1. DL manuals
  2. Bakers Pride
  3. Kitchen Appliances
  4. Dante CH-14
  5. Operation Manual

Bakers Pride Dante CH-14 Operation Manual

Manual is about: EQUIPMENT PRICE LIST

Summary of Dante CH-14

  • Page 1

    Built by craftsmen. Tested by time ® . Series: xx & ch operation manual dante series gas charbroilers.

  • Page 2: Charbroiler Operation Manual

    Xx & ch charbroiler operation manual models: dante xx & ch charbroiler operation manual bakers pride oven company, llc is a wholly owned subsidiary of standex international corporation. All gas operated bakers pride ® charbroilers are intended for use with the type of gas specified on the rating pla...

  • Page 3: Table of Contents

    Xx & ch charbroiler operation manual 1 table of contents general description 2 installation 2 clearances 2 gas connection 2 burners 2 radiants 3 top grates 3 lighting 3 griddle plates 3 additional installation requirements 4 installation with casters 4 optional smoker base 4 operating instructions 5...

  • Page 4: Installation Instructions

    Xx & ch charbroiler operation manual 2 installation instructions gas connection: the gas pressure regulator supplied must be installed at the gas inlet of each broiler. Each regulator is adjusted to yield a manifold pressure of 5 in. Water column for natural gas or 10 in. Water column for propane ga...

  • Page 5: Installation Instructions

    Xx & ch charbroiler operation manual 3 installation instructions radiants: mount the “v” shaped radiants over the burners with each end mounted on special supports on the front and rear of the chamber. A radiant should be mounted over each burner assembly. Gs ceramic briquettes option: the radiants ...

  • Page 6: Installation Instructions

    Xx & ch charbroiler operation manual 4 installation instructions additional installation instructions (a) keep the area around the broiler free and clear of combustible materials. (b) the provision of an adequate air supply to your broiler is essential. Provide for sufficient outside air to enter th...

  • Page 7: Operating Instructions

    Xx & ch charbroiler operation manual 5 operating instructions lighting procedure: see installation instructions. Once the pilot burners are lit, the broiler may be turned “on” or “off” by turning the control valves on or off as necessary. Broiling procedure: broiler top grates must be hot enough to ...

  • Page 8: Operating Instructions

    Xx & ch charbroiler operation manual 6 operating instructions 3) as the wood incinerates and begins to turn to ash, it will lose its ability to impart a smoke flavor. Periodically check the condition of the wood and replenish before it is completely burned. This will ensure uninterrupted smoking cap...

  • Page 9: Operating Instructions

    Xx & ch charbroiler operation manual 7 operating instructions average production guide: estimated hourly production model number broiling area 3 oz. Burgers 12 oz. Steaks ch-4 xx-4 21” x 24” 600 120 ch-6 xx-6 31 1/2” x 24” 900 180 ch-8 xx-8 42” x 24” 1200 240 ch-10 xx-10 52 1/2” x 24” 1500 300 ch-12...

  • Page 10: Troubleshooting Guide

    Xx & ch charbroiler operation manual 8 troubleshooting guide the following should be checked: 1. The building’s main pressure regulator. 2. The size of the broiler’s gas supply line (if it is a new installation). 3. The broiler’s pressure regulator. 4. The orifice size of each burner. One burner fai...

  • Page 11: Valve Assembly Views

    Xx & ch charbroiler operation manual 9 valve assembly views valve assembly views: figure 2: air mixer cap and pilot burners figure 3: side view - ch series (a=cap hold-down screw) figure 3: side view - xx series.

  • Page 12

    Xx & ch charbroiler operation manual 10 parts lists and exploded views exploded view – xx-4, 6, 8, 10, 12 burner / accessories item part no. Description 1 r1017x manifold assy (xx-4) 2 r1018x manifold assy (xx-6) 3 r1019x manifold assy (xx-8) 4 r1020x manifold assy (xx-10) 5 r1133x manifold assy (xx...

  • Page 13

    Xx & ch charbroiler operation manual 11 parts lists and exploded views exploded view – xx-4, 6, 8, 10, 12 exterior / grates note: when ordering, always specify part #, model #, serial #, voltage/phase and gas type..

  • Page 14

    Xx & ch charbroiler operation manual 12 item part no. Description 1 g1013x control panel (xx-4) g1014x control panel (xx-6) g1015x control panel (xx-8) g1016x control panel (xx-10) g1249k control panel (xx-12) 2 g1007x top front trim (xx-4) g1008x top front trim (xx-6) g1009x top front trim (xx-8) g...

  • Page 15

    Xx & ch charbroiler operation manual 13 parts lists and exploded views exploded view – ch-6, 8, 10, 12, 14 note: when ordering, always specify part #, model #, serial #, voltage/phase and gas type..

  • Page 16

    Xx & ch charbroiler operation manual 14 parts lists and exploded views item part no. Description 1 t1006a top grate 5 1/4' wide 2 2 t1217u grate, meat (4 1/2") 3 t1210u grate, meat (6") 4 t1216a grate, top, flat cast iron (4 1/2") 5 t1212a grate, top, flat cast iron (6") 6 6 t1199u roll-a-grate (4 1...

  • Page 17: Bakers Pride

    15 heavy duty gas charbroiler operation manual bakers pride limited warranty what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: • the equipment has not been accidentally or intentionally damaged, alter...

  • Page 18

    Be sure to keep up with new product announcements and events on social media! The standex food service equipment group (fseg) is a manufacturer of innovative commercial food service equipment offering a wealth of refrigeration and cooking expertise. Products include walk-in coolers and freezers; hot...