Keating Of Chicago SERIES 2006 User Manual - Operating
GAS PRESSURE AT MANIFOLD
NATURAL Gas - 3.0 in. W.C.
LP Gas - 10.0 in. W.C.
MAXIMUM INCOMING GAS PRESSURE
NATUARAL Gas - 7.0 in. W.C.
LP Gas - 11.0 in. W.C.
NOTE: It is estimated that half of all service calls made
on Keating Incredible Frying Machine® (IFM) result
from an inadequate gas supply. During installation,
have a gas company representative make certain that
the fryer is receiving adequate gas pressure and
volume (see “Installation” or your serial plate on the
fryer door).
PROPANE GAS MAY EVENTUALLY LOSE ITS
ODOR AND PRECAUTIONS SHOULD BE TAKEN TO
ASSURE THAT IT IS NOT PRESENT EVEN THOUGH
YOU DO NOT DETECT AN ODOR. IF THERE IS ANY
DOUBT, YOU SHOULD CALL YOUR LOCAL
PROPANE GAS SUPPLIER FOR ASSISTANCE.
OPERATING
FILLING
NOTE: Before filling the fryer make certain the fryer
vessel is sanitized, dry and the drain valve is
completely closed. Refer to item 13 on page 16, or item
11 on page 18 for location of drain valve.
NOTE: We recommend that solid shortening not be
used in an Incredible Frying Machine (IFM) as they are
not equipped with a melt cycle. If solid shortening is
used, it should be melted prior to filling the fryer vessel.
Damage done by melting solid shortening in the fryer
vessel will void the warranty.
BE SURE THE HEAT TRANSFER TUBES ARE
COMPLETELY COVERED WITH OIL BEFORE
SWITCHING THE FRYER ON. IF OIL LEVEL DROPS
BELOW TOP OF HEAT TRANSFER TUBES, SEVERE
DAMAGE TO FRYER AND INJURY TO OPERATOR
MAY RESULT.
DO NOT MIX HOT OIL AND WATER IN ANY FORM.
Oil expands when heated. The “Max” line has been
provided to ensure optimum cooking while ensuring the
safety of the operator. Do not overfill the fryer vessel.
See Figure 3-1.
Figure 3-1
“Max” Level Line
Fill the fryer vessel with oil or MELTED solid shortening
up to the “Max” line.
LIGHTING
BEFORE ATTEMPTING TO LIGHT THE FRYER,
MAKE SURE THE GAS CONNECTIONS ARE
SECURE AND HAVE BEEN LEAK TESTED AND
THE FRYER HAS BEEN PROPERLY FILLED WITH
OIL.
Figure 2-4 IFM Control Panel
Control Panel with timers Model 2000
14” Control Panel with timers Model 2006
5