1 7014-259b november 30, 2017 notice: do not discard this manual classic bay 1200 pellet appliance model(s): cb1200m-mbk owner’s manual operation & care installer: leave this manual with party responsible for use and operation. Owner: retain this manual for future reference. Contact your dealer with...
2 7014-259b november 30, 2017 cb1200 freestanding 9.00 2017 2018 2019 jan feb mar apr may jun jul aug sep oct nov dec floor protector must be noncombustible material, extending beneath heater and to the front/sides/rear as indicated. Measure front distance (i) from the surface of the glass door. Flo...
November 30, 2017 7014-259b 3 cb1200 freestanding table of contents safety alert key: • danger!Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury. • warning!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury. • caution!Indicatesahazardoussitua...
4 7014-259b november 30, 2017 cb1200 freestanding b. Warranty policy s l e n a p y r o t c a rf e r d e d l o m x 4021-645h 10/15 page 1 of 2 hearth & home technologies limited lifetime warranty hearth & home technologies, on behalf of its hearth brands (“hht”), extends the following warranty for hh...
November 30, 2017 7014-259b 5 cb1200 freestanding warranty conditions: • this warranty only covers hht appliances that are purchased through an hht authorized dealer or distributor. A list of hht authorized dealers is available on the hht branded websites. • this warranty is only valid while the hht...
6 7014-259b november 30, 2017 cb1200 freestanding e. Mobile home approved • this appliance is approved for mobile home installa- tions when not installed in a sleeping room and when an outside combustion air inlet is provided. • thestructuralintegrityofthemobilehomefloor,ceil- ing, and walls must be...
November 30, 2017 7014-259b 7 cb1200 freestanding user guide 2 operating instructions a. Fire safety to provide reasonable fire safety, the following should be givenseriousconsideration: • installatleastonesmokedetectoroneachfloorofyour home. • installatleastonecarbonmonoxidedetectoroneachfloor of y...
8 7014-259b november 30, 2017 cb1200 freestanding when the thermostat calls for heat, the appliance will start up onthehighsettingforthefirst4minutesand15seconds,then automaticallyswitchtotheburnrateforwhichitisset.Ifthe appliance is set at one of the lower settings, it will run quieter but take lon...
November 30, 2017 7014-259b 9 cb1200 freestanding fuel adjustment rod thumb screw set screw hot while in operation. Keep children, clothing and furniture away. Contact may cause skin burns. Caution k. Ignition cycles 1. At the beginning of each ignition cycle, it is normal to see somesmokeinthefireb...
10 7014-259b november 30, 2017 cb1200 freestanding m. Clear space notice:clearances may only be reduced by means ap- proved by the regulatory authority having jurisdiction. Mantel: avoid placing candles and other heat-sensitive objectsonmantelorhearth.Heatmaydamagetheseobjects. Fire risk. Keep combu...
November 30, 2017 7014-259b 11 cb1200 freestanding w r figure 11.2 press and pull to remove press and pull to remove figure 11.3 power outlet terminal block. Center 2 screws for thermostat wires figure 11.1 thermostat operation digital display digital display back light heat (on) or off button tempe...
12 7014-259b november 30, 2017 cb1200 freestanding o. Frequently asked questions odorsandvaporsreleasedduringinitialoperation. • curing of high temperature paint. • openwindowsforaircirculation. Odorsmaybeirritatingtosensitiveindividuals. Caution issues solutions 1. Metallicnoise. 1. Noise is caused...
November 30, 2017 7014-259b 13 cb1200 freestanding 3 maintenance and service whenproperlymaintained,yourfireplacewillgiveyou many years of trouble-free service. Contact your dealer to answer question regarding proper operation, troubleshoot- ingandserviceforyourappliance.Visitwww.Quadrafire. Comtofi...
14 7014-259b november 30, 2017 cb1200 freestanding c. General maintenance and cleaning 1. Types of fuel depending on the type of fuel you are burning will dictate how oftenyouhavetocleanyourfirepot. Ifthefuelyouareburninghasahighdirtorashcontentoryou areburningshelledfieldcorn,itmaybenecessarytoclea...
November 30, 2017 7014-259b 15 cb1200 freestanding figure 15.1 heat exchanger cleaning rods 6. Cleaning heat exchanger chambers & drop tube • frequency:monthlyorevery1tonoffuel • by:homeowner theamountofashbuildupinthefirepotwillbeagoodguide to determine how often you should clean the heat exchang- ...
16 7014-259b november 30, 2017 cb1200 freestanding 11. Cleaning the glass • frequency:whenclearviewofthefirepotbecomes obscure • by:homeowner a. Appliance must be completely cool before cleaning glass. B.Vacuumflyashfromglassanddoorrope. C.Use a damp paper towel or any non-abrasive glass cleaner. Wi...
November 30, 2017 7014-259b 17 cb1200 freestanding 19. Clean exhaust exit behind the exhaust blower a.Open both the upper and lower right side panels. Figure 17.2. B.Usingaphillipsheadscrewdriverremovethe4screws from the clean-out plate and set aside. Figure 17.2. C.Useasmallvacuumhoseattachmenttocl...
18 7014-259b november 30, 2017 cb1200 freestanding withproperinstallation,operation,andmaintenanceyourappliancewillprovideyearsoftrouble-freeservice.Ifyoudoexperienceaprob- lem,thistroubleshootingguidewillassistaqualifiedservicepersoninthediagnosisofaproblemandthecorrectiveactiontobetaken. Thistroub...
November 30, 2017 7014-259b 19 cb1200 freestanding symptom possible cause corrective action sloworsmokystart-up (cont’d) dirtyexhaustand/orventingsystem. Check for ash build up in appliance, includingbehindrearpanels,firebox,heat exchanger, exhaust blower and venting. Feedsystemfailsto start. Outoff...
20 7014-259b november 30, 2017 cb1200 freestanding symptoms possible cause corrective action convection blower fails to start. #1 snap disc defective. Blower not plugged in. Blower is defective. Control box is defective. Replace snap disc. Check that blower is plugged into wire har- ness. Replace bl...
November 30, 2017 7014-259b 21 cb1200 freestanding a. Glass replacement (replace with 5mm ceramic glass only) • remove door from appliance and place face down on a protected surface to avoid scratching the door. • remove all door rope. 1. Replacing center glass note: do not let air wash spacers fall...
22 7014-259b november 30, 2017 cb1200 freestanding remove 2 screws remove 4 screws outside air flex hose convection blower c. Blower replacement 1. Convection blower replacement a.Usepropershutdownprocedurestoshutdownthe appliance and let it completely cool. B. The convection blower is located at th...
November 30, 2017 7014-259b 23 cb1200 freestanding 2. Exhaust blower replacement remove existing blower: a.Usepropershutdownprocedurestoshutdownthe appliance and let it completely cool and then unplug it. B. Use an 11/32” wrench or nut driver to loosen and removethe(6)nutsholdingmotormountplatetothe...
24 7014-259b november 30, 2017 cb1200 freestanding 6 reference materials 2. Convection blower the convection blower is mounted at the bottom rear of the appliance. There are 2 impellers, one on each side of the motor. The convection blower pushes heated air through the heat exchange system into the ...
November 30, 2017 7014-259b 25 cb1200 freestanding andoffasneeded.Powerisalwayspresentatsnapdisc#1. 18. Snap disc #2 (thermostat override) 200°f snapdisc#2isalsolocatedontherightsideoftheappliance between snap disc #1 and convection blower. There are 2 yellow wires connected to it. This snap disc wi...
26 7014-259b november 30, 2017 cb1200 freestanding power outlet terminal block. Center 2 screws for thermostat wires cleaning rods heat exchanger tubes figure 26.1 figure 26.2 figure 26.3 heat output fan speed reset button call light high high med low low outside air flex hose convection blower figu...
November 30, 2017 7014-259b 27 cb1200 freestanding c. Service and maintenance log date of service performed by description of service.
28 7014-259b november 30, 2017 cb1200 freestanding date of service performed by description of service.
November 30, 2017 7014-259b 29 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active classic bay freestanding pellet stove 1 5 2 3 6 7 12 9 8 4 10 11 13 14 15 16 21 17 18 19 20 22 23 24 25 26 33 35 37 38 39 40 31 29 28 27 30 36 32 ...
30 7014-259b november 30, 2017 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to ...
November 30, 2017 7014-259b 31 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to ...
32 7014-259b november 30, 2017 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to ...
November 30, 2017 7014-259b 33 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to ...
34 7014-259b november 30, 2017 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to ...
November 30, 2017 7014-259b 35 cb1200 freestanding service parts r cb1200m-mbk beginning manufacturing date: april 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to ...
36 7014-259b november 30, 2017 contact information hearth & home technologies 352 mountain house road halifax, pa 17032 division of hni industries please contact your quadra-fire dealer with any questions or concerns. For the number of your nearest quadra-fire dealer log onto www.Quadrafire.Com do n...