- DL manuals
- JBL
- Subwoofer
- BALBOA-SUB10
- Service Manual
JBL BALBOA-SUB10 Service Manual - page 19
Summary of BALBOA-SUB10
Page 1
Venue ™ series sub10 amplifier/subwoofer service manual jbl consumer products 250 crossways park dr. Woodbury, new york 11797 rev2 8/2006.
Page 2: - Contents -
- contents - basic specifications……………….….….….….…………….1 packaging…………………………….………………………......2 detailed specifications ……..…………….……………..3 connections..……………………………………………………5 operation ………….……………………………..…………….7 test set-up and procedure……..……….…….………….8 exploded view/parts list…………………………………..9 block di...
Page 3
Sub10 venture series 2.
Page 4
Jbl venue sub10 150w powered sub/ plate amp line voltage yes/no hi/lo line unit notes us 120vac/60hz yes 108-132 vrms normal operation eu 230vac/50-60hz yes 207-264 vrms normal operation, moms required asia 100vac/50hz yes 90-110 vrms normal operation parameter specification unit qa test limits cond...
Page 5
Parameter specification unit qa test limits conditions notes power on delay time 3 sec. Functional ac power applied transients/pops ato transient 5 mv-peak 10 @ speaker outputs turn-on transient 50 mv-peak 100 @ speaker outputs ac line cycled from off to on turn-off transient 50 mv-peak 100 @ speake...
Page 6
System connections if you have a dolby ® digital or dts ® receiver/processor with a low-frequency- effects (lfe) or subwoofer output: receiver/amplifier front speaker output in l r subwoofer or lfe output 0 0 andby in l r this figure shows how to connect bare wires to the speaker-level terminals. If...
Page 7
Risk of electric shock do not open c aution risk of electric shock do not open c aution risk of electric shock do not open sub10 power ac 120v~60hz 250 watts t3.15a l/250v "war ning: for continued protection against risk of fire, replace only with same type t 3.15a l/250v fuse" "ave r tis s e me nt:...
Page 8
Power on plug your subwoofer’s ac cord into a wall outlet. Do not use the outlets on the back of the receiver. Initially set the subwoofer-level control ¢ to the “min” position. Turn on your sub by pressing the power switch ª on the rear panel. Turn on your entire audio system and start a cd or movi...
Page 9
Sub10 test set up and procedure equipment needed: • function/signal generator/sweep generator • integrated amplifier • multimeter • speaker cables general unit function (uut = unit under test) 1) from the signal generator, connect line level (rca) cables to the subwoofer line level input jacks l/r o...
Page 10
Sub10 venture series 9.
Page 11
Sub10 venture series 10
Page 12
Sub10 120v electrical parts list part number description qty reference designator preamp pcb resistors 110-12472j52-e resistor4.7k 1/2w ±5% cf 52mm (rohs) 2 r201,r202 110-16102j26-e resistor 1k 1/6w ±5% cf 26mm (rohs) 4 r213,r214,r215,r254 110-16103j26-e resistor10k 1/6w ±5% cf 26mm (rohs) 15 r209,r...
Page 13
Part number description qty reference designator preamp pcb 195-10204hgw-e double color led 204hgw 3¢(rohs) 1 d209, miscellaneous 162-50062001-e 2pin 60mm red/black 1 for d209, 174-0rca326p-e jack rca-326 (rohs) 1 jk201, 174-2wp810a-e spk jack 8p red up black down with cap 1 jk203, 175-1c07v01-e wir...
Page 14
Part number description qty reference designator main pcb 135-3226m50-e electrolytic cap 22u 50v ±20% 2 c505,c506, 135-3227m16-e electrolytic cap 220u 16v ±20% 1 c118, 135-3476m16-e electrolytic cap47u 16v ±20% 1 c318, semiconductors 190-16tl074cn-e *i.C tl074cn st (rohs) dual op-amp 1 u301 192-161t...
Page 15
Part number description qty reference designator class d ass'y pcb (replacment of entire module is recommended, part# 051-b00012a-e). Semiconductors 190-16tl072dts-e smd i.C. Tl072cdt sgs thomson dual op-amp 1 ic1, 192-09124126qs-e smd transistor 2sc2412k-t146q/r 3 q1,q4,q5, 192-09139066rs-e smd tra...
Page 16
Sub10 venture series 15.
Page 17
Sub10 venture series 16.
Page 18
Sub10 venture series 17.
Page 19
Sub10 venture series 18.
Page 20
Sub10 venture series 19.
Page 21
Sub10 venture series 20
Page 22
, ic1 sub10 venture series 21.
Page 23
Sub10 venture series 22.
Page 24
Sub10 venture series 23.
Page 25
Sub10 venture series 24.
Page 26
Sub10 venture series 25.