1. DL manuals
  2. IBM
  3. Processor
  4. ThinkPad R30
  5. Hardware Maintenance Manual

IBM ThinkPad R30 Hardware Maintenance Manual - Preface

Summary of ThinkPad R30

  • Page 1

    Thinkpad r30/r31 hardware maintenance manual.

  • Page 2

    Before using this information and the product it supports, be sure to read the general information under “introduction” on page 1, and “notices” on page 211. First edition (april 2002) the following paragraph does not apply to the united kingdom or any country where such provisions are inconsistent ...

  • Page 3: Preface

    Preface about this manual this manual contains service and reference information for ibm thinkpad r30/r31 products. Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. The manual is divided into sections as follows: v the introduction section provides gener...

  • Page 4

    Iv thinkpad r30/r31 hmm.

  • Page 5: Contents

    Contents preface . . . . . . . . . . . . . . . Iii thinkpad r30/r31 hardware maintenance manual 1 introduction . . . . . . . . . . . . . . 1 important service information. . . . . . . . 1 drive and diskette compatibility matrix . . . . . 2 safety notices (multi-lingual translations) . . . . 3 safety...

  • Page 6

    Product overview . . . . . . . . . . 105 fru removals and replacements . . . . . . 110 locations . . . . . . . . . . . . . 139 parts list . . . . . . . . . . . . . 142 thinkpad r31 part ii . . . . . . . . . . 159 product overview . . . . . . . . . . 160 fru removals and replacements . . . . . . 165 ...

  • Page 7: Thinkpad R30/r31 Hardware

    Thinkpad r30/r31 hardware maintenance manual introduction important service information important diskette fixes are customer-installable. The diskette fixes are posted on the ibm support site http://www.Pc.Ibm.Com/support/ . Advise customers to contact the ibm ® helpcenter ® at 800-772-2227 if they...

  • Page 8

    Hard disk drive replacement strategy always try to run a low-level format before replacing a hard disk drive. Attention: the drive startup sequence in the computer you are servicing might have been changed. Be extremely careful during write operations such as copying, saving, or formatting. Data or ...

  • Page 9

    Safety notices (multi-lingual translations) in this manual, safety notices appear in english with a page number reference to the appropriate multi-lingual, translated safety notice found in this section. The following safety notices are provided in english, french, german, italian, and spanish. Safe...

  • Page 10

    Safety notice 2 some standby batteries contain a small amount of nickel and cadmium. Do not disassemble it, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use...

  • Page 11

    (continued) alcune batterie di riserva contengono una piccola quantità di nichel e cadmio. Non smontarle, ricaricarle, gettarle nel fuoco o nell’acqua né cortocircuitarle. Smaltirle secondo la normativa in vigore (dpr 915/82, successive disposizioni e disposizioni locali). Quando si sostituisce la b...

  • Page 12

    Safety notice 3 the battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pac...

  • Page 13

    Safety notice 4 the lithium battery can cause a fire, explosion, or severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°c (212°f), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations...

  • Page 14

    (continued) la bateria de repuesto es una bateria de litio y puede provocar incendios, explosiones o quemaduras graves. No la recargue, ni quite el conector polarizado, ni la desmonte, ni caliente por encima de los 100°c (212°f), ni la incinere ni exponga el contenido de sus celdas al agua. Deséchel...

  • Page 15

    Safety notice 5 if the lcd breaks and the fluid from inside the lcd gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d’affichage à cristaux liquides ...

  • Page 16

    Safety notice 6 to avoid shock, do not remove the plastic cover that surrounds the lower portion of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. Aus sicherheitsgründen die kunststoffa...

  • Page 17

    Safety notice 8 before removing any fru, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’ali...

  • Page 18

    Safety information the following section contains the safety information that you need to be familiar with before servicing an ibm mobile computer. General safety follow these rules to ensure general safety: v observe good housekeeping in the area of the machines during and after maintenance. V when...

  • Page 19

    V reinstall all covers correctly before returning the machine to the customer. Electrical safety observe the following rules when working on electrical equipment. Important use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate yo...

  • Page 20

    – stand on suitable rubber mats (obtained locally, if necessary) to insulate you from grounds such as metal floor strips and machine frames. Observe the special safety precautions when you work with very high voltages; these instructions are in the safety sections of maintenance information. Use ext...

  • Page 21

    You can continue without first correcting the problem. Consider these conditions and the safety hazards they present: v electrical hazards, especially primary power (primary voltage on the frame can cause serious or fatal electrical shock). V explosive hazards, such as a damaged crt face or bulging ...

  • Page 22

    Notes: 1. Use product-specific esd procedures when they exceed the requirements noted here. 2. Make sure that the esd protective devices you use have been certified (iso 9000) as fully effective. When handling esd-sensitive parts: v keep the parts in protective packages until they are inserted into ...

  • Page 23

    Class 1 laser products. Elsewhere, the drive is certified to conform to the requirements of the international electrotechnical commission (iec) 825 and cenelec en 60 825 for class 1 laser products. When an optical drive is installed, note the following. Caution: use of controls or adjustments or per...

  • Page 24

    Opening the cd-rom drive could result in exposure to hazardous laser radiation. There are no serviceable parts inside the cd-rom drive. Do not open. Some cd-rom drives contain an embedded class 3a or class 3b laser diode. Note the following. Danger laser radiation when open. Do not stare into the be...

  • Page 25

    General descriptions this chapter includes descriptions for any thinkpad model that has the pc-doctor dos diagnostics program. Some descriptions might not apply to your particular computer. Mt 2656, 2657, 2676 19.

  • Page 26

    Read this first before you go to the checkout guide, be sure to read this section. Important notes: v only certified trained personnel should service the computer. V read the entire fru service procedures before replacing any frus. V use new nylon-coated screws when you replace frus. V be extremely ...

  • Page 27

    Before checking problems with the computer, determine whether the damage is covered under the warranty by referring to the following: note for warranty: for warranty: during the warranty period, the customer may be responsible for repair costs if the computer damage was caused by misuse, accident, m...

  • Page 28

    Fru replacement notices this section contains notices for removal and replacement. Read this section carefully before replacing any fru. Lcd replacement notice the tft lcd for the computer contains many thin-film transistors (tfts). A small number of missing, discolored, or lighted dots (on all the ...

  • Page 29

    Turn an additional 180 degrees after the screw head touches the surface of the plastic part: v torque driver if you have a torque driver, refer to the ″torque″ column with each step. V make sure you use the correct screw, and tighten all screws firmly to the torque shown in the table if you have a t...

  • Page 30

    Note: if lcd cannot display after change id code, make sure you write the correct id code, or try reseating the lcd coaxtial cable connectors. Thermal sensor the system is equipped with sensors to protect against system overheating. By setting system and processor thermal thresholds, the system can ...

  • Page 31

    Related service information this section provides information about the following: v “power button as reset switch” v “running a low-level format” v “service web site” v “passwords” v “power management features” on page 27 v “fn key combinations” on page 29 v “product recovery program” on page 29 po...

  • Page 32

    Will be prompted. If correct svp is entered, post enters bios setup without erasing pop. To boot up the system user should override pop by svp at the password sub-menu. V when svp is not set, post erase the pop and then boots up the system. Power-on passwords power-on password is a security feature ...

  • Page 33

    3. The main screen displays as below: 4. Using the up or down arrow key, select password. 5. Press the enter key. The following submenu is displayed: * power-on password * supervisor password * lock bios setting * hard disk x password 6. Select power-on password and press enter . 7. Type in correct ...

  • Page 34

    Standby mode when in standby mode, the following occurs: v the lcd backlight turns off. V the hard disk motor either spins down or stops (controlled by os). V suspend led turns on. Events that cause the computer to enter standby mode: note: these events depend on the power button, sleep button and l...

  • Page 35

    Note: these events depend on the power button, sleep button and lid settings (options set to hibernate mode) in the ″advanced″ page of the ″power management properties ″ screen. V hibernation requested by the sleep button (fn+f4) or (fn+f12) v hibernation requested by the power button v hibernation ...

  • Page 36

    1. Save all files and shut down the desktop. 2. Turn off the computer. 3. Turn on the computer. Quickly press f11 when this message is displayed on the screen: ... ″to start the product recovery program, press f11 ″ .....This message is displayed for only a few seconds. Note: if this message does no...

  • Page 37

    7. If the hard-disk drive is blank, a menu will appear stating ″your computer originally included a product recovery program ... Reinstall the product recovery program? (y/n) [ ] ″.}. * to install service partition, go to step 4. * to preload hard-disk drive without installing service partition, pre...

  • Page 38

    Checkout guide use the following procedure as a guide for computer problems. Note: the diagnostic tests are intended to test only ibm products. Non-ibm products, prototype cards, or modified options can give false errors and invalid system responses. 1. Obtain the failing symptoms in as much detail ...

  • Page 39

    If the error recurs, replace the fru that caused the error. Note: with some frus, especially the system board, the problem may be caused by peripheral frus. Verify that each peripheral fru, such as the flexible cable, has no problem by doing the following: a. Replace each peripheral fru one at a tim...

  • Page 40

    V vga information v ide drive information v pci information v pnpisa information v smbios information v fru information v vesa lcd information utility: v run external tests v surface scan hard disk v benchmark system v dos shell v tech support form v battery rundown v view test log v print log v sav...

  • Page 41

    V if the power-on indicator does not turn on, check the power cord of the ac adapter for correct continuity and installation. V if the operational charge does not work, go to “checking operational charging”. Unplug the ac adapter cable from the computer and measure the output voltage at the plug of ...

  • Page 42

    Checking the battery asm note: the battery asm may not be able to charged when it is hot. In that case, remove it from the computer and leave it at room temperature for a while. After it cools down, reinstall it and recharge it. Do the following: 1. Power off the computer. 2. Remove the battery pack...

  • Page 43

    Resistance is not correct, replace the battery asm. If the resistance is correct, replace the system board. Mt 2656, 2657, 2676 37.

  • Page 44

    Symptom-to-fru index the symptom-to-fru index lists the symptoms and errors and the possible causes. The most likely cause is listed first. Note: perform the fru replacement or actions in the sequence shown in the fru/action columns. If a fru does not solve the problem, put the original part back in...

  • Page 45

    Error code message meanings comment 0220 monitor type does not match cmos run setup monitor type not correctly identified is setup. 0230 shadow ram failed at offset : nnnn shadow ram failed at offset nnnn of the 64k block at which the error was detected. 0231 system ram failed at offset : nnnn syste...

  • Page 46

    Error code message meanings comment 0270 real time clock error real-time clock fails bios hardware test. May require board repair. 0271 check date and time settings bios found date or time out of range and reset the real-time clock. May require setting legal date (1991–2099). 0280 previous boot inco...

  • Page 47

    Error code message meanings comment 02b3 incorrect drive b type — run setup type of floppy drive b: not correctly identified in setup 02d0 system cache error- cache disabled ram cache failed and bios disabled the cache. On older boards, check the cache jumpers. You may have to replace that cache. Se...

  • Page 48

    Error code message meanings comment failing bits: nnnn the hex number nnnn is a map of the bits at the ram address which failed the memory test. Each 1 (one) in the map indicates a failed bit. See errors 230, 231, or 232 above for offset address of the failure in system,extended, or shadow memory. F...

  • Page 49

    Error code message meanings comment operating system not found operating system cannot be located on either drive a: or drive c:. Enter setup and see if fixed disk and drive a: are properly identified. Parity check 1 nnnn parity error found in the system bus. Bios attempts to locate the address and ...

  • Page 50

    Error code message meanings comment run the i2o configuration utility one or more unclaimed block storage devices have the configuration request bit set in the lct. Run an i2o configuration utility (e.G. The sac utility). System bios shadowed system bios copied to shadow ram. Umb upper limit segment...

  • Page 51

    Error code message meanings comment 0197 invalid remote change requested the remote chnfiguration for the security chip has failed. Confirm the operation and try again. System go into bios setup automatically. 1801 unsupported docking station is attached - power off and remove the docking station at...

  • Page 52

    Event description s1/s3 beep low battery warning beep n/a 4 short beeps critical thermal system post n/a 3 long beeps dram type error pc133 sdram only n/a 2 long beeps responses of boot block bios flash success n/a 2 long, 1 short, and then 1 long beep bios file size mismatch n/a 1 long, 1 short bee...

  • Page 53

    Symptom/error fru/action in sequence lcd backlight does not work. Lcd is too dark. Lcd brightness cannot be adjusted. V keyboard (if contrast and brightness function keys do not work) v reseat lcd connector v check lcd inverter id v lcd cable asm v lcd inverter/led board (13.3 ″/14.1″) v lcd v syste...

  • Page 54

    Indicator-related symptoms symptom/error fru/action in sequence indicator incorrectly remains off or on, but system runs correctly. V reseat inveter/led board (13.3 ″/14.1″) v inveter/led board (13.3″/14.1″) v system board v coaxial cable power-related symptoms symptom/error fru/action in sequence p...

  • Page 55

    Memory-related symptom symptom/error fru/action in sequence memory count (size) appears different from the actual size. (the main memory with 8mb of vga.) v go to “fru tests” on page 57. V enter bios utility and execute ″load setup default settings″; then reboot the system. V dimm v system board aud...

  • Page 56

    Power management-related symptoms symptom/error fru/action in sequence the system doesn’t enter hibernation mode. V go to “hibernation mode” on page 28. V boot an operating system and press fn+f12 and see if the computer enters hibernation mode. V keyboard v hard disk drive connector v hard disk dri...

  • Page 57

    Symptom/error fru/action in sequence parallel port device problems. V device driver v device cable v device v ensure that ″parallel port″ in the ″config sub-menu″ menu of the bios utility is correctly set. V system board modem-related symptom symptom/error fru/action in sequence internal modem does ...

  • Page 58

    1. Run the diagnostic test for the system board at least 10 times. 2. If no error is detected, do not replace any frus. 3. If any error is detected, replace the fru. Rerun the test to verify that there are no more errors. Undetermined problems the diagnostic tests did not identify which adapter or d...

  • Page 59

    Thinkpad r30 this section applies to the following models: 2656, 2657, 2676. Mt 2656, 2657, 2676 53.

  • Page 60

    Product overview the following shows an overview of the system features. Feature description processor intel pentium iii celeron processor 800/100, 900/100 mhz, 1 ghz, l2 cache bus architecture host bus 64bits/100 mhz, pci 32 bits/33 mhz, isa 16 bits/8.33 mhz, pcmcia 16 bits/33mhz, cardbus 32 bits/3...

  • Page 61

    Feature description ethernet (optional) intel 82550gy on board . It supports 10/100mbps ieee 1394 (optional) ti tsb43ab22 1394 controller on board ieee 1394.A 4–pin connector — no cable power 100mbps, 200mbps and 400mbps pc card (pcmcia) one type i/ii or type iii i/o ports external monitor speaker-o...

  • Page 62

    Meaning of each icon: 7 6 symbol color meaning (1) drive in use green data is being read from or written to the hard disk. Do not enter standby mode or power off the computer when this indicator is on. (2) numeric lock green the numeric keypad on the keyboard is enabled. You enable or disable the ke...

  • Page 63

    Symbol color meaning (3) caps lock green caps lock mode is enabled. All alphabetic characters (a-z) are entered in capital letters without the shift key being pressed. You enable or disable the caps lock mode by pressing the caps lock key. (4) scroll lock green scroll lock mode is enabled. The arrow...

  • Page 64

    Fru applicable test modem 1. Make sure the modem set up correctly. 2. Replacing the modem jack and modem card one at a time, run the modem tests in other devices (diagnostics) audio internal speaker (interactive tests) stereo speaker (interactive tests) speaker system beeper: internal speaker (inter...

  • Page 65

    Fru removals and replacements this section contains information about removals and replacements. V do not damage any parts. Only certified and trained personnel should service the computer. V the arrows in this section show the direction of movement to remove a fru, or to turn a screw to release the...

  • Page 66

    Safety notice 8 translations in ″safety notices (multi-lingual translations) ″ section: before removing any fru, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Attention: the system board is sensitive and c...

  • Page 67

    1 2 note: the screw does not separate from the pci cover. 3 4 note: there are 2 cables on step 4 : the gray cable is the main antenna and the black cable is the auxiliarey antenna. Note: when you install the pci card, remember to press it down and ensure the connection is well. Mt 2656, 2657, 2676 6...

  • Page 68

    1030 memory cover and memory card v “1010 battery assembly” on page 60 1 2 note: the screw does not separate from the memory cover. 3 to install the memory card: with the notched end of the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, int...

  • Page 69

    Pivot the memory card until it snaps into place. Side view 1040 hard disk drive assembly v “1010 battery assembly” on page 60 1 2 step size (quantity) color torque 1 m3 x l4 (1) black 3.2 kgf-cm mt 2656, 2657, 2676 63.

  • Page 70

    Warning do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data on the drive. Before removing the drive, have the user make a backup copy of all the information on the drive if possible....

  • Page 71

    1 step size (quantity) color torque 1 m2.5 x l10 (2) black 3.2 kgf-cm 2 3 3 3 4 mt 2656, 2657, 2676 65.

  • Page 72

    Notes: 1. When replacing the keyboard, make sure that the cable is clean and insert it directly into the connector, making sure it makes contact with the bottom of the connector. 2. If the cable do not touch the bottom of the connector, the keyboard function will be rendered useless. 3. The cable of...

  • Page 73

    1 2 3 step size (quantity) color torque 2 m2.5 x l10 (1) black 3.2 kgf-cm 3 m2.5 x l10 (1) black 3.2 kgf-cm mt 2656, 2657, 2676 67.

  • Page 74

    1090 lcd assembly v “1010 battery assembly” on page 60 v “1060 keyboard” on page 64 v “1080 middle cover” on page 66 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 1 2 3 68 thinkpad r30/r31 hmm.

  • Page 75

    Note: release the gray cable, which is the main antenna from the system. 4 4 5 step size (quantity) color torque 4 m2.5 x l10 (4) black 3.2 kgf-cm 5 m2.5 x l5 (1) silver 3.2 kgf-cm 6 1100 keyboard bezel v “1010 battery assembly” on page 60 v “1060 keyboard” on page 64 v “1080 middle cover” on page 6...

  • Page 76

    1 step size (quantity) color torque 1 m2.5 x l10 (7) black 3.2 kgf-cm 2 70 thinkpad r30/r31 hmm.

  • Page 77

    Caution: the keyboard bezel has several latches. When removing the keyboard bezel from the bottom cover, gently release these latches, then raise the side of the keyboard bezel facing the palm rest to remove it. Be careful not to break the latches. 1110 pcmcia holder v “1010 battery assembly” on pag...

  • Page 78

    3 note: before removing and replacing the pcmcia holder, make sure that the pcmcia cards are removed and the eject levers are sticking out. 1120 auxiliary antenna v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 6...

  • Page 79

    1120 speaker v “1010 battery assembly” on page 60 v “1060 keyboard” on page 64 v “1080 middle cover” on page 66 v “1090 lcd assembly” on page 68 v “1100 keyboard bezel” on page 69 1 2 step size (quantity) color torque 2 m2.5 x l4(1) black 2.5 kgf-cm 1140 cpu spring v “1010 battery assembly” on page ...

  • Page 80

    1 step size (quantity) color torque 1 m2.5 x l5 (2) silver 3.2 kgf-cm 1150 fan assembly v “1010 battery assembly” on page 60 v “1060 keyboard” on page 64 v “1080 middle cover” on page 66 v “1090 lcd assembly” on page 68 v “1100 keyboard bezel” on page 69 v “1140 cpu spring” on page 73 1 2 74 thinkpa...

  • Page 81

    3 4 step size (quantity) color torque 3 m2.5 x l5 (2) silver 3.2 kgf-cm 1160 system board v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 v “1040 hard disk drive assembly” on page 63 v “1050 cd-rom assembly” o...

  • Page 82

    1 step size (quantity) color torque 1 m2.5 x l10(3) silver 3.2 kgf-cm notes: 1. When removing the system board from the bottom cover, gently raise the side of the system board facing the rear i/o ports; then pull out the system board. 1170 modem cable (with combo card) v “1010 battery assembly” on p...

  • Page 83

    V “1090 lcd assembly” on page 68 v “1100 keyboard bezel” on page 69 v “1120 speaker” on page 73 v “1160 system board” on page 75 1180 modem card (without combo card) v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on pag...

  • Page 84

    1 step size (quantity) color torque 1 m2.5 x l5 (2) silver 3.2 kgf-cm 1190 hard disk drive bezel v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 v “1040 hard disk drive assembly” on page 63 v “1050 cd-rom asse...

  • Page 85

    1 step size (quantity) color torque 1 m2 x l6 (2) silver 1.6 kgf-cm 1200 cd-rom chassis v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 v “1040 hard disk drive assembly” on page 63 v “1050 cd-rom assembly” on ...

  • Page 86

    1 2 step size (quantity) color torque 2 m2.5 x l5 (3) silver 3.2 kgf-cm 1210 lcd bezel assembly (13.3 ″) v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 v “1060 keyboard” on page 64 80 thinkpad r30/r31 hmm.

  • Page 87

    V “1080 middle cover” on page 66 v “1090 lcd assembly” on page 68 1 2 3 step size (quantity) color torque 2 m2 x l4(2) silver 2.5 kgf-cm 3 m2.5 x l6(2) black 2.5 kgf-cm 3 4 5 6 7 3 note: when removing the lcd, take note of the following: mt 2656, 2657, 2676 81.

  • Page 88

    V be careful not to scratch the lcd bezel when removing the screw mylars. V the lcd bezel has several latches. Release these latches; then remove the lcd bezel. Be careful not to break these latches. V gently push the two lcd latches outward to remove the lcd bezel. 1220 lcd inveter (13.3 ″) v “1010...

  • Page 89

    1 2 3 4 1240 lcd bracket hinge assembly (13.3 ″) v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 v “1060 keyboard” on page 64 v “1080 middle cover” on page 66 v “1090 lcd assembly” on page 68 v “1210 lcd bezel...

  • Page 90

    1 step size (quantity) color torque 1 m2 x l4 (4) silver 2.5 kgf-cm 1250 lcd fpc assembly (13.3 ″) v “1010 battery assembly” on page 60 v “1020 mini-pci cover and mini-pci card” on page 60 v “1030 memory cover and memory card” on page 62 v “1060 keyboard” on page 64 v “1080 middle cover” on page 66 ...

  • Page 91

    1 step size (quantity) color torque 1 m2 x l4(1) silver 2.5 kgf-cm 2 1260 wireless reassembly v “1240 lcd bracket hinge assembly (13.3″)” on page 83 v “1230 led board (13.3″)” on page 82 mt 2656, 2657, 2676 85.

  • Page 92

    86 thinkpad r30/r31 hmm.

  • Page 93

    Locations front view computer display ultrabay plus trackpoint system-status indicators power button volume & mute buttons rear view monitor connector modem connector power jack ethernet connector usb connector parallel port s-video out connector security keyhole bottom view 10 1 2 3 4 5 6 7 8 9 10 ...

  • Page 94

    3. Pc card slot 4. Stereo headphone jack 5. Microphone jack 6. Hard disk drive 7. Mini-pci card slot door 8. Infrared port 9. Lcd latches 10. Built-in speakers 11. Battery pack 12. Battery pack latch 88 thinkpad r30/r31 hmm.

  • Page 95

    Switch locations sw3 check password disabled pin3 1 1 0 0 pin4 1 1 0 check password enabled 1 0 boot block enabled boot block disabled mt 2656, 2657, 2676 89.

  • Page 96

    Parts list 1 2 3 4 6 7 8 9 10 11 12 13 14 15 16 17 18 19 5 20 note: the parts marked with asterisk are crus (customer replaceable units.) no. Description fru no. 1 hinge cap 26p9722 2 keyboard unit (“keyboard” on page 96) 3 middle cover asm ww 26p9727 4 kbd bezel asm. Ww 46l5052 90 thinkpad r30/r31 ...

  • Page 97

    No. Description fru no. 5 antenna kit 13.3 ″ antenna kit 14.1 ″ antenna aux antenna lcd 26p9712 26p9711 6 cable asm. Kit , rj11 and lid switch rj-11 cable for cdc board model rj-11 cable mini pci combo board model lid switch cable 27l0689 7 planar p-iii 1 ghz 12p3648 planar p-iii 1 ghz w/1394 12p365...

  • Page 98

    No. Description fru no. 15 mini-pci / dimm door kit 26p9739* 16 battery assy. (ni-mh) sanyo-w/w sanyo-japan 02k6827* 02k6835* battery assy. (li-ion) sanyo-w/w sanyo-japan panasonic-w/w panasonic-japan 02k6822* 02k6830* 02k6824* 02k6832* 17 speaker kit 02k5989 18 rtc battery 11j8591 19 cd-rom module ...

  • Page 99

    No. Description fru no. Screw kit hdd coin screw m/b hex screw screw dimm cover steel screw mach pan nylok m2.0*13 ni bh msn+n screw m2.0*6 screw mach flat m3*2.8 screw hdd m3*l4 wch msn+cz screw m2.5*5 screw m2.5l10b 86.9a353100 screw m2.5*6 screw m2.4 wafer ni 26p9741 lcd fru 13.3-inch tft: 1 2 3 ...

  • Page 100

    No. Description fru no. 1 13.3 ″ lcd bezel 26p9715 2 lcd panel asm (13.3 ″ tft) sanyo lg 11p8212 11p8220 3 13.3 ″ hinge-bracket asm (r,l) 26p9720 4 lcd-invertor / led card (for 13.3 ″ & 14.1 ″ tft) 26p8139 5 lcd cable asm. 27l0687 6 antenna kit 13.3 ″ lcd antenna w/ 13.3 ″ lcd antenna aux 26p9712 7 ...

  • Page 101

    14.1-inch tft: 1 2 3 3 4 5 6 7 8 no. Description fru no. 1 14.1 ″ lcd bezel (for w/w) 26p9713 2 lcdpanel asm. (14.1 ″ tft) hyundai samsung 11p8214 11p8215 3 14.1 ″ hinge-bracket asm (r,l) 26p9719 4 lcd-invertor / led card (for 13.3 ″ & 14.1 ″ tft) 26p8139 5 lcd cable asm. 27l0686 6 antenna kit 14.1 ...

  • Page 102

    No. Description fru no. Lcd rear cover asm for 13.3 ″/14.1″ (for w/o w) 13.3 ″/14.1″ lcd rear cover 13.3 ″/14.1″ lcdpanel w/o wireless ibm logo 26p9707 8 lcd hinge cap asm. 26p9722 lg/ibm logo kit for lcd rear cover for kbd bezel 08k5860 keyboard description vendor fru no. Kbd asm us english nmb 02k...

  • Page 103

    Common parts list tools: description fru no. Tri-connector wrap plug 72x8546 pc test card 35g4703 audio wrap cable 66g5180 usb parallel test cable 05k2580 screwdriver kit 95f3598 5mm socket wrench 05k4694 screwdriver 27l8126 wireless antenna connector removal tool 08k7159 thinkpad hardware maintenan...

  • Page 104

    Power cords: ibm power cords for a specific country are usually available only in that country. For 2–pin power cords: ibm power cord part number used in these countries or regions 13h5264* canada, u.S.A. 13h5273* japan 36l8870* argentina for 3–pin power cords: note: the grounded adapter is required...

  • Page 105

    Recovery cd eng-xp home (cf) 32p5396 2656–6af, 20f, 19f recovery cd la-sp-w98-xp home(la) 32p5397 2656–60s, 20s, 30s recovery cd la-sp-w98-xp home(la) 32p5397 2656–60x, 20x, 30x recovery cd la-br-w98-xp home(br) 32p5398 2656–60p, 20p, 30p recovery cd japan-xp home 46p4469 2656–6aj, 60j, 42j, 80j rec...

  • Page 106

    Recovery cd netherland- win2000 (nl) 32p5343 2656–f0g, eag, e0g, d0g, bag, bog, d3g, e2g recovery cd finland-w98 (fi) 14p9994 2656–72g, 7bg, 62g, 52g, 3bg, 32g, 22g, 51g, 64g recovery cd finland-win2000 (fi) 23p5342 2656–f0g, eag, e0g, d0g, bag, bog, d3g, e2g recovery cd italy-w98 (it) 14p9993 2656–...

  • Page 107

    Recovery cd german-w98 (gr) 14p9990 2656–72g, 7bg, 62g, 52g, 3bg, 32g, 22g, 51g, 64g recovery cd german-win2000 (gr) 32p5338 2656–f0g, eag, e0g, d0g, bag, bog, d3g, e2g recovery cd thailand-w98 (th) 32p5307 2656–72y, 7by, 62y, 55y, 3by, 32y recovery cd portuguese-w98 14p9987 2656–62p, 22p recovery c...

  • Page 108

    Recovery cd polish-w98 (po) 32p5300 2656–72g, 7bg, 62g, 52g, 3bg, 32g, 22g, 51g, 64g recovery cd polish-win2000 (po) 32p5348 2656–f0g, eag, e0g, d0g, bag, bog, d3g, e2g recovery cd hebrew-w98 (hb) 14p9999 2656–72g, 7bg, 62g, 52g, 3bg, 32g, 22g, 51g, 64g recovery cd hebrew-win2000 (hb) 32p5347 2656–f...

  • Page 109

    Thinkpad r31 part i this section applies to the following models: 2656-9fu, 2656-9ff, 2656-ifu, 2656-iff, 2656-7gu, 2656-7gf, 2656-ggu, 2656-ggf, 2656-hfu, 2656-hgu-ofxp, 2656-heu, 26560-8ft-fdd, 2656-7fs/p/x, 2656-gfm, 2656-gfs/p/x, 2656-7lc-fdd, 2656-7lh-fdd, 2656-7lk-fdd, 2656-7ls/p/x, 2656-e6u, ...

  • Page 110

    2656-k9j, 2656-k8j, 2656-h8u, 2656-h9u-ofxp, 2656-h7u, 2656-h4u, 2656-h5u, 2656-h6u-ofxp, 2656-fgu, 2656-feu, 2656-f5u, 2656-f4u, 2656-m4u, 2656-l4u, 2656-99u, 2656-88u, 2656-c2g, 2656-c3g, 2657-fgu, 2657-feu, 2657-f5u, 2657-f4u, 2657-j2u, 2657-j2j-fdd, 2657-j2g/m, 2657-j2a/t/c/h/k-fdd, 2657-j2f/s/p...

  • Page 111

    Product overview the following shows an overview of the system features. Feature description processor intel pentium iii processor 1.00/1.13ghz, intel celeron processor 1.06ghz bus architecture host bus 64bits/133 mhz, pci 32 bits/33 mhz, lpc 4bits/33mhz, pcmcia 16 bits, cardbus 32 bits/32 mhz syste...

  • Page 112

    Feature description ieee 1394 (optional) ti tsb43ab21 1394 controller on board ieee 1394.A 4–pin connector — no cable power 100mbps, 200mbps and 400mbps pc card (pcmcia) one type i/ii or type iii i/o ports external monitor speaker-out microphone-in dc-in tv-out (s-video out) parallel two usbs ieee 1...

  • Page 113

    7 6 symbol color meaning (1) drive in use green data is being read from or written to the hard disk. Do not enter standby mode or power off the computer when this indicator is on. (2) numeric lock green the numeric keypad on the keyboard is enabled. You enable or disable the keypad by pressing and h...

  • Page 114

    Symbol color meaning (6) battery status green enough battery power remains for operation. Blinking green the battery power charges up to 80% full power blinking orange the battery pack needs to be charged orange the battery pack is being charged. (7) standby mode green the computer is in standby mod...

  • Page 115

    Fru applicable test trackpont or pointing device if the trackpoint does not work, see if an external ps/2 mouse is connected to the mouse/keyboard connector and remove it. The trackpoint is automatically disabled if an external ps/2 mouse is attached. Check also if the trackpoint driver is correctly...

  • Page 116

    Fru removals and replacements this section contains information about removals and replacements. V do not damage any parts. Only certified and trained personnel should service the computer. V the arrows in this section show the direction of movement to remove a fru, or to turn a screw to release the...

  • Page 117

    Safety notice 8 translations in ″safety notices (multi-lingual translations) ″ section: before removing any fru, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Attention: the system board is sensitive and c...

  • Page 118

    1 2 note: the screw does not separate from the pci cover. 3 4 note: there are 2 cables on step 4 : the gray cable is the main antenna and the black cable is the auxiliarey antenna. Note: when you install the pci card, remember to press it down and ensure the connection is well. 112 thinkpad r30/r31 ...

  • Page 119

    1030 memory cover and memory card v “1010 battery assembly” on page 111 1 2 note: the screw does not separate from the memory cover. 3 to install the memory card: with the notched end of the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, in...

  • Page 120

    Pivot the memory card until it snaps into place. Side view 1040 hard disk drive assembly v “1010 battery assembly” on page 111 1 2 step size (quantity) color torque 1 m3 x l4 (1) black 3.2 kgf-cm 114 thinkpad r30/r31 hmm.

  • Page 121

    Warning do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data on the drive. Before removing the drive, have the user make a backup copy of all the information on the drive if possible....

  • Page 122

    1 step size (quantity) color torque 1 m2.5 x l10 (2) black 3.2 kgf-cm 2 3 4 116 thinkpad r30/r31 hmm.

  • Page 123

    Notes: 1. When replacing the keyboard, make sure that the cable is clean and insert it directly into the connector, making sure it makes contact with the bottom of the connector. 2. If the cable do not touch the bottom of the connector, the keyboard function will be rendered useless. 3. The cable of...

  • Page 124

    1 2 3 step size (quantity) color torque 2 m2.5 x l10 (1) black 3.2 kgf-cm 3 m2.5 x l10 (1) black 2.5 kgf-cm 118 thinkpad r30/r31 hmm.

  • Page 125

    1090 lcd assembly v “1010 battery assembly” on page 111 v “1060 keyboard” on page 115 v “1080 middle cover” on page 117 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 1 2 3 mt 2656, 2657, 2676 119.

  • Page 126

    Note: release the gray cable, which is the main antenna from the system. 4 4 5 step size (quantity) color torque 4 m2.5 x l10 (4) black 3.6 kgf-cm 5 m2.5 x l5 (1) silver 2.5 kgf-cm 6 1100 keyboard bezel v “1010 battery assembly” on page 111 v “1060 keyboard” on page 115 v “1080 middle cover” on page...

  • Page 127

    V “1070 backup battery” on page 117 1 step size (quantity) color torque 1 m2.5 x l10 (7) black 3.2 kgf-cm mt 2656, 2657, 2676 121.

  • Page 128

    2 caution: the keyboard bezel has several latches. When removing the keyboard bezel from the bottom cover, gently release these latches, then raise the side of the keyboard bezel facing the palm rest to remove it. Be careful not to break the latches. 1110 pcmcia holder v “1010 battery assembly” on p...

  • Page 129

    1 2 step size (quantity) color torque 2 m2 x l6 (3) silver 1.6 kgf-cm 3 4 note: before removing and replacing the pcmcia holder, make sure that the pcmcia cards are removed and the eject levers are sticking out. Mt 2656, 2657, 2676 123.

  • Page 130

    1120 auxiliary antenna v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1060 keyboard” on page 115 v “1080 middle cover” on page 117 v “1090 lcd assembly” on page 119 v “1070 backup battery” on page 117 v...

  • Page 131

    1 2 3 4 5 step size (quantity) color torque 3 m2.5 x l5 (2) silver 3.2 kgf-cm mt 2656, 2657, 2676 125.

  • Page 132

    1140 cpu assembly v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1060 keyboard” on page 115 v “1080 middle cover” on page 117 v “1090 lcd assembly” on page 119 v “1070 backup battery” on page 117 v “110...

  • Page 133

    1 2 step size (quantity) color torque 2 m2.5 x l5(3) silver 2.5 kgf-cm notes: 1. When removing the system board from the bottom cover, gently raise the side of the system board facing the rear i/o ports; then pull out the system board. 1160 speaker v “1010 battery assembly” on page 111 v “1020 mini-...

  • Page 134

    V “1030 memory cover and memory card” on page 113 v “1040 hard disk drive assembly” on page 114 v “1050 cd-rom assembly” on page 115 v “1060 keyboard” on page 115 v “1080 middle cover” on page 117 v “1090 lcd assembly” on page 119 v “1070 backup battery” on page 117 v “1100 keyboard bezel” on page 1...

  • Page 135

    1180 modem card (without combo card) v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1040 hard disk drive assembly” on page 114 v “1050 cd-rom assembly” on page 115 v “1060 keyboard” on page 115 v “1080 ...

  • Page 136

    1 step size (quantity) color torque 1 m2.5 x l5 (2) silver 3.2 kgf-cm 1190 hard disk drive bezel v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1040 hard disk drive assembly” on page 114 v “1050 cd-rom ...

  • Page 137

    1 step size (quantity) color torque 1 m2 x l6 (2) silver 1.6 kgf-cm 1200 cd-rom chassis v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1040 hard disk drive assembly” on page 114 v “1050 cd-rom assembly”...

  • Page 138

    1 2 3 step size (quantity) color torque 2 m2.5 x l5 (2) silver 3.2 kgf-cm 3 m2 x l6 (1) silver 1.6 kgf-cm 1210 lcd bezel assembly (13.3 ″) v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1060 keyboard” o...

  • Page 139

    1 2 3 step size (quantity) color torque 2 m2 x l4(2) silver 2.5 kgf-cm 3 m2.5 x l6(2) black 2.5 kgf-cm 3 4 5 6 7 3 note: when removing the lcd, take note of the following: v be careful not to scratch the lcd bezel when removing the screw mylars. Mt 2656, 2657, 2676 133.

  • Page 140

    V the lcd bezel has several latches. Release these latches; then remove the lcd bezel. Be careful not to break these latches. V gently push the two lcd latches outward to remove the lcd bezel. 1220 lcd inveter (13.3 ″) v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” o...

  • Page 141

    1 2 3 4 1240 lcd bracket hinge assembly (13.3 ″) v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1060 keyboard” on page 115 v “1080 middle cover” on page 117 v “1090 lcd assembly” on page 119 v “1210 lcd...

  • Page 142

    1 step size (quantity) color torque 1 m2 x l4 (4) silver 2.5 kgf-cm 1250 lcd fpc assembly (13.3 ″) v “1010 battery assembly” on page 111 v “1020 mini-pci cover and mini-pci card” on page 111 v “1030 memory cover and memory card” on page 113 v “1060 keyboard” on page 115 v “1080 middle cover” on page...

  • Page 143

    1 step size (quantity) color torque 1 m2 x l4(1) silver 2.5 kgf-cm 2 1260 wireless reassembly v “1240 lcd bracket hinge assembly (13.3″)” on page 135 v “1230 led board (13.3″)” on page 134 mt 2656, 2657, 2676 137.

  • Page 144

    138 thinkpad r30/r31 hmm.

  • Page 145

    Locations front view computer display ultrabay plus trackpoint system-status indicators power button volume & mute buttons rear view monitor connector modem connector power jack ethernet connector usb connector parallel port s-video out connector security keyhole bottom view 10 1 2 3 4 5 6 7 8 9 10 ...

  • Page 146

    3. Memory slot door 4. Docking connector 140 thinkpad r30/r31 hmm.

  • Page 147

    Switch locations boot block enable boot block enable boot block enable boot block enable chkpw enable chkpw enable boot block disable boot block disable chkpw disable chkpw disable chkpw enable chkpw enable boot block disable boot block disable chkpw disable chkpw disable mt 2656, 2657, 2676 141.

  • Page 148

    Parts list 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 22 23 23 note: the parts marked with asterisk are crus (customer replaceable units.) no. Description fru no. 1 hinge cap 26p9722 2 keyboard (“keyboard” on page 148) 3 middle cover asm ww 26p9727 4 kbd bezel asm. Ww 46l6378 5 cable a...

  • Page 149

    No. Description fru no. 6 antenna kit 13.3 ″ antenna kit 14.1 ″ antenna aux antenna lcd 26p9712 26p9711 7 cpu cel 1066 mhz 26p8155 cpu p-iii 1.00 ghz 26p8359 cpu p-iii 1.06 ghz 26p8283 cpu p-iii 1.20 ghz 26p8285 8 crypto card 26p8084 9 cdc modem card 26p8256 10 fan asm. 26p9723 11 heatsink 46l6365 1...

  • Page 150

    No. Description fru no. Lower case w/ label taiwan 46l6548 lower case w/ label india 46l6371 lower case w/ label india 2656 46l6549 lower case w/ label w/w 2657 46l6664 lower case w/ label emea 2657 46l6665 lower case w/ label iipc 2657 46l6666 lower case w/ label korea 2657 46l6667 lower case w/ la...

  • Page 151

    No. Description fru no. Dvd-rom module mke hlds(hitachi) 08k9648* 08k9646* cd-rw module sony teac 27l4231* 08k9644* cd-rw/dvd-rom combo module kme 08k9694* rubber kit pcmcia screw cap* 3 rubber foot * 3 lcd bezel screw cap (w/w) *4 ieee-1394 dummy label ieee-1394 icon label 26p9742 screw kit hdd coi...

  • Page 152

    Lcd fru 13.3-inch tft: 1 2 3 3 4 5 6 7 8 no. Description fru no. 1 13.3 ″ lcd bezel 46l6330 2 lcd panel asm (13.3 ″ tft) tori-sanyo lg 11p8212 11p8220 3 13.3 ″ hinge-bracket asm (r,l) 26p9720 4 lcd-invertor / led card (for 13.3 ″ & 14.1 ″ tft) 26p8139 lcd-invertor / led card —sumida (for 13.3 ″ & 14...

  • Page 153

    No. Description fru no. 7 lcd rear cover asm for 13.3 ″/14.1″ ( for wireless model ) 13.3 ″/14.1″ lcd rear cover 13.3 ″/14.1″ lcdpanel w/wireless ibm logo 26p9709 lcd rear cover asm for 13.3 ″/14.1″ 13.3 ″/14.1″ lcd rear cover 13.3 ″/14.1″ lcdpanel w/o wireless ibm logo 26p9707 8 lcd hinge cap 26p97...

  • Page 154

    No. Description fru no. 2 lcdpanel asm. (14.1 ″ tft) hyundai samsung lg 11p8214 11p8215 11p8210 3 14.1 ″ hinge-bracket asm (r,l) 26p9719 4 lcd-invertor / led card (for 13.3 ″ & 14.1 ″ tft) 26p8139 lcd-invertor / led card —sumida (for 13.3 ″ & 14.1″ tft) 26p8153 5 lcd cable asm. 27l0686 6 antenna kit...

  • Page 155

    Description vendor fru no. Kbd asm belgian nmb 02k6012* kbd asm switzerland nmb 02k6014* kbd asm portuguese nmb 02k6016* kbd asm russian nmb 02k6020* kbd asm slovakian nmb 02k6036* kbd asm slovenian nmb 02k6034* kbd asm traditional chinese nmb 02k6040* kbd asm turkish nmb 02k6026* kbd asm arabic nmb...

  • Page 156

    Description vendor fru no. Kbd asm slovakian chicony 02k6258* kbd asm japan chicony 02k6260* kbd asm traditional chinese chicony 08k4500* kbd asm korea chicony 08k4502* kbd asm la spanish chicony 08k4504* common parts list tools: description fru no. Tri-connector wrap plug 72x8546 pc test card 35g47...

  • Page 157

    Ac adapter: description fru no. Ac adapter, 72w 3-pin (astec) 02k6751* ac adapter, 72w 3-pin (delta) 02k6754* ac adapter, 72w 2-pin (astec) 02k6753* ac adapter, 72w 2-pin (delta) 02k6756* power cords: ibm power cords for a specific country are usually available only in that country. For 2–pin power ...

  • Page 158

    Recovery cd eng-xp home (ud) 32p6416 2656–65g, 6fg, 56g, 27g, 28g, 2fg, 57g, 26g, 31g, 35g, 5cg recovery cd eng-xp home (ud) 32p6415 2656–3fu, 25u, 7gu, 9fu, 6fu, 56u recovery cd eng-xp home (us) 32p6415 2656–7lh, 63h, 6gh, 5dh, 27h, 56h recovery cd eng-xp home (us) 32p6415 2656–65a, 56a, 27a, 4pa ;...

  • Page 159

    Recovery cd hongkong traditional chinese-xp home 62p8530 2656–6gb recovery cd turkey-xp home 32p6433 2656–56g, 6fg, 56g, 27g, 28g, 2fg, 28g, 26g, 31g, 35g, 5cg recovery cd greek-xp home 32p6434 2656–56g, 6fg, 56g, 27g, 28g, 2fg, 28g, 26g, 31g, 35g, 5cg recovery cd hungary-xp home 32p6435 2656–56g, 6...

  • Page 160

    Recovery cd netherland-winxp pro 32p6529 2656–e5g, efg, d8g, abg, ahg, afg, bbg, d9g, adg, ajg, d7g, j2g, 89g, 50g, hhg, mmg recovery cd finland-winxp pro 32p6528 2656–e5g, efg, d8g, abg, ahg, afg, bbg, d9g, adg, ajg, d7g, j2g, 89g, 50g, hhg, mmg recovery cd italy-winxp pro 32p6527 2656–e5g, efg, d8...

  • Page 161

    Recovery cd japan-winxp pro retail 46p6988 2656–75j/8fj/47j recovery cd traditional chinese-winxp pro 62p8525 2656–e5t, eft, e8t, eit, d6t, abt, j2t, mmt, hht recovery cd simplified chinese-winxp pro 62p8528 2656–e5c, efc, eic, e6c, j2c, hhc, mmc recovery cd hong kong traditional chinese-xp pro 62p8...

  • Page 162

    Recovery cd english -win 2000 (us) 32p6312 2656–e7u, heu, e4u, j1u, eeu, beu, a4u, aeu, feu, f4u, l4u, h5u, ffu, llu, h7u recovery cd english -win 2000 (us) 32p6312 2656–e4h, j1h, eeh, ffh, llh recovery cd english -win 2000 (us) 32p6312 2656–e4m, j1m, eem, bgm, aam, bim, e7m, ffm, llm ; e4a, j1a, ee...

  • Page 163

    Recovery cd portuguese- win2000 32p6316 2656–e4p, j1p, eep, ffp, llp recovery cd japan-win2000 46p6941 2656–6hj, 67j, 48j, ffj, eej, j1j, e4j, k8j, llj recovery cd traditional chinese-win2000 62p8523 2656–e4t, j1t, eet, fft, llt recovery cd simplified chinese-win2000 62p8526 2656–e4c, j1c, eec, ffc,...

  • Page 164

    Ultrabay devices: description fru no. Cd—rw drive (sony) 08k9617* diskette drive (teac) 08k9606* diskette drive (sony) 08k9607* superdisk drive (ls120 x 2) 05k9235* superdisk drive (ls240) 08k9615* zip—250 drive 00n8254* 2nd hdd adapter 08k6067* ultrabay plus device carrier 26p9388* ultrabay plus nu...

  • Page 165

    Thinkpad r31 part ii this section applies to the following models: 2656-2gx, 2656-2hx, 2656-2jx, 2656-2kx, 2656-2lx, 2656-1ax, 2656-2vx, 2656-1bx, 2656-2px, 2656-2mx, 2656-1cx, 2656-2cx, 2656-2nx, 2656-2ex, 2656-1dx, 2656-2gx, 2656-1fx, 2656-1gx, 2656-1ix, 2656-1jx, 2656-1kx, 2656-lx, 2656-mx, 2656-...

  • Page 166

    Product overview the following shows an overview of the system features. Feature description processor intel pentium iii processor 1.26ghz, intel celeron processor 1.13/1.20/1.33 ghz bus architecture host bus 64bits/133 mhz, pci 32 bits/33 mhz, lpc 4bits/33mhz, pcmcia 16 bits, cardbus 32 bits/32 mhz...

  • Page 167

    Feature description ieee 1394 (optional) ti tsb43ab21 1394 controller on board ieee 1394.A 4–pin connector — no cable power 100mbps, 200mbps and 400mbps pc card (pcmcia) one type i/ii or type iii i/o ports external monitor speaker-out microphone-in dc-in tv-out (s-video out) parallel two usbs ieee 1...

  • Page 168

    7 6 symbol color meaning (1) drive in use green data is being read from or written to the hard disk. Do not enter standby mode or power off the computer when this indicator is on. (2) numeric lock green the numeric keypad on the keyboard is enabled. You enable or disable the keypad by pressing and h...

  • Page 169

    Symbol color meaning (6) battery status green enough battery power remains for operation. Blinking green the battery power charges up to 80% full power blinking orange the battery pack needs to be charged orange the battery pack is being charged. (7) standby mode green the computer is in standby mod...

  • Page 170

    Fru applicable test trackpont or pointing device if the trackpoint does not work, see if an external ps/2 mouse is connected to the mouse/keyboard connector and remove it. The trackpoint is automatically disabled if an external ps/2 mouse is attached. Check also if the trackpoint driver is correctly...

  • Page 171

    Fru removals and replacements this section contains information about removals and replacements. V do not damage any parts. Only certified and trained personnel should service the computer. V the arrows in this section show the direction of movement to remove a fru, or to turn a screw to release the...

  • Page 172

    Safety notice 8 translations in ″safety notices (multi-lingual translations) ″ section: before removing any fru, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Attention: the system board is sensitive and c...

  • Page 173

    1 2 note: the screw does not separate from the pci cover. 3 4 note: there are 2 cables on step 4 : the gray cable is the main antenna and the black cable is the auxiliarey antenna. Note: when you install the pci card, remember to press it down and ensure the connection is well. Mt 2656, 2657, 2676 1...

  • Page 174

    1030 memory cover and memory card v “1010 battery assembly” on page 166 1 2 note: the screw does not separate from the memory cover. 3 to install the memory card: with the notched end of the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, in...

  • Page 175

    Pivot the memory card until it snaps into place. Side view 1040 hard disk drive assembly v “1010 battery assembly” on page 166 1 2 step size (quantity) color torque 1 m3 x l4 (1) black 3.2 kgf-cm mt 2656, 2657, 2676 169.

  • Page 176

    Warning do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data on the drive. Before removing the drive, have the user make a backup copy of all the information on the drive if possible....

  • Page 177

    1 step size (quantity) color torque 1 m2.5 x l10 (2) black 3.2 kgf-cm 2 3 4 mt 2656, 2657, 2676 171.

  • Page 178

    Notes: 1. When replacing the keyboard, make sure that the cable is clean and insert it directly into the connector, making sure it makes contact with the bottom of the connector. 2. If the cable do not touch the bottom of the connector, the keyboard function will be rendered useless. 3. The cable of...

  • Page 179

    1080 middle cover v “1010 battery assembly” on page 166 v “1060 keyboard” on page 170 1 2 3 step size (quantity) color torque 2 m2.5 x l10 (1) black 3.2 kgf-cm mt 2656, 2657, 2676 173.

  • Page 180

    Step size (quantity) color torque 3 m2.5 x l10 (1) black 2.5 kgf-cm 1090 lcd assembly v “1010 battery assembly” on page 166 v “1060 keyboard” on page 170 v “1080 middle cover” on page 173 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 1 2 3 17...

  • Page 181

    Note: release the gray cable, which is the main antenna from the system. 4 4 5 step size (quantity) color torque 4 m2.5 x l10 (4) black 3.6 kgf-cm 5 m2.5 x l5 (1) silver 2.5 kgf-cm 6 mt 2656, 2657, 2676 175.

  • Page 182

    7 1100 keyboard bezel v “1010 battery assembly” on page 166 v “1060 keyboard” on page 170 v “1080 middle cover” on page 173 v “1090 lcd assembly” on page 174 v “1070 backup battery” on page 117 1 176 thinkpad r30/r31 hmm.

  • Page 183

    Step size (quantity) color torque 1 m2.5 x l10 (7) black 3.2 kgf-cm 2 caution: the keyboard bezel has several latches. When removing the keyboard bezel from the bottom cover, gently release these latches, then raise the side of the keyboard bezel facing the palm rest to remove it. Be careful not to ...

  • Page 184

    1 2 step size (quantity) color torque 2 m2 x l6 (3) silver 1.6 kgf-cm 3 4 178 thinkpad r30/r31 hmm.

  • Page 185

    Note: before removing and replacing the pcmcia holder, make sure that the pcmcia cards are removed and the eject levers are sticking out. 1120 auxiliary antenna v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 1...

  • Page 186

    1 2 3 4 5 step size (quantity) color torque 3 m2.5 x l5 (2) silver 3.2 kgf-cm 180 thinkpad r30/r31 hmm.

  • Page 187

    1140 cpu assembly v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1060 keyboard” on page 170 v “1080 middle cover” on page 173 v “1090 lcd assembly” on page 174 v “1070 backup battery” on page 117 v “110...

  • Page 188

    1 2 step size (quantity) color torque 2 m2.5 x l5(3) silver 2.5 kgf-cm notes: 1. When removing the system board from the bottom cover, gently raise the side of the system board facing the rear i/o ports; then pull out the system board. 182 thinkpad r30/r31 hmm.

  • Page 189

    1160 speaker v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1060 keyboard” on page 170 v “1080 middle cover” on page 173 v “1090 lcd assembly” on page 174 v “1070 backup battery” on page 117 v “1100 key...

  • Page 190

    1180 modem card (without combo card) v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1040 hard disk drive assembly” on page 169 v “1050 cd-rom assembly” on page 170 v “1060 keyboard” on page 170 v “1080 ...

  • Page 191

    1 step size (quantity) color torque 1 m2.5 x l5 (2) silver 3.2 kgf-cm 1190 hard disk drive bezel v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1040 hard disk drive assembly” on page 169 v “1050 cd-rom ...

  • Page 192

    1 step size (quantity) color torque 1 m2 x l6 (2) silver 1.6 kgf-cm 1200 cd-rom chassis v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1040 hard disk drive assembly” on page 169 v “1050 cd-rom assembly”...

  • Page 193

    1 2 3 step size (quantity) color torque 2 m2 x l4 (1) silver 2.5 kgf-cm 3 m2.5 x l5 (1) silver 3.2 kgf-cm mt 2656, 2657, 2676 187.

  • Page 194

    4 5 step size (quantity) color torque 4 m2.5 x l5 (2) silver 3.2 kgf-cm 5 m2 x l6 (1) silver 1.6 kgf-cm 1210 lcd bezel assembly (13.3 ″) v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1060 keyboard” on ...

  • Page 195

    2 3 step size (quantity) color torque 2 m2 x l4(2) silver 2.5 kgf-cm 3 m2.5 x l6(2) black 2.5 kgf-cm 3 4 5 6 7 3 note: when removing the lcd, take note of the following: v be careful not to scratch the lcd bezel when removing the screw mylars. V the lcd bezel has several latches. Release these latch...

  • Page 196

    V “1090 lcd assembly” on page 174 v “1210 lcd bezel assembly (13.3″)” on page 188 1 step size (quantity) color torque 1 m2 x l10(4) black 2.5 kgf-cm 1230 led board (13.3 ″) v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory car...

  • Page 197

    3 4 1240 lcd bracket hinge assembly (13.3 ″) v “1010 battery assembly” on page 166 v “1020 mini-pci cover and mini-pci card” on page 166 v “1030 memory cover and memory card” on page 168 v “1060 keyboard” on page 170 v “1080 middle cover” on page 173 v “1090 lcd assembly” on page 174 v “1210 lcd bez...

  • Page 198

    V “1030 memory cover and memory card” on page 168 v “1060 keyboard” on page 170 v “1080 middle cover” on page 173 v “1090 lcd assembly” on page 174 v “1210 lcd bezel assembly (13.3″)” on page 188 v “1220 lcd inveter (13.3″)” on page 189 v “1230 led board (13.3″)” on page 190 v “1240 lcd bracket hing...

  • Page 199

    2 1260 wireless reassembly v “1240 lcd bracket hinge assembly (13.3″)” on page 191 v “1230 led board (13.3″)” on page 190 mt 2656, 2657, 2676 193.

  • Page 200

    Locations front view computer display ultrabay plus trackpoint system-status indicators power button volume & mute buttons rear view monitor connector modem connector power jack ethernet connector usb connector parallel port s-video out connector security keyhole bottom view 10 1 2 3 4 5 6 7 8 9 10 ...

  • Page 201

    3. Memory slot door 4. Docking connector mt 2656, 2657, 2676 195.

  • Page 202

    Switch locations boot block enable boot block enable boot block enable boot block enable chkpw enable chkpw enable boot block disable boot block disable chkpw disable chkpw disable chkpw enable chkpw enable boot block disable boot block disable chkpw disable chkpw disable 196 thinkpad r30/r31 hmm.

  • Page 203

    Parts list 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 22 23 23 24 note: the parts marked with asterisk are crus (customer replaceable units.) no. Description fru no. 1 hinge cap 26p9722 2 keyboard unit (“keyboard” on page 204) 3 middle cover asm ww 26p9727 4 kbd bezel asm. Ww 46l6378 5...

  • Page 204

    No. Description fru no. 6 antenna kit 13.3 ″ antenna kit 14.1 ″ antenna aux antenna lcd 26p9712 26p9711 7 cpu cel 1133 mhz 26p8156 cpu cel 1200 mhz 26p8157 cpu cel 1.33 ghz 26p8158 cpu p-iii 1.2 ghz 26p8285 cpu p-iii 1.266 ghz 26p8363 8 crypto card 26p8084 9 cdc modem card 26p8256 10 fan asm. 26p972...

  • Page 205

    No. Description fru no. Lower case w/ label korea 46p2535 lower case w/ label taiwan 46p2536 lower case w/ label india 46l6371 lower case w/ label india 2656 46p2542 lower case w/ label w/w 2657 46p2543 lower case w/ label emea 2657 46p2544 lower case w/ label iipc 2657 46p2545 lower case w/ label k...

  • Page 206

    No. Description fru no. 23 cd-rom module teac hlds(lg) 27l3436* 27l4301* dvd-rom module mke hlds(hitachi) 27l4351* 27l4355* cd-rw module sony teac 27l4231* 27l4297* cd-rw/dvd-rom combo module kme 27l4359* 24 heatsink dc-dc 46p2555 rubber kit pcmcia screw cap* 3 rubber foot * 3 lcd bezel screw cap (w...

  • Page 207

    No. Description fru no. Misc common battery knob battery latch battery spring cd-rom pull bar cd-rom latch cd-rom spring for latch cd-rom spring for cd-rom pull bar pcmcia door pcmcia spring 26p9740 lcd fru 13.3-inch tft: 1 2 3 3 4 5 6 7 8 no. Description fru no. 1 13.3 ″ lcd bezel 46l6330 mt 2656, ...

  • Page 208

    No. Description fru no. 2 lcd panel asm (13.3 ″ tft) tori-sanyo lg 11p8212 11p8220 3 13.3 ″ hinge-bracket asm (r,l) 26p9720 4 lcd-invertor / led card (for 13.3 ″ & 14.1 ″ tft) 26p8139 lcd-invertor / led card —sumida (for 13.3 ″ & 14.1″ tft) 26p8153 5 lcd cable asm. 27l0687 6 antenna kit 13.3 ″ lcd a...

  • Page 209

    14.1-inch tft: 1 2 3 3 4 5 6 7 8 no. Description fru no. 1 14.1 ″ lcd bezel (for w/w) 46l6329 2 lcdpanel asm. (14.1 ″ tft) hyundai samsung lg 11p8214 11p8215 11p8210 3 14.1 ″ hinge-bracket asm (r,l) 26p9719 4 lcd-invertor / led card (for 13.3 ″ & 14.1 ″ tft) 26p8139 lcd-invertor / led card —sumida (...

  • Page 210

    No. Description fru no. 7 lcd rear cover asm for 13.3 ″/14.1″ (for w/w) 13.3 ″/14.1″ lcd rear cover 13.3 ″/14.1″ lcdpanel w/wireless ibm logo 26p9709 lcd rear cover asm for 13.3 ″/14.1″ (for w/o w) 13.3 ″/14.1″ lcd rear cover 13.3 ″/14.1″ lcdpanel w/o wireless ibm logo 26p9707 8 lcd hinge cap asm. 2...

  • Page 211

    Description vendor fru no. Kbd asm greek nmb 02k6032* kbd asm japan nmb 02k6038* kbd asm korea nmb 02k6042* kbd asm la spanish nmb 02k6044* kbd asm us english chicony 02k6212* kbd asm canadian french chicony 02k6214* kbd asm german chicony 02k6212* kbd asm uk english chicony 02k6218* kbd asm french ...

  • Page 212

    Description fru no. Usb parallel test cable 05k2580 screwdriver kit 95f3598 5mm socket wrench 05k4694 screwdriver 27l8126 wireless antenna connector removal tool 08k7159 thinkpad hardware maintenance diskette version 1.10 note: the data may look the same with the sample hmm but the diskette version ...

  • Page 213

    For 2–pin power cords: ibm power cord part number used in these countries or regions 13h5264* canada, u.S.A. 13h5273* japan 36l8870* argentina for 3–pin power cords: note: the grounded adapter is required for full mprii compliance. If a 3–pin power cord came with your computer, see “safety informati...

  • Page 214

    Recovery cd italy-xp home 32p6425 2656–1dg, 2gg recovery cd spanish-xp home 32p6423 2656–1dg, 2gg recovery cd la-sp-xp home 32p6418 2656–2hx, 1ax recovery cd la-sp-xp home 32p6418 2656–2hs, 1as recovery cd denmark-xp home 32p6420 2656–1dg, 2gg recovery cd sweden-xp home 32p6424 2656–1dg, 2gg recover...

  • Page 215

    Recovery cd eng-xp pro (us) 01r534 2656–1cm, 1lm, 2pm recovery cd norway-xp pro 32p6530 2656–1cg, 2cg, 2eg recovery cd netherland-xp pro 32p6529 2656–1cg, 2cg, 2eg recovery cd finland-xp pro 32p6528 2656–1cg, 2cg, 2eg recovery cd italy-xp pro 32p6527 2656–1cg, 2cg, 2eg recovery cd spanish-xp pro 32p...

  • Page 216

    Recovery cd eng-win2000 (us) 01r534 2656–e7u, heu, e4u, j1u, eeu, beu, a4u, aeu, feu, f4u, l4u, h5u, ffu, h7u, cju: 2657–e4u, j1u, llu, f4u, feu recovery cd eng-win2000 (us) 01r534 2656–e4h, j1h, eeh, ffh: 2657–e4h, j1h, llh recovery cd eng-win2000 (us) 01r534 2656–e4m, j1m, eem, bgm, aam, bim, e7m,...

  • Page 217

    Notices references in this publication to ibm products, programs, or services do not imply that ibm intends to make these available in all countries in which ibm operates. Any reference to an ibm product, program, or service is not intended to state or imply that only ibm product, program, or servic...

  • Page 218

    Trademarks the following terms are trademarks or service marks of ibm corporation in the united states and other countries: ibm usb thinkpad trackpoint trackpoint iv the following terms are trademarks or service marks of other companies as follows: amd-k6-2 advanced micro devices, inc. Amd advanced ...