AC Mobility Traxx 2 User Manual - Fault Finding
AC Mobility
User Manual for the Traxx 2 2 electric wheelchair
September 2009
Page 23
Fault Finding
Problem : The controller lamp flashes
Action to
take :
If lamp flashes immediately when the power is switched on and the
joystick is engaged, switch the power off, wait a few seconds, then
switch on again. Wait for two seconds before re-engaging the
joystick.
Problem :The controller lamp flashes slowly while driving
Action to
take :
The slow flashing means that the battery charge level is low and
should be placed on charge as soon as practicable
Problem : The controller lamp flashes continuously and the chair will not
operate.
Action to
take :
The continuous flashing of the lamp means that there may be a
major problem. Switch the power off, and contact your dealer and
advise of the problem.
Problem : The chair is difficult to steer
Action to
take :
First, check the tyre pressure of all tyres. Second, if your chair is
fitted with a hub release system for freewheeling, check to see that
both clutches are engaged correctly
Please Note
If you detect that there are problems with the motors, the battery charger, the controller or
damage to the wheelchair frame, it is recommended that you contact the nearest
Authorized Service Agent or your distributor.
If you notice any other irregular aspect of your chair or if the chair fails to respond after
making some of the above inspections, phone your nearest Authorized Service Agent or
dealer for assistance. They will advise if the wheelchair should be returned for repairs. If
the chair is to be returned, they will also advise on the availability of replacement units,
and the required method of packing and shipping.
Tools supplied with the wheelchair
The wheelchairs are not supplied with any special tools as these not required for day to day
operation. Should repairs be required, please contact your Authorized Service Agent or
your dealer.
Replacement parts list
The commonly replaced items on your Traxx 2 are:
Tyres
Use
Type
size
Front tyre Pneumatic
220 x 60mm (9” x 2 ½ ” approx)
Microcellular 200 x 45mm (8” x 2” approx)
Rear tyre
Pneumatic
317 x 62mm (12 ½ ” x 2 ¼ ” approx)
300 x 85mm (12” x 3” approx)
Repairs by the user
Note: Battery servicing, changing tyres and inflation of tyres is potentially hazardous. The
user replaces damaged tyres, tubes and batteries at their own risk. If this is done, it is
recommended to take place as outlined above.
It is recommended that all repairs are carried out by your nearest Authorized
Service Agent or distributor.