1. DL manuals
  2. Pacific Living
  3. Oven
  4. PL8304SS
  5. Owner's Manual

Pacific Living PL8304SS Owner's Manual

Summary of PL8304SS

  • Page 1

    1 pacific living outdoor gas oven owner’s manual (for the followings models: pl8304ss / pl8blk - outdoor oven without cart) warning: for outdoor use only warning: improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read this instruction manual t...

  • Page 2: Oven Operation 1-2-3

    2 attach your receipt here serial number____________________ purchase date____________________ questions, problems, missing parts? Before returning to your retailer, call our customer service department at 1-866-410-0408, monday - friday, 8 a.M. - 5 p.M., pst. Oven operation 1-2-3 before cooking: st...

  • Page 3

    Table of contents 3 safety information…………………………………….………...….……………..………….…………. 4 package contents…..………………..…..….……...…...................…………..………………………. 6 hardware contents………………………………………………………………..….………………….. 7 assembly instructions………………..……………….……………………….……………………..…..8 lp gas assembly…………………………...

  • Page 4

    Safety information 4 please read and understand this entire manual before attempting to assemble, operate or install the product. If you have any questions regarding the product, please call customer service at 1-866-410-0408 monday to friday from 8 a.M. To 5 p.M. Pst. 1. The installation of this ap...

  • Page 5

    Safety information 5 16. The cylinder used must include a collar to protect the cylinder valve. 17. Do not store a spare lp-gas cylinder under or near the appliance. 18. Never fill the cylinder beyond 80 percent full. 19. If the information in “17” and “18” is not followed exactly, a fire causing de...

  • Page 6

    Package contents 6 part number description qty a oven body 1 b smoker box 1 c cooking grate 2 d pizza stone 1 e bottom grill 1 f flame tamer 1 g drip tray 1 h control knob 1 i pvc feet 4 j manifold and regulator 1.

  • Page 7

    7 hardware contents the following item is included inside the outdoor oven carton: battery 1 pc the following items are not included inside the outdoor oven carton, but needed when assembling the outdoor oven. Phillips head screwdriver 1 pc the following items are included inside the outdoor oven bo...

  • Page 8

    8 before beginning assembly, make sure all parts are present. Compare parts with package contents list and hardware contents list. If any part is missing or damaged, do not attempt to assemble the product. Step 1： feet assembly attach m5*30 x 4pcs cross recessed cheese head screws and 4pcs pvc feet ...

  • Page 9

    9 step 4 ： oven body assembly install cooking grate (part c), bottom grill (part e), a knob, pizza stone (part d), smoker box (part b) and drip tray (part g) as shown. Make sure the plastic is removed from the drip tray. Step 5： your complete outdoor oven is now assembled. L.P. Gas installation gas ...

  • Page 10

    10 5. Connect the hose and regulator assembly to the tank valve .Hand-tighten the quick coupling nut clockwise to a full stop (as below shown). Do not use a wrench to tighten because it could damage the quick coupling nut and result in a hazardous condition. 6. Open the tank valve fully (countercloc...

  • Page 11

    11 warning: the type i connective coupling (see fig. 7) supplied with your oven must not be replaced with a different type of oven/tank connection system. Removal will result in loss of warranty, gas leakage, fire and severe bodily harm. Pig 7 external thread thermally sensitive nut type i valve han...

  • Page 12

    12 shuts off the flow of gas to a cylinder after 80% capacity is reached. This limits the potential for release of gas when the cylinder is heated, averting a fire or possible injury. The l.P. Cylinder must have a shut-off valve terminating in an l.P. Gas supply cylinder outlet specified, as applica...

  • Page 13

    13 shipment, installation or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks and immediately check the system if the smell of gas is detected. 1. Do not smoke while leak testing. 2. Extinguish all open flames. 3. Never leak test with an open fl...

  • Page 14

    14 preparation for ng conversion: before beginning conversion, make sure all parts are present. Compare parts with package contents. If any part is missing or damaged, do not attempt to convert. Contact customer service for replacement parts. 1. Turn off gas supply, and then remove cap on gas supply...

  • Page 15

    15 ng conversion instruction: before the conversion, make sure all control knobs are in the off position, lp tank valve is closed, and tank is disconnected from regulator and removed from oven. Next, open the door and remove the two cooking grills, smoker box, pizza stone, base grill and flame tamer...

  • Page 16

    16 use a screwdriver to loosen the screw that is used to fasten the burner cover. Turn the burner cover until the hole marked “ng” overlaps with the fixing hole on the burner. Put the screw back into the holes and tighten again. Use orifice removal tool to remove theφ1.2 lp orifice from the outdoor ...

  • Page 17

    17 put back the two cooking grills, smoker box, pizza stone and base grill into the right position. Use the 17x19 mm wrench to remove the regulator and then put on the ng hose. Fasten the hose using 17x19 mm wrench. Use the screw driver to put the conversion screw into the knob..

  • Page 18: Warning/avertissement

    18 when converting to natural gas, please be aware that the low heat setting of the main burners and searing burner is “ng low,” as shown on the control panel. “lp low” setting is not applied when converting to natural gas. After finish converting to natural gas, please attach below label and ng lab...

  • Page 19

    19 caution: if low flames or burner problems are observed after converting from lpg to ng, the natural gas lines may not be large enough. Refer to the “from house to oven” chart above for natural gas supply line specifications. Please contact a plumber to assure proper pressure at 7-inch water colum...

  • Page 20

    20 never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire. Verify the type of gas supply to be used, and make sure the serial plate agrees with that of the supply. Conversion kits are included, which will enable you to convert yo...

  • Page 21

    21 non-combustible material or construction by at least 24 in. (61 cm) from back and 24 in (61 cm) from side. (see the diagram below) 5. Never store or use gasoline or other flammable or volatile substances in the vicinity of this grill or in the vicinity of any other heat – generating appliance, be...

  • Page 22

    22 general rules do not leave the oven unattended while cooking! 1. Make sure the oven has been leak-tested and is properly located. 2. Light the oven burner using the instructions provided in this manual. 3. Turn the control knob to desired temperature - high or low - and preheat the oven for 10 mi...

  • Page 23

    23 operating instructions oven burner lighting warning: do not lean over oven when lighting. Turn off lp supply at cylinder when appliance is not in use. Main burner lighting instructions: 1. Check that the control knobs are in the off position. 2. Open valve at tank fully by turning counterclockwis...

  • Page 24

    24 using the oven light light operation instruction 1. Make sure the light’s power switch on the control panel is in the “off” position. 2. Connect power plug to properly grounded outlet. 3. Turn the light’s power switch to “on.” warning: keep any electrical supply cord away from any heated surface....

  • Page 25

    25 general maintenance - keep outdoor cooking gas appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. - do not obstruct the flow of combustion and ventilation air. - keep the ventilation openings of the cylinder enclosure free and clear from deb...

  • Page 26

    26 the oven. Wear a barbecue mitt and scrub the oven racks with a damp cloth. If the oven is allowed to cool down, cleaning the grates will be easier if removed from the oven and cleaned with a mild detergent. Stainless steel after initial usage, areas of the oven may discolor from the intense heat ...

  • Page 27

    27 1. Turn off/unplug and allow to cool before replacing bulb (lamp). Next, open the door and remove the two cooking grills, smoker box, pizza stone, base grill and flame tamer. 2. Use screw driver to remove the m5*35 screw x 4 pcs from the heat shield. And then remove the heat shield. 3. Use screw ...

  • Page 28

    28 4. Remove the front glass cover from the light housing so you can replace the bulb. 5. After replacement, clip the front glass door into the light housing. 6. Use m4*10 screw to affix the light assembly on to the back panel of the oven..

  • Page 29

    29 7. Use screw m5*35×4 pcs to affix the back heat shield onto the back panel of the oven. The order is: screw→back heat shield→heat insulation washer→flat washer→ oven back panel. 8. Finally, replace the two cooking grills, smoker box, pizza stone, base grill and flame tamer. Cleaning method follow...

  • Page 30

    30 warning to ensure continued protection against electric shock: 1. Connect to properly grounded outlets only. 2. Do not expose to rain. 3. Keep extension cord connections dry and off the ground. Bulb specification bulb type: halogen wattage: 20 watts per bulb voltage: 12 volts please contact custo...

  • Page 31

    31 oven door cleaning 1. Remove the m4*10 screw x 4 pcs from the oven door and then remove the oven door from the oven. 2. Remove the m4*10 screw x 7 pcs connecting the door exterior and interior, and then remove the m4*10 screw x 4 pcs from the door hinge. Remove the shoulder screw that attaches th...

  • Page 32

    32 4. After cleaning, re-assemble the oven door. Put the door interior onto the exterior and line up screw holes. Use m4*10 screw x 7 pcs to connect the door interior and exterior. Next, use the shoulder screw to affix the handle to the door. Finally, use m4*10 screw x 4 pcs to re-attach the hinge o...

  • Page 33

    Troubleshooting 33 troubleshooting solutions are provided for common questions below. You can also call the customer service department at 1-866-410-0408, 8 a.M. – 5 p.M., pst, monday to friday. Problem possible cause corrective action oven will not light. 1. The ignition wire came off the electrica...

  • Page 34

    Troubleshooting 34 burner orifice size main burner Φ1.8 mm 2. Clear ports of any obstructions. 3. Refill the lp tank. Low heat, lp gas. The propane regulator assembly incorporates an excess flow device designed to supply the oven with sufficient gas flow. Rapid changes in pressure can trigger the ex...

  • Page 35

    Warranty 35 pacific living inc. Outdoor oven limited one (1) year warranty pacific living outdoor ovens are covered under manufacturer warranty for one full year from the date of purchase. The warranty is for parts and labor. At the discretion of pacific living the unit will be repaired or replaced ...

  • Page 36

    Exploded parts diagram 36 for replacement parts, call our customer service department at 1-866-410-0408, 8 a.M. – 5 p.M., pst, monday to friday. 52 7 8 9 10 11 13 14 16 35 34 33 32 17 18 21 29 30 19 31 27 4 5 6 15 3 2 1 28 26 22 25 24 23 36 37 40 41 43 44 46 45 47 48 49 38 42 39 50 51 12 20

  • Page 37

    Exploded parts diagram 37 no. Part name qty no. Part name qty 1 heat shield pipe 4 27 round temp. Gauge 1 2 oven back heat shield 1 28 left glass fixing bracket 1 3 light assembly 1 29 control panel 1 4 handle buckle 1 30 knob bezel assembly 1 5 gas pipe 1 31 control knob 1 6 chimney assembly 1 32 l...

  • Page 38

    Replacement parts list 38 1 、 bg070-01 oven exterior * 1 pc 2. Bg070-02-00b oven interior * 1 pc 3. Bg070-24 burner bracket beam * 1 pc 4. Bg070b-03-01 oven back panel * 1 pc 5. Bg070-03a oven back heat shield * 1 pc 6. Bg070-10-00b burner assy. * 1 pc 7. Bg070-18 cooking grate * 2 pcs 8. Bg070-17b ...

  • Page 39

    Replacement parts list 39 21. Bg070b-66 orifice holder * 1 pc 22. Bg070b-09-03-00 oven door heat shield * 1 pc 23. Bg070b-09-00b oven door assy. * 1 pc 24. Bg070-45 oven door hinge * 2 pc 25. Bg070b-38 oven door glass * 2 pc 26. Bg070-30 temp. Gauge * 1 pc 27. Bg070-12-00 oven door handle assy. * 1 ...

  • Page 40

    Replacement parts list 40 45. Tyq-9b-ll516-00 hose and regulator * 1 pc 46. Dgp350np-55-00 match holder * 1 pc 47. Bg070b-73-00 flame tamer assy. * 1 pc 48. Bg070b-53 trolley top panel * 1 pc 49. Bg070b-54 trolley door horizontal beam * 1 pc 50. Bg070b-50-00 trolley left sidepanel assy. * 1 pc 51. B...