Page 18: Checking Battery

    36 d returning to the default setting press the on and off buttons simultaneously for approx. 10 seconds until the led extinguishes. Default setting: heating mode, 30 minutes checking battery press the on or off button. Battery led action almost spent flashes orange for 5 seconds replace batteries a...

  • Page 19: Battery Change

    37 d battery change see also page 30: "programming telestart transmitter". Note return batteries of our products after use at the point of purchase or in its immediate vicinity. Returning them is free. As end user you are legally obliged to return used batteries. Caution! Risk of explosion if batter...

  • Page 20: Troubleshooting

    38 d troubleshooting if a fault occurs, check the security and condition of the fuses and the connections. If there is a malfunction, the heater unit switches to defect lock mode. Before you visit a webasto service station, try to clear the defect lock. You can rectify the following faults yourself:...

  • Page 21: Fault Reset

    39 d fault reset the defect lock is incorporated in the auxiliary heater fuse holder in the engine compartment. Note: the heater unit is switched on when the fuse is replaced. If this action does not correct the fault, please contact a webasto service station. Briefly press the on button on the left...

  • Page 22: Webasto Ag

    D bei mehrsprachiger ausführung ist deutsch verbindlich. In multilingual versions the german language is binding. Id en t. -n r. 131 5109 a webasto ag postfach 80 d - 82131 stockdorf germany hotline: +49 (0)1805 - 707 400 (€ 0.14 aus dem deutschen festnetz) e-mail: kundencenter@webasto.De http://www...