Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 1 wingspan.... 62” wing loading… 21-23 oz./sq. Ft. Fuselage length… 48” wing area… 687 sq. In. Engine required ... 2-stroke .40 to .50 weight……....
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 2 introduction congratulations and thank you for purchasing the lanier mariner 40. We are sure you will be happy with the quality of this kit an...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 3 4. Locate the servo mounting plate and remove the covering over the slot with a micro tip soldering iron. Not only does this remove the coveri...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 4 7. You will need two 6” servo lead extension for this next step. (not supplied), one for each wing. The extensions must be compatible with you...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 5 far side. Now fasten in place with the hardware supplied. 11. Temporarily plug the servo into the receiver. Turn on the radio and allow the se...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 6 17. Secure the float assembly in place with the hardware shown. Be sure to place the metal straps at an angle for secure mounting of screw. 18...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 7 21. Lay it on the wing. Trace around it and remove the covering inside the line. Remove ink line with paper towel and alcohol. Glue in place w...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 8 4. Turn the fuselage over and mark the outline on the bottom of the stab with felt tip pen 5. Remove the covering between the lines. 6. Lay th...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 9 hinging the elevator and rudder 1. Before hinging the elevator and rudder to the stab and vertical fin, locate the control horns and ca them i...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 10 installing servos and pushrods 1. The servo rails are pre-installed in the fuse. 2. Install the rudder and elevator servo using the hardware ...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 11 7. Install the pushrod support on the sleeves temporarily for alignment with the servos. Do not glue in place yet. 8. Plug the servos into th...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 12 1. Locate the engine pod with mast. Find the center of the firewall by drawing lines from each corner. Now strike a horizontal and vertical l...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 13 cowl installation 1. Unpack the cowl and cutout the opening for the engine as shown in the photo. Make it large enough so you can access the ...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 14 5. Drill four 1/16” dia. Holes, two on each side. Use a hand drill however a drill press will ensure straighter holes. Do both sides. 6. Inst...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 15 end so fuel line will not be cut. Make sure inside of tank is clean before installing stopper on tank. 2. Wrap fuel tank with bubble wrap (no...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 16 6. Remove the engine from the mount. Install the cowl and align the spinner back plate with the cowl leaving 1/16” to 3/32” clearance between...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 17 3. Trial fit the wing on the fuselage. The leading edge should fit snug against the front former. It may be necessary to increase the notch d...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 18 smooth. Be sure to cut out the notch for the mast, located in the center. 2. Trial fit the windshield on the fuselage. It may necessary to do...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 19 balance point forward it may improve the smoothness and tracking, but your mariner may require more speed for takeoff and become more difficu...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 20 which in turn will cause your engine to get hot or quit. Charge the batteries 1. Follow the battery charging procedure recommended in the rad...
Assembly instructions lanier r/c mariner 40 mk ii arf lanier r/c, inc.- p o box 458 - oakwood, ga 30566 - ph 770-532-6401 © copyright 2006 lanier r/c, inc. 21 we hope you enjoy the mariner as much as we did bringing it to you. Flying off the water is different. And different is what keeps us interes...