- DL manuals
- EcoSpring
- Water Heater
- ES190
- Installation & Owner's Manual
EcoSpring ES190 Installation & Owner's Manual
Summary of ES190
Page 1
Installation & owner’s manual thank you very much for purchasing an ecospring es190 heat pump water heater. Before using your unit , please read this manual carefully and keep it for future reference. All in one air-source heat pump water heater ecospring es190 verson 1.1 july.2012.
Page 3
Your safety is the most important! Warning this unit requires reliable earthing before usage to prevent potential injury or death please ask a qualified service technician for a reliable earthing connection.
Page 4
P arts names note all pictures in this manual are for explanation purposes only. They may be slightly different from the heat pump water heater you purchased. The actual unit shall prevail. Fan unit tpr valve t op cover evaporator filter magnesium stick rear cover front cover w ater outlet drain por...
Page 5
1 installation & owner‘s manual contents page 1. Precautions to prevent injury to the user, other people and/or property damage, the following instructions must be adhered to. Incorrect operation may cause harm or damage. Warning warning caution failure to observe a caution may result in injury or e...
Page 6
2 installation & owner‘s manual caution the earth pole of terminal must be earthed,and the rated current should be more than 20a. Make sure that power supply terminal and power supply plug are dry and have a good connection. Method: turn on power supply, run the unit for 30 minutes then turn it off ...
Page 7
3 installation & owner‘s manual 1580 fig.3-1 fig.4.1 display fig.3-2 air outlet unit: mm unit: mm barrier ≥ 600 ≥ 300 ≥ 100 ≥ 600 ≥ 500 ≥ 100 kitchen areas where oil permeates. Areas of strong electromagnetic waves exist. Areas where flammable gases or materials exist. Areas where acid or alkali gas...
Page 8
4 installation & owner‘s manual 5. Pipeline connection fig.5.1 pipeline connection schematic water outlet user water inlet barrel-drain drain port tpr valve upper condensate outlet lowerr condensate outlet b fig.4.2 user user dimension h (mm) 1580 ￠a (mm) 568 model rsj-15/190rdn3-c table . 4-1 5.1 p...
Page 9
5 installation & owner‘s manual warning fig.6.1 6. Electric connection 6.1 specifications of power supply 6.2 electric leakage protector . Table.6-1 30/20 30 ma ≤ 0.1sec creepage breaker earth wire(mm2) manual switch(a) capcity/fuse model name power supply min. Diameter of powe supply line(mm2) 220-...
Page 10
6 installation & owner‘s manual fig.6.2 6.3 electric wiring diagram ambient temperature sensor suction temperature sensor cn20 sw3 sw3-2 sw2 sw2-1 without t3: evaporator temp. Sensor t4: ambient temp. Sensor t5l: tank temp. Sensor tp: discharge temp. Sensor earthing th: suction temp. Sensor.
Page 11
7 installation & owner‘s manual caution caution 7.1 operation steps 7. Operating instruction before turning on this unit, please follow the steps below. Filling with water: if the unit is used for the first time or used again after draining the tank, please make sure that the tank is full of water b...
Page 12
8 installation & owner‘s manual 7.2 operation 1. Control panel explanation 2. Display explanation display operation 10 11 12 13 14 16 15 17 18 19 11 10 12 13 water temp will be illuminated all the time. Shows water temperature on normal time; shows setting temperature when setting temperature; shows...
Page 13
9 installation & owner‘s manual 7.2.1 operation interface 20 21 22 23 27 24 25 26 28 21 20 23 22 24 mode selection press button to select operation mode. The unit can operate with three modes: economy mode, hybrid mode and e-heater mode. Economy mode is the normal mode. Economy mode: the unit can he...
Page 14
10 installation & owner‘s manual pipeline connection explanation install the water inlet/outlet pipes and pipe for tpr valve in accordance with the as/nzs standards. 25 26 set timer-time on only time on only: if only set the timer-time on, the unit will automatically operate once between the setting...
Page 15
11 installation & owner‘s manual 7.3. Combination button 7.7. Trouble shooting 7.7.1 non-error tips q: why compressor can't start immediately after setting? A: unit will wait for 3 min to balance the pressure of system before starting compressor again, it's a self protection logic of unit. Q: why so...
Page 16
12 installation & owner‘s manual 7.7.5 error code shooting table malfunction description corrective action error of sensor t5l(lower water temperature sensor) e1 check the connection between sensor and pcb has released or sensor has been broken. Contact a qualified person to service the unit. Tank a...
Page 17
13 installation & owner‘s manual la water-heating operating capability two heating parts are included in the unit, one heat pump and one electric heater, which is installed in the middle. All the heating parts do not work together. This unit has one temperature sensor, which is installed at the uppe...
Page 18
14 installation & owner‘s manual 8.3 recovery time defrosting during water-heating if the evaporator freezes over in economy mode and hybrid mode during cold weather, the system will defrost automatically to keep effective performance(3~10 min). In defrosting mode, the fan motor will run at a high s...
Page 19
15 installation & owner‘s manual 9. Maintenance 9.1 maintenance instruction to take out the air filter get off the top cover,and take out the filter 9.2 non-error malfunction 9.3 malfunctions and resolutions table.9-1 counterclockwise rotate top cover check the connection between power supply plug, ...
Page 20
16 installation & owner‘s manual 10. Specifications the test conditions: ambient temperature 20/15℃(db/wb), water temperature from 15℃ up to 45℃. Model high-pressure protector, over-load protector, temp controller&protector, electric leakage protector, etc r134a(0.8kg) protection compressor power e-...