FHP CA CONSOLE series Installation Instructions Manual - Unit Check-Out
970-293 Revised 05-12
UNIT CHECK-OUT
SHEET
Customer Data
Customer Name ______________________________________________
Date _________________________________
Address _____________________________________________________
_____________________________________________________
Phone_______________________________________________________
Unit Number __________________________
Unit Nameplate Data
Unit Make _________________________________________
Model Number_____________________________________
Serial Number_________________________________
Refrigerant Charge (oz) ________
Compressor: RLA _____________
LRA ______________
Blower Motor: FLA (or NPA) ____________
HP_______________
Maximum Fuse Size (Amps) ___________
Minimum Circuit Ampacity (Amps) ______________
Operating Conditions
Cooling Mode
Heating Mode
Entering / Leaving Air Temp
_______________ /_______________
_______________ /_______________
Entering Air Measured at:
_______________________________
_______________________________
Leaving Air Measured at:
_______________________________
_______________________________
Entering / Leaving Fluid Temp
_______________ /_______________
_______________ /_______________
Compressor Volts / Amps
_______________ /_______________
_______________ /_______________
Blower Motor Volts / Amps
_______________ /_______________
_______________ /_______________
Fluid Flow (gpm)*
_______________________________
_______________________________
Fluid Side Pressure Drop*
_______________________________
_______________________________
Suction / Discharge Pressure (psig)*
_______________ /_______________
_______________ /_______________
Suction / Discharge Temp*
_______________ /_______________
_______________ /_______________
Suction Superheat*
_______________________________
_______________________________
Entering TXV / Cap Tube Temp*
_______________________________
_______________________________
Liquid Subcooling*
_______________________________
_______________________________
* Required for Troubleshooting ONLY
Auxiliary Heat
Unit Make _________________________________________
Model Number _____________________________________
Serial Number ________________________________
Max Fuse Size (Amps) _______________________________
Volts / Amps_____________________ /____________________
Entering Air Temperature ____________________________
Leaving Air Temperature _____________________________
CS-7.2-FO-15.Rev.0
14
CA CONSOLE SERIES