Quadra-Fire SANTAFE-MBK Installation Manual - page 2
2
7050-145E
August 3, 2015
SANTA FE FREESTANDING
TABLE OF CONTENTS
Safety Alert Key:
• DANGER!Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION!Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
1
Important Safety Information ............3
A. Appliance Certifi cation ......................................................3
B. BTU & Effi ciency Specifi cations........................................3
C. Glass Specifi cations .........................................................3
D. Electrical Rating................................................................3
E. Mobile Home Approved .................................................... 3
2
Getting Started ...................................4
A. Design, Installation & Location Considerations ..........................4
B. Thermostat Wall Control Location......................................5
C. Tools And Supplies Needed ..............................................5
D. Inspect Appliance and Components .................................5
E. Install Checklist ..................................................................6
3
Dimensions and Clearances .............7
A. Appliance Dimensions ......................................................7
B. Clearances to Combustibles (UL and ULC) .......................8
C. Hearth Pad Requirements (UL and ULC) ..........................8
4
Vent Information .................................9
A. Venting Termination Minimum Requirements ...................9
B. Avoiding Smoke and Odors ..............................................10
C. Negative Pressure ............................................................10
D. Draft .... .............................................................................11
E. Chimney and Exhaust Connection ..................................11
F. Venting Termination Requirements ...................................11
G. Equivalent Feet of Pipe ...................................................12
H. Pipe Selection Chart ........................................................12
I. Pellet Venting Charts..........................................................13
5
Venting Systems ..............................14
A. Alcove ..............................................................................14
B. Through The Wall .............................................................15
C. Vertical into Existing Class A Chimney .............................16
D. Through The Wall & Vertical - Exterior ..............................16
E. Vertical - Interior - Typical Installation ................................16
F. Masonry.............................................................................17
G. Alternate Masonry ............................................................17
6
Appliance Set-Up .............................18
A. Outside Air Kit Instructions ................................................18
C. Top Vent Adapter Installation ............................................19
D. Rear Vent & Rear Vent to Top Vent Adapter Installation ...19
E. Optional Log Set Placement Instructions ..........................20
F. Thermostat Installation ......................................................20
G. Optional Nickel or Black Nickel Grille ................................22
7
Mobile Home Installation .................23
8
Accessory List .................................24