Garden Trax Y2007 Instructions Manual - Caution!
12
MAINTENANCE
STEPS FOR WORKING ON EQUIPMENT
1.
Make sure engine switch is in the o
ff p
osi
ti
on
2.
Disconnect
the Sp
ark Plug wire from the S
p
ark Plug
3.
Secure the S
p
ark Plug wire away from the S
p
ark Plug itself and other metal
p
arts. Make sure this is done to
p
revent wire from arcing with Plug
4.
Repl
ace or r
epa
i
r pa
rts on your unit
5.
Once com
p
lete, make sure all
parts ar
e secure and
fi
t correctly
NOTE: All parts must come from the factory or our authorized Service Center. Never use parts that
are not designed specifically for the unit
6.
Once com
p
lete, rea
tt
ach the S
p
ark Plug wire
MINI CULTIVATOR MAINTENANCE
1.
The unit Transmission Case comes with grease that has been
p
acked at the factory. It is recommended by the
factory that the grease level be checked by a quali
fie
d service
p
rofessional to ensure that the grease level is
accurate. If grease is needed, add only molylithium ty
p
e grease only if the level is below the to
p
of the gears. DO
NOT OVERFILL!
2.
Make sure all screws, nuts and bolts are secure and
ti
ght
3.
Store the unit in a safe cool environment for cold weather o
perati
on. Transferring the unit from cold to warm
environments can cause cond
ensati
on build
up
ENGINE MAINTENANCE
Cooling Fins, Air Vents and linkages must always be k
ept
free of dirt and debris. Always make sure they are clean
before each
ti
me you use the unit
Never Run this unit without the engine Air Filter
p
ro
p
erly installed. Engine failure and add
iti
onal wear may occur
if air cleaner is not installed
pr
o
p
erly
Service the Air Filter every 90 days or a
ft
er 20 or more hours of o
p
er
ati
on.
Clean Air filter on a daily basis in
dry, dusty, or other extreme conditions. If dust is visible in the air while the machine is in operation, the air filter
should be cleaned.
PRACTICE SAFETY AT ALL TIMES!!!! ENGINE MUST BE TURNED OFF AND ALLOWED TO COOL AND SPARK
PLUG WIRE MUST BE DISCONNECTED WHENEVER WORKING ON UNIT FOR MAINTENANCE OR REPAIR
TO PREVENT ACCIDENTAL STARTING:
ENGINE MUST BE TURNED OFF AND ALLOWED TO COOL AND SPARK PLUG WIRE MUST BE DISCONNECTED
BEFORE CHECKING OR ADJUSTING ENGINE
MUFFLER AND NEARBY AREA TEMPERATURES MAY EXCEED 150° F (65° C). AVOID THESE AREAS
ALWAYS CHECK UNIT FOR LOOSE SCREWS AND BOLTS. KEEP CONNECTIONS SECURE
NEVER STORE UNIT INDOORS WITH FUEL IN THE TANK. FUEL VAPORS MAY BE PRESENT
ONLY ADULTS SHOULD BE ALLOWED TO USE UNIT OR PREFORM MAINTENANCE ON IT
ENGINE MUST BE TURNED OFF AND SPARK PLUG WIRE DISCONNECTED BEFORE ANY REPAIRS OR
MAINTENANCE IS PREFORMED ON UNIT
CAUTION!
MODEL Y2007
MINI CULTIVATOR AND DETHATHER
●
●
●