Parts & maintenance manual when performance matters. ™ warning if incorrectly used, this machine can cause severe injury. Those who use and maintain this machine should be trained in its proper use, warned of its dangers, and should read the entire manual before attempting to set up, operate, adjust...
This manual contains adjustment, maintenance, troubleshooting instructions, and parts list for your new jacobsen mower. This manual should be stored with the mower for reference during operation. Before you operate your mower, you and each operator you employ should read the manual carefully in its ...
3 table of contents 1 safety 1.1 operating safety............................................... 4 1.2 important safety notes ..................................... 5 2 specifications 2.1 product identification ........................................ 6 2.2 engine .......................................
1 safety 4 1 safety 1.1 operating safety ______________________________________________________ 1. Safety is dependent upon the awareness, concern, and prudence of those who operate or service the equipment. Never allow minors to operate any equipment. 2. It is your responsibility to read this manua...
Safety 1 5 1.2 important safety notes ________________________________________________ this safety alert symbol is used to alert you to potential hazards. Danger - indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Warning - indicates a potenti...
2 specifications 6 2 specifications 2.1 product identification _________________________________________________ 62305 .............................. Greens king iv, 50 state, 16 hp gasoline engine, manual steering. Without mowers. 62306 .............................. Greens king iv, 50 state, 18 hp...
Specifications 2 7 2.4 mower __________________________________________________________________ tires ................................ 18 x 9.5 - 8 tubeless 4 ply pressure:......................... 8-12 psi (55-83 kpa) battery: type .......................... 12 volt lead/acid group ...................
3 adjustments 8 3 adjustments 3.1 general ________________________________________________________________ 1. Adjustments and maintenance should always be performed by a qualified technician. If proper adjustment cannot be made, contact an authorized jacobsen dealer. 2. Replace, do not adjust , worn...
Adjustments 3 9 3.3 bedknife adjustment ___________________________________________________ 1. Read section 3.2 before making the adjustment. 2. Start adjustment at the leading end of the reel, followed by the trailing end. The leading end of the reel blades is that end which passes over the bedknif...
3 adjustments 10 3.5 reel bearing ___________________________________________________________ excessive end play or any radial play indicates bad bearings, a weak tension spring, or a backed off nut. 1. Check bearing housing mounting hardware. Tighten or replace components as required. Carefully cle...
Adjustments 3 11 3.8 leveling procedure ____________________________________________________ 1. Lower the implements until they are about 1/4 in. (6.35 mm) above the ground. If they are not level with the ground, adjust torsion spring (z) . 2. Carefully loosen spring mounting clamp and slowly turn c...
3 adjustments 12 3.11 parking brake _________________________________________________________ disengage brake lever and measure the distance between nut (ab) and bottom of pivot. Adjust nut so the distance is 3/16 in. (5 mm). Figure 3l 3.12 interlock switches ________________________________________...
Adjustments 3 13 3.14 traction lever _________________________________________________________ 1. Remove front cowling and adjust lever to align with the four positions on the instrument panel. 2. Adjust ball joints (ac) on rod (ad) and/or adjust position and number of washers (ae) for proper alignm...
3 adjustments 14 3.17 choke control_________________________________________________________ 1. Push choke control knob to the off position. 2. Set choke lever at carburetor to off (butterfly open) position. 3. Adjust control wire (at the carburetor) then clamp wire housing in place while keeping ch...
Adjustments 3 15 3.19 torque specification ___________________________________________________ jacobsen uses grade 5 bolts as standard, unless otherwise noted. Notice all torque values included in these charts are approximate and are for reference only. Use of these torque values is at your sole ris...
4 maintenance 16 4 maintenance 4.1 general ________________________________________________________________ 1. Adjustment and maintenance should always be performed by a qualified technician. If proper adjustments cannot be made, contact an authorized jacobsen dealer. 2. Inspect the equipment on a r...
Maintenance 4 17 4.3 engine oil ______________________________________________________________ check the engine oil at the start of each day, before starting the engine. If the oil level is low, remove oil filler cap and add oil as necessary. Perform initial oil change after the first 8 hours of ope...
4 maintenance 18 4.5 fuel ____________________________________________________________________ handle fuel with care - it is highly flammable. Use an approved container. The spout must fit inside the fuel filler neck. Avoid using cans and funnels to transfer fuel. • fill the fuel tank to within 1 in...
Maintenance 4 19 4.7 battery ________________________________________________________________ make absolutely certain the ignition switch is off and the key has been removed before servicing the battery. Apply a light coat of silicone dielectric grease to terminals and cable ends to prevent corrosio...
4 maintenance 20 4.10 hydraulic hoses _______________________________________________________ 1. Always lower implements to ground, disengage all drives, engage parking brake, stop engine, and remove key before inspecting or disconnecting hydraulic lines or hoses. 2. Check visible hoses and tubes da...
Maintenance 4 21 4.12 hydraulic fluid filters ________________________________________________ the hydraulic system is protected by one 20 micron filter. To replace hydraulic fluid filter: 1. Remove the old filter. 2. Fill new filter with clean hydraulic fluid then install new filter. Hand tighten o...
4 maintenance 22 4.16 wheel mounting procedure ____________________________________________ 1. Remove dirt, grease, and oil from stud thread. Do not lubricate threads . 2. Position wheel on hub and inspect to ensure full contact between mounting surface of wheel and hub or brake drum. 3. Finger tigh...
Maintenance 4 23 4.19 backlapping____________________________________________________________ check the reel and bedknife to determine if backlapping or grinding will restore the cutting edge. If wear or damage is beyond the point where the cutting edges can be corrected by the lapping process, they...
4 maintenance 24 4.20 storage________________________________________________________________ general 1. Wash the mower thoroughly and lubricate. Repair and paint damaged or exposed metal. 2. Inspect the mower, tighten all hardware, and replace worn or damaged components. 3. Clean the tires thorough...
Troubleshooting 5 25 5 troubleshooting 5.1 general ________________________________________________________________ the troubleshooting chart below lists basic problems that may occur during start-up and operation. For more detailed information regarding the hydraulic and electrical systems contact ...
6 maintenance and lubrication charts 26 6 maintenance and lubrication charts 6.1 general ________________________________________________________________ 1. Always clean the grease fitting before and after lubricating. 2. Lubricate with grease that meets or exceeds nlgi grade 2 lb specifications. Ap...
Maintenance and lubrication charts 6 27 6.3 maintenance charts ___________________________________________________ a - add or adjust c - clean i - inspect l- lubricate r - replace ar - as required * indicates initial service for new machines. ** every 250 hours or yearly, whichever comes first. *** ...
7 notes 28 7 notes.
Parts catalog 8 29 8 parts catalog 8.1 how to use the parts catalog _________________________________________ abbreviations n/s - not serviced separately, can only be obtained by ordering main component or kit. Ar -variable quantity or measurement is required to obtain correct adjustment. Symbols su...
30 2 1 n r green s kin g iv v-twin ohv manufactured under one or more of the followin g u. S . Patent s : xxxxxxx xxxxxxx xxxxxxx charlotte, nc made in u. S .A. ® a textron company b io d e g radable flu id ® 41 8 1 8 65 rev b 3 002051 3 002051 4141266 8-12 p.S.I. (55-83 kpa) 41 8 1 8 64 42051 83 3 ...
31 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 4179664 1 decal, jacobsen 2 2810349 1 decal, left side 3 4141266 1 decal, oil light 4 2810350 1 decal, right side 5 3002057 1 decal, ignition switch 6 4181865 1 decal, warning 7 3002053 1...
32 ® green s kin g iv plu s v-t win ohv b io deg rad ab le f l u i d b io d eg rada ble f lu id a b c d a b b b c c c d 1 2 3 4 5 5 5 5 20 5 5 5 5 6 7 8 9 10 11 11 11 11 12 1 3 / 14 19 15 16 16 17 17 1 8 1 8 1 8 1 8 21 22 2 3 24 greens king iv gas 2.1 front cowling serial no. 62305 - 1689 and up ser...
33 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 2810572 1 floorboard ● 2 n/s 1 pad, right floorboard ● 3 n/s 1 pad, left floorboard 4 2811918 1 cover, steering tower 5 403753 12 screw, 1/4-20 x 1/2” hex flange 6 2811542 1 panel, left s...
34 b b 1 2 3 4 4 5 5 6 6 7 8 9 10 11 12 1 3 1 3 1 3 1 3 1 3 14 14 14 14 14 15 15 15 15 15 16 17 1 8 1 8 19 19 20 20 21 greens king iv gas 3.1 floorboard and fenders serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
35 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 2810572 1 floorboard 2 2810705 1 fender, left side 3 2810706 1 fender, right side 4 400104 2 screw, 1/4-20 x 1/2” hex head 5 453023 2 flat washer, 1/4 6 445794 2 nut, 1/4-20 spiralock fla...
36 1 2 2 3 3 4 4 5 6 6 7 8 9 10 11 12 12 1 3 1 3 14 14 15 15 16 16 16 16 17 17 17 17 17 17 1 8 1 8 25 25 26 19 19 20 21 22 2 3 24 greens king iv gas 4.1 seat serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
37 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 2809868 1 skirt, top 2 400188 4 screw, 5/16-18 x 1” hex head 3 453009 4 flat washer, 5/16 4 338277 2 bracket, set mounting 5 345666 1 clamp, seat harness 6 445781 4 nut, 5/16-18 whizlock ...
38 1 1 1 1 1 2 3 4 4 5 5 6 6 6 7 8 9 9 10 10 10 10 11 12 1 3 14 15 15 16 17 1 8 19 19 19 19 20 21 22 22 22 22 22 2 3 2 3 2 3 2 3 2 3 2 3 24 25 26 27 2 8 29 3 0 3 1 3 2 33 3 4 3 5 3 6 3 7 3 7 38 45 3 9 40 41 42 4 3 44 in s trument panel component s lever s top s and decal s s witch panel s hour meter...
39 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 361646 2 fuse holder includes cap and panel nut 2 361700 1 fuse, 6 amp 3 364979 1 fuse, 20 amp 4 366751 1 light, yellow parking brake includes panel nut 5 164194 1 light, red engine oil i...
40 a b c d e a b c d e f f 1 2 2 2 2 2 2 2 2 2 2 3 4 4 5 6 7 7 8 8 9 9 10 10 10 11 11 11 12 1 3 1 3 1 3 14 14 15 16 17 1 8 1 8 1 8 19 19 20 20 20 21 21 21 21 22 22 22 22 2 3 24 24 24 25 25 26 27 2 8 29 3 0 3 1 3 2 33 3 4 3 5 3 6 3 7 38 3 9 3 9 greens king iv gas 6.1 lower control linkage serial no. ...
41 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 116536 1 valve, 5 spool stack see 35.1 2 502751 5 • kit, clevis and cotter pin 3 400216 3 screw, 5/16-18 x 2-3/4” hex head 4 446136 5 lockwasher, 5/16 heavy 5 443106 3 nut, 5/16-18 hex 6 ...
42 > change from previous revision 1 2 3 4 5 5 6 6 6 6 7 7 7 8 8 8 8 9 10 10 10 11 12 1 3 14 15 16 17 1 8 1 8 1 8 19 19 19 19 20 21 22 22 2 3 24 25 26 27 2 8 29 3 0 3 1 3 2 33 2 8 20 20 greens king iv gas 7.1 upper control linkage serial no. All.
43 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 131786 1 bracket, control linkage 2 353994 1 block, left side 3 354009 1 block, right side 4 400276 1 screw, 3/8-16 x 3 in. Hex head 5 400274 2 screw, 3/8-16 x 2-1/2 hex head 6 446142 4 l...
44 a a b b 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 11 11 12 1 3 1 3 14 15 16 16 17 1 8 1 8 19 20 21 22 2 3 24 25 26 27 2 8 29 3 0 3 1 3 1 3 2 33 3 4 3 5 3 5 3 6 3 6 3 6 3 7 38 3 9 40 41 42 4 3 44 greens king iv gas 8.1 pedal linkage serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
45 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 2811529 1 shaft, brake 2 352726 2 bushing, brake pedal shaft 3 2810683 2 bushing, shaft 4 2811528 2 spacer, brake 5 2809910 2 brake arm 6 434003 2 screw, 5/16-18 x 1” socket head 7 446136...
46 1 2 3 4 5 6 7 8 9 10 10 11 12 12 1 3 14 15 16 17 1 8 19 20 21 22 2 3 24 25 26 27 2 8 29 3 0 3 1 3 1 greens king iv gas 9.1 wheel motors and brakes serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
47 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 122675 2 wheel motor see 36.1 2 463027 1 • key 3 800778 2 • nut, 1-20 hex 4 400416 8 screw, 1/2-13 x 2-1/2” hex head 5 446154 8 lockwasher, 1/2 heavy 6 443118 8 nut, 1/2-13 hex 7 390742 2...
48 > change from previous revision 1 2 2 2 2 2 3 3 3 4 5 5 6 6 7 7 8 8 greens king iv gas 10.1 frame bushings greens king iv gas serial no. 62305 - 1689 and up item part no. Qty. Description serial numbers/notes 1 n/s 1 frame, greens king iv gas 2 3007694 6 • bushing, 1” shaft 3 357999 4 • bushing, ...
49 > change from previous revision 1 2 2 2 2 2 3 3 3 5 5 6 6 7 7 8 8 greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 frame, greens king iv plus gas 2 3007694 6 • bushing, 1” shaft 3 357999 4 • bushing, 7/8” shaft 4 503441 2 • wheel motor mounting bracket service o...
50 1 2 3 4 4 4 5 5 5 5 5 5 6 6 6 6 6 6 7 8 8 9 10 11 11 12 1 3 11 1 3 14 15 16 16 17 1 8 19 20 21 22 2 3 24 24 25 26 27 2 8 29 3 0 3 1 3 1 3 2 33 3 4 3 5 3 6 3 6 3 7 3 6 38 3 9 40 40 41 42 3 2 3 4 33 greens king iv gas 12.1 front frame serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
51 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 frame assembly see 10.1 or 11.1 for service 2 2810689 1 angle, left side valve mount 3 2810690 1 angle, right side valve mount 4 400262 6 screw, 3/8-16 x 1” hex head 5 446142 9 lock...
52 1 2 3 3 4 5 6 7 8 9 9 44 10 11 12 1 3 1 3 14 15 15 16 16 17 1 8 1 8 1 8 1 8 1 8 1 8 19 19 20 20 20 21 21 21 21 22 2 3 2 3 24 view rotated 1 8 0° 24 24 25 26 26 26 26 27 2 8 2 8 2 8 2 8 29 29 3 0 3 1 3 1 3 2 33 33 3 4 3 5 3 4 3 6 3 7 / 38 40 41 42 4 3 45 3 9 a a a greens king iv gas 13.1 rear fram...
53 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 frame assembly see 10.1 or 11.1 for service parts 2 403751 2 screw, 5/16-18 x 3/4” hex flange 3 445781 2 nut, 5/16-18 whizlock flange 4 4214600 1 bracket, throttle and choke 5 13289...
54 1 2 3 4 5 5 6 6 6 6 7 7 7 8 9 9 10 11 11 11 8 greens king iv gas 14.1 rops serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
55 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 4203340 1 rops assembly 1 4223360 1 • rops base 2 4250895 1 • right side rops tube 3 4250894 1 • left side rops tube 4 4223362 1 • connector tube 5 4223361 2 • spacer 6 446140 10 lockwasher...
56 1 2 2 3 4 5 6 7 8 9 10 11 12 1 3 14 15 15 16 17 1 8 19 20 20 21 22 2 3 24 26 26 27 27 greens king iv gas 15.1 steering axle manual steering units serial no. 62305 -1686 and up.
57 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 frame assembly 2 3007694 2 bushing, 1” shaft 3 471214 2 grease fitting, 1/4-28 straight 4 1004577 1 steering fork 5 345621 1 seal, steering shaft 6 360113 2 thrust washer 7 345401 1...
58 1 2 2 3 4 5 6 7 8 2 8 9 10 11 12 1 3 17 2 3 24 26 26 26 27 27 27 14 15 15 16 1 8 19 20 20 21 22 29 3 0 3 0 3 1 3 1 3 2 33 3 4 3 4 3 5 greens king iv gas 16.1 steering axle power steering units serial no. 62306 - 2013 and up.
59 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 frame assembly 2 3007694 2 bushing, 1” shaft 3 471214 2 grease fitting, 1/4-28 straight 4 1004577 1 steering fork 5 345621 1 seal, steering shaft 6 360113 2 thrust washer 7 345401 1...
60 a a 1 2 3 4 4 5 5 6 7 8 9 10 11 12 1 3 14 15 15 16 16 17 1 8 19 19 20 20 20 20 21 21 21 21 22 22 22 22 2 3 2 3 2 3 2 3 24 25 25 26 26 27 greens king iv gas 17.1 manual steering serial no. 62305 - 1686 and up.
61 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 354022 1 shaft, manual steering 2 463017 1 key, 3/16 x 3/4” woodruff 3 3002734 1 pulley, front cable 4 412015 2 screw, 5/16-18 x 5/8” square head 5 353349 2 bearing, self aligning 6 40018...
62 1 2 3 4 5 6 7 8 8 9 10 11 12 1 3 14 15 16 17 1 8 19 20 greens king iv gas 18.1 power steering valve serial no. 62306 - 2013 and up.
63 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 2811918 1 cover, steering tower see 2.1 2 4203680 1 mount, steering valve 3 400294 2 screw, 3/8-24 x 3/4” hex head 4 444744 2 locknut, 3/8-24 hex center 5 365206 1 lock pin 6 443810 2 nut...
64 1 2 3 3 4 4 4 4 5 5 5 5 5 5 5 5 6 6 6 6 6 6 6 7 7 7 8 8 8 9 9 9 10 10 10 11 11 11 12 1 3 14 15 16 17 1 8 19 20 greens king iv gas 19.1 engine mounts serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
65 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 ref 1 engine and pump assembly see 20.1 2 4221982 1 mount, engine 3 400194 4 screw, 5/16-18 x 1-3/4” hex head 4 453009 5 flat washer, 5/16 5 446136 15 lockwasher, 5/16 heavy 6 443106 14 n...
66 1 2 3 4 5 3 2 6 7 8 9 10 11 12 1 3 14 15 16 17 1 8 1 8 19 20 21 22 22 22 22 22 2 3 24 24 25 26 27 27 2 8 29 29 3 0 3 1 3 1 3 0 62 3 05 - green s kin g iv unit s 62 3 06 - green s kin g iv plu s unit s greens king iv gas 20.1 engine and pump serial no. 62305 - 1689 and up serial no. 62306 - 2013 a...
67 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 engine, briggs & stratton vanguard 2 5000440 1 • filter, engine oil 3 5000441 1 • filter, air 4 5000436 1 • filter, fuel 5 360970 1 clamp, wire harness 6 3008863 1 stand off, m6-1 7...
68 a a 1 2 3 3 4 4 5 5 5 5 6 6 6 7 7 8 9 9 10 11 12 1 3 14 15 16 17 1 8 19 19 19 19 19 19 19 19 19 19 19 20 21 22 2 3 24 24 24 24 25 26 27 2 8 29 3 0 3 1 3 2 33 3 4 3 5 3 5 greens king iv gas 21.1 fuel tank serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
69 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 390344 1 pan, tank support 2 337306 1 pad, neoprene 3 337295 2 pad, neoprene 4 400188 6 screw, 5/16-18 x 1” hex head 5 453009 10 flat washer, 5/16 6 445781 8 nut, 5/16-18 whizlock flange ...
70 1 2 3 4 4 4 5 6 7 8 9 10 11 12 1 3 1 3 14 15 16 17 1 8 19 19 19 20 21 22 greens king iv gas 22.1 tank hydraulics serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
71 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 123077 1 tank, hydraulic 2 3001393 1 hose, tank to pump inside 3 3001393 1 hose, tank to pump outside used on 62305 3 3003105 1 hose, tank to pump outside used on 62306 4 319914 4 clamp, ...
72 1 2 3 4 5 6 7 8 8 9 19 9 10 11 12 1 3 14 15 16 16 17 1 8 greens king iv gas 23.1 pump to valve hydraulics serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
73 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 4180906 1 pump, 4 section gear 62305 units - see 20.1 1 4243202 1 pump, 5 section gear pump 62306 units - see 20.1 2 350947 1 fitting, -10 37° x -10 orb straight 339899 1 • o-ring, -10 or...
74 1 2 2 2 2 2 3 4 5 5 6 7 7 8 8 9 10 11 11 12 1 3 14 15 16 16 17 17 1 8 19 20 20 21 22 12 14 1 3 greens king iv gas 24.1 traction hydraulics serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
75 > change from previous revision greens king iv plus item part no. Qty. Description serial numbers/notes 1 116536 1 5 spool valve see 35.1 2 350947 6 fitting, -10 37° x -10 orb straight 339899 1 • o-ring, -10 orb 3 116543 1 tube, valve to upper motor tube forward pressure 4 2500086 1 tube, upper m...
76 1 2 2 3 4 5 5 6 6 7 7 8 8 9 10 10 11 11 12 12 1 3 14 15 16 16 17 17 1 8 1 8 19 20 21 greens king iv gas 25.1 front reel hydraulics serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
77 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 116536 1 5 spool valve see 35.1 2 342199 2 fitting, -6 37° x -8 orb straight 339898 1 • o-ring, -8 orb 3 2500084 1 tube, left reel pressure 4 2500085 1 tube, right reel pressure 5 1000223...
78 1 2 3 4 5 5 6 7 8 9 10 11 11 12 1 3 14 14 15 16 16 17 1 8 19 20 21 22 2 3 24 25 26 27 2 8 3 2 29 3 0 3 1 greens king iv gas 26.1 rear reel and lift hydraulics serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
79 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 116536 1 5 spool valve see 35.1 2 342199 2 fitting, -6 37° x -8 orb straight 339898 1 • o-ring, -8 orb 3 1000536 1 tube, rear reel pressure 4 1001011 1 hose, center reel pressure 5 360039...
80 t p l r 1 2 3 4 4 ho s e item 4 5 5 ho s e item 5 6 6 ho s e item 6 7 8 8 9 10 ho s e item 10 11 greens king iv gas 27.1 steering hydraulics serial no. 62306 - 2013 and up.
81 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 4243202 1 pump, 5 section gear pump see 20.1 2 351399 1 fitting, -6 37° flare x -6 orb 45° 339897 1 • o-ring, -6 orb 3 4203884 1 bundle, power steering hoses 4 4203883 1 • hose, pump to s...
82 1 1 1 2 2 2 3 4 5 5 6 5 5 6 4 5 5 5 5 6 6 6 6 6 7 7 7 8 9 10 10 10 10 11 11 12 1 3 1 3 1 3 1 3 14 14 14 15 17 1 8 19 20 20 21 22 2 3 24 25 16 5 6 5 19 greens king iv gas 28.1 hydraulic clamps serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
83 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 361137 1 clamp, seven tube 2 357854 6 liner, tube clamp 3 361105 1 bracket, tube support 4 400122 4 screw, 1/4-20 x 2-1/4” hex head 5 452004 18 flat washer, 1/4 6 444708 13 locknut, 1/4-2...
84 1 1 2 3 4 5 6 6 7 7 8 8 9 10 10 10 10 10 11 11 12 12 12 12 1 3 1 3 14 14 14 14 15 15 16 16 17 17 1 8 1 8 19 19 20 20 20 20 21 22 2 3 2 3 24 24 25 25 26 27 2 8 2 8 29 29 3 0 3 0 3 1 3 1 3 2 33 3 4 3 5 3 5 3 5 3 6 3 6 3 6 1 8 a a 3 7 3 7 38 3 9 3 9 3 9 3 9 40 41 42 4 3 44 45 greens king iv gas 29.1...
85 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 460052 2 cotter pin, 3/16 x 1-1/2” 2 160033 1 cam, left side lift 3 160034 1 cam, right side lift 4 131675 1 lever, left side lift 5 131498 1 lever, right side lift 6 463017 4 key, 3/16 x...
86 1 2 2 3 4 4 5 5 6 7 8 9 10 11 12 1 3 14 15 16 16 17 1 8 19 20 20 21 22 2 3 24 25 26 27 2 8 29 3 0 3 1 3 2 33 3 4 3 5 3 6 3 6 3 7 3 7 38 38 greens king iv gas 30.1 center lift arm serial no. All.
87 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 frame assembly see 10.1 or 11.1 for service 2 3007694 2 • bushing, 1” shaft 3 354039 1 pin, cylinder mounting 4 367437 2 cotter pin, 9/64 x 1-1/4” 5 349213 ar bushing, 3/4 6 2811638...
88 s t a rter s olenoid fr a me gro u nd engine connection s s e a t s witch h a rne ss ho u r meter mow & b a ckl a p s witche s in s tr u ment p a nel s h u tdown rel a y mech a nic ’s s witch ignition s witch s t a rter 1 2 3 4 4 5 5 6 7 8 9 10 11 12 1 3 14 greens king iv gas 31.1 harness routing...
89 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 2811599 1 harness, main wire 2 3001411 1 solenoid cable 3 3003773 1 clamp, 1/4” see 5.1 4 361064 2 clamp, 5/8” see 12.1 5 345671 2 clamp, 3/4” see 28.1 6 345666 1 clamp, 1/2” see 21.1 7 3...
90 1 2 3 4 4 4 5 5 5 6 6 6 7 7 7 8 8 8 9 9 9 10 10 10 11 12 12 1 3 1 3 1 3 14 14 14 14 14 14 15 15 15 16 16 16 17 17 17 1 8 1 8 1 8 19 20 21 21 22 greens king iv gas 32.1 reel mounting serial no. All.
91 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 122786 1 lift yoke, left side 2 122787 1 lift yoke, right side 3 122783 1 lift yoke, center 4 5002569 3 housing, swivel see 29.1 or 30.1 5 3004063 1 • spring, compression 6 3004975 1 • pi...
92 1 2 2 3 4 5 5 6 6 7 8 8 9 9 9 9 9 10 10 11 11 12 1 3 14 14 15 15 16 16 17 17 1 8 19 19 20 20 20 21 22 24 2 3 greens king iv gas 33.1 outer reel assembly serial no. All.
93 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n/s 1 inner reel assembly see 34.1 2 1002224 2 zerk bolt 3 1004990 1 rear roller 4 3010422 1 • roller shaft 5 3010712 2 • bearing, roller 6 3010286 2 • seal, roller 7 2810043 1 shield, gr...
94 greens king iv gas 34.1 inner reel assembly serial no. All optional ma g knife bedknive s part number de s cription 41 3 1 3 69 22 ” high profile 41 3 1005 22 ” medi u m s ection 41 3 1001 22 ” low profile 41 3 1 3 70 22 ” to u rn a ment 41 3 100 3 22 ” su per to u rn a ment s tandard s tyle bedk...
95 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 3010293 1 stop, reel 2 1002256 1 bearing housing 3 336962 1 • seal, grease 4 500534 1 • bearing, cup and cone 5 471214 1 • grease fitting, 1/4-28 straight 6 471240 1 • vent fitting 7 4001...
96 12 12 9 9 9 18 18 17 9 9 9 26 26 26 26 26 26 2 3 4 5 7 8 11 10 15 22 7 8 6 13 20 21 27 27 28 29 14 24 25 19 23 16 1 greens king iv gas 35.1 5 section valve part no. 116536 serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
97 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 n / s — cover plate 2 2500568 1 main relief cartridge 3 2500567 1 • relief seal kit 4 2500795 ar • shim 0.020 thick 5 549748 1 • o-ring, viton 6 5000020 1 section, 4 way complete 7 549626...
98 8 matched s et matched s et 4 7 4 17 21 22 2 3 4 2 1 20 19 1 8 9 4 5 3 6 16 14 15 14 1 3 12 11 10 greens king iv gas 36.1 front wheel motor part number 122675 serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up.
99 > change from previous revision greens king iv plus gas item part no. Qty. Description serial numbers/notes 1 554513 7 special bolt 2 n / s 1 end cover 3 + 1 commutator vespel seal included in seal kit 4 + 5 seal ring included in seal kit 5 n / s 1 commutator 6 n / s 1 commutator ring 7 n / s 1 m...
100 .59 .37 .37 .37 .65 1500 psi 1500 psi 1500 psi 1700 psi .65 .65 .059 standard .052 "soft drop" 0.043” 1100 psi traction left reel center reel right reel lift/lower backlap valve backlap valve backlap valve left reel motor center reel motor right reel motor rear cylinder front cylinder load contr...
101 > change from previous revision .59 .37 .37 .37 .37 .65 11.9 11.9 1500 psi 1500 psi 1500 psi 1700 psi 921 psi in out rt lt v p c 1100 psi .65 .65 .059 standard .052 "soft drop" traction left reel center reel right reel lift/lower backlap valve backlap valve backlap valve left reel motor center r...
102 greens king iv gas 39.1 electrical schematic serial no. 62305 - 1689 and up serial no. 62306 - 2013 and up ◆ - indicates wire included in engine + - battery a i y b x s s l g interlock solenoid starter 20 amp 6 amp rd pu rd 30 85 86 87a 87 rd rd rd rd pu pu bu bu pu ignition switch fuel solenoid...
103 > change from previous revision a o-ring b greens king iv plus gas a b o-ring tubing o.D. Hose i.D. Thread size part number 1/8 5/16-24 459290 3/16 3/8-24 459291 1/4 7/16-20 339896 5/16 1/2-20 459293 3/8 9/16-18 339897 1/2 3/4-16 339898 5/8 7/8-14 339899 3/4 1-1/16-12 339900 7/8 1-3/16-12 459296...
104 index 1000223.......................77 1000224.......................77 1000348.......................39 1000514.......................53 1000536.......................79 1000537.......................79 1001010.......................39 1001011.......................79 1001012......................
105 index 350745 ........................ 91 350947 .................. 73 , 75 351107 ............ 73 , 79 , 81 351108 ............ 75 , 77 , 79 351109 ............ 73 , 77 , 79 351399 ............ 73 , 79 , 81 351956 ........................ 47 352726 .................. 43 , 45 353349 ................
106 index 4250894.......................55 4250895.......................55 4257771.................31 , 33 4257772.................31 , 33 4257812.......................37 4259671.......................69 4260072.................53 , 69 4262111.......................69 4263652.........................
107 index.
Jacobsen, a textron company 11108 quality drive, charlotte, nc 28273 www.Jacobsen.Com 800-848-1636 when performance matters. ™ equipment from jacobsen is built to exacting standards ensured by iso 9001 and iso 14001 registration at all of our manufacturing locations. A worldwide dealer network and f...