1. DL manuals
  2. Woodbridge Fireplace Inc
  3. Outdoor Fireplace
  4. BONFIRE
  5. Owner's Operation And Installation Manual

Woodbridge Fireplace Inc BONFIRE Owner's Operation And Installation Manual

Summary of BONFIRE

  • Page 1

    If you smell gas: 1. Shut off gas to appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. Danger owner’s operation and installation manual we recommend that our products be installed and serviced by pro...

  • Page 2: Warnings

    2 safety information warnings natural gas: natural gas is odor- less. An odor making agent is added to the gas. The odor helps you detect a gas leak. However, the odor added to the gas can fade. Gas may be present even though no odor exists. Make certain you read and under- stand all warnings. Keep ...

  • Page 3

    Specifications 32” 7.75” 12” 22.5” fireplace burner dimensions / __ 13” parameter / model bonfire gas type natural s.I.T. Control valve model 880.001 ignition electronic manifold pressure 3.5" w.C. Inlet gas pressure, max 10.5" w.C. Specifications inlet gas pressure, min 5.0" w.C. Orifice size 19/64...

  • Page 4

    Locating your bonfire 4 clearances to combustible materials: when placed 30% or more in total of the remaining wall area is open and unrestricted. Open side at least 25% of total wall area 3) certain materials or items, when placed under or near the appliance, will be subjected to 4) typically an ou...

  • Page 5: Bonfire

    Bonfire installation (example ) clearance to combustibles must be maintained according to page 4. 5.

  • Page 6: Product Assembly

    Product assembly 1. Remove burner assembly, and burner media from packa- ging (see parts list) 2. Connect the burner assembly to gas supply using supplied flex connector and shutoff valve. 3. Evenly fill the media compartment with burner media (broken tempered glass) fully covering the burner as sho...

  • Page 7

    Fireplace installation check gas type installing gas piping to fireplace / burner system location installation items needed before installing fireplace and burner system, make sure you have the items listed below. • tee joint • pipe wrench • approved flexible gas line with gas connector (if allowed ...

  • Page 8: Connecting To Gas

    A.G.A. Design-certified manual shutoff valve with 1/8” npt tap cap pipe nipple tee joint sediment trap 3” minimum connecting to gas supply installation items needed pliers - sediment trap - tee joints - pipe wrench installation must include a manual shutoff valve, union, and plugged 1/8” npt tap. Lo...

  • Page 9

    Lighting instruction s 9.

  • Page 10

    Access panel close access panel. 3. Open access panel. Turn the manual gas shutoff valve clockwise open access panel. 10. Turn on all electric power to the appliance. Counterclockwise reverse side. Close access panel. 12. Locate on/off switch outside the appliance.Turn it to on. 13. The pilot should...

  • Page 11

    Cleaning and maintenance burner, pilot and control compartment pilot flame the flames from the pilot should be visually checked as soon as the unit is installed and periodically during normal operation. The pilot flame must always be present when the fireplace is in operation or connected to the gas...

  • Page 12

    Troubleshooting warning: turn off the unit and let cool before servicing. Only a qualified service person should service and repair this appliance. Observed problem possible cause remedy age 1. Passage of air/gas across irregular sur- faces 2. Excessive gas pressure on natural gas units 1. Incorrect...

  • Page 13

    Observed problem spark at pilot but no ignition burner does not light after pilot is lit delayed ignition burner unit produces unwanted odors gas odor even when remote control is remedy 1. Turn on gas supply or open manual 2. Purge air from the supply line 1" blue flame 4. Clean pilot (see cleaning ...

  • Page 14

    16 1 8 5 2 3 6 7 9 10 11 12 illustrated parts list 4 11 14 15 16 13 1 7 1 8 14.

  • Page 15

    Illustrated parts list 0.199.039 pilot assembly 9 12 10 8 6 15 15.

  • Page 16

    Illustrated parts list for part description see next page lavarock optional fireplace topping media 19 20 21 22 1 6 1 pc. Ceramic log set black glass small stones.

  • Page 17

    Illustrated parts list warning failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with this appliance may result in property damage or personal injury. All replacement parts should be ordered from your retailer or www.Woodbridgefp.Com i...

  • Page 18

    127(6.

  • Page 19

    127(6.

  • Page 20

    Warranty coverage lifetime warranty basic warranty woodbridge fireplace inc. Warrants the components and materials in your gas appliance to be free from manufacturing and material defects for a period of two years from date of installation. After installation, if any of the components manufactured b...