Maintenance guide 100 neilson street, onehunga, auckland, new zealand tel: 09 634 1483 fax: 09 634 6804 www.Crighton.Co.Nz.
Replacing the side bricks, rear baffle, top baffle and air tube: p300 open the door fully and look up inside the fire box. You will see the air tube and baffle above the firebox chamber, and two side bricks and a cast iron rear baffle. You will need to remove the two side bricks in the firebox befor...
To remove rear baffle: lift the bottom edge of the rear baffle to clear the lugs cast into the base of the firebox, and then rotate the bottom edge forward and lift the baffle out through the firebox door. To remove the air tube: the air tube is held in place by passing through holes in either side ...
To remove the baffle: the baffle is held up by ledges at both sides of the firebox. Lift the baffle and move to one side so the other side can drop past the ledge and then rotate the baffle down and out the firebox door. To replace the baffle: reverse the procedure above for removing the baffle. Ens...
Replacing the door glass, seal tape and door seal rope: open the door fully. You will see the glass is retained by a frame that clips into the hinge at the right side (facing the inside of the door) and held by two screws at the left side. The door seal rope is fitted into a groove formed in the gla...
Fit new ladder tape to the edge of the glass ensuring it is centered on the edge of the glass so that an equal amount of tape will extend down both faces of the glass when it is folded down. Make sure that the ends of the tape meet tightly at the join. A gap here will allow air leaks into the firebo...
