1. DL manuals
  2. Garden Trax
  3. Tiller
  4. Y2007
  5. Instructions Manual

Garden Trax Y2007 Instructions Manual

Manual is about: MINI CULTIVATOR & DETHATCHER

Summary of Y2007

  • Page 1

    Mini cultivator & dethatcher instructions y2007 thank you for purchasing your garden trax garden tool! It is important that you read all assembly, usage and safety instructions! Please take time to read this manual and follow all instructions to enhance your gardening experience! Then please registe...

  • Page 2

    2 model y2007 congratulations... On purchasing your new garden trax mini cultivator & dethatcher and welcome to the world of garden trax gardening. We know that you are anxious to get right to work and start working in your garden, but before you do, it is important that you take a few moments and f...

  • Page 3

    3 model y2007 engine displacement 42.7cc fuel tank capacity 36 oz oil/gas ratio 40:1 - 2.6 oz per gallon oil type 2 cycle engine oil gas type unleaded reg gas spark plug l8rtc spark plug gap 0.028 transmission gear drive gear ratio 32:1 tilling width 6" min to 12" max tilling depth 4" max tine speed...

  • Page 4: Caution!

    4 model y2007 general safety rules special messages this manual contains special messages to highlight and bring a en on to poten al safety concerns, machine damage as well as helpful opera ng and servicing informa on. Please read all the manual to avoid injury and machine damage. *note : during the...

  • Page 5

    5 engine safety precautions carbon monoxide poising warning all engines have carbon monoxide contained in their exhaust fumes. It is a deadly, colorless, odorless, tasteless gas which could be present even though you see or smell no engine exhaust. In an enclosed area with no ven la on, this gas can...

  • Page 6: Caution!

    6 model y2007 burns and fires certain parts of this unit such as the mu ffl er, mu ffl er guard and engine parts become extremely hot during t he opera on of this unit. These parts will remain extremely hot even a er the unit has been turned o ff and stopped running prevention of burns and fires ● never ...

  • Page 7

    7 safety decal garden trax is a leading manufacturer of outdoor power equipment. This unit had been designed and manufactured with your safety in mind. It has been manufactured with all the reliability you expect from an industry leader. Please read this manual in order to gain the necessary knowled...

  • Page 8

    8 unpacking & assembly unpack your unit by carefully li ing it out of its container. Remove any packing material and cut any plas c es holding the handlebar pieces to the rest of the assembly. Assembly 1. Stand the unit upright with the nes and wheels on a level surface. Do not elevate the unit to a...

  • Page 9: Caution!

    9 model y2007 operating your new unit preparing the engine for starting gas and oil we recommend the use of a good quality 2-cycle oil when opera ti ng the engine to that the engine operates smoothly throughout its life. Use only unleaded regular gasoline. Mixture run engine with a 40:1 ra ti o gas ...

  • Page 10: Warning!

    10 normal operation 1. The clutch transfer maximum power to the unit ti nes a ft er approximately 2 hours of normal opera ti on. During this break-in period clutch slippage may occur. The unit's clutch should be kept free of oil and other moisture to ensure efficie nt opera ti on 2. When cul ti va ti ...

  • Page 11

    11 cold engine starting continuied 3. Move choke lever to choke posi ti on note: in the choke position, always move the lever to the farthest choke position possible 4. Push rocker switch to the on po siti on 5. Squeeze the thro tt le control with the right hand. Grasp the starter rope handle and pu...

  • Page 12: Caution!

    12 maintenance steps for working on equipment 1. Make sure engine switch is in the o ff p osi ti on 2. Disconnect the sp ark plug wire from the s p ark plug 3. Secure the s p ark plug wire away from the s p ark plug itself and other metal p arts. Make sure this is done to p revent wire from arcing wi...

  • Page 13

    13 keeping the air filter clean steps for cleaning ring style foam air filter (see parts drawing on page 13) 1. Wash in warm water with liquid detergent un til d irt and debris are removed. Press or squeeze fi lter when cleaning... Do not twist 2. Rinse fi lter un til de tergent and dirt are removed 3...

  • Page 14

    14 spark plug the recommended spark plug for this unit is l8rtc (ngk spark plug type is rcj6y) 1. Always check the spark plug at the beginning of each season 2. Disconnect spark plug cap and clean any debris or dirt from around the spark plug area 3. Examine the spark plug and replace if any of the ...

  • Page 15

    15 adjusting wheels & drag stake the wheels on the mini cul vator can be adjusted into two height po ons (see figure 4) 1. To adjust the wheels, pull the detent pin out of the rear mounted plas parts mount hole 2. Turn the rear mounted p parts 180 degrees and then put the rear mounted p parts into t...

  • Page 16: Caution!

    16 transporting your unit 1. A ft er using your mini cul ti vator, always allow the unit to cool o ff before transpor ti ng. Never transport the unit in an enclosed space within a vehicle as fumes and vapors may build up. They could ignite and cause serious injury or death 2. If fuel is present in fu...

  • Page 17

    17 troubleshooting problem possible cause remedy/action engine will not start 1. Power switch off 1. Flip switch to on position 2. Spark plug wire disconnected 2. Connect spark plug wire to spark plug 3. Out of fuel 3. Refuel 4. Spark plug wet, faulty or improperly gapped 4. Clean, replace or gap sp...

  • Page 18

    18 handle bar parts drawing and list 13 11 5 7 6 6 12 key part # description qty. 1 y4000.02-05 grip,handlebar 2 2 his hand 1 3 bolt,phillips truss hd zn 10-24x1-1/4 1 4 1 5 nut ， t-handle 6 6 washer 8 7 bolt ， handle clamp 6 8 trigger assembly,long throw w/o cable 1 9 throttle cable 1 10 1 11 handl...

  • Page 19

    19 hood and tines parts list and drawing key part # description qty. 1 y2000.01 1 3 y4000.05-04 2 4 y4000.05-05 2 5 y4000.04-01 2 6 y4000.04.04 1 7 y4000.04.03 1 8 y4000.05.02 2 9 gb/t889.1 2 10 y4000.05-07 2 11 y4000.05-02 1 12 y4000.05-03 1 13 y4000.04.02 1 14 1 key part # description qty. 15 y400...

  • Page 20

    20 transmission parts drawing and parts list 1 15 10 2 3 4 14 10 12 13 19 20 21 7 6 8 9 5 11 11 16 24 18 18 22 5 17 17 23 key part # description qty. 1 y4000.03 1 gb/t6174 nut ， jam m8 transmission assembly y4000.03.01 clutch drum 4 ball bearing ， 629 1 5 y4000.03-04 bushin ， gdrive shaft 2 6 washer...

  • Page 21

    21 engine parts drawing model y2007 mini cultivator and dethather.

  • Page 22

    22 engine parts list model y2007 mini cultivator and dethather.

  • Page 23

    23 p lease take the next step to register your purch ase by completing the enclosed warran ty ca rd and mailing the card to the following address: or by going to www.Thunderbay products .Com website and finding the warranty icon. Click on the warranty icon to register your purch ase. Ec declaration ...