Quik N’ Crispy GF – II Operator's Manual - page 24
©2006 QNC, Inc. 0106 Operator’s Manual
23
For complete cleaning at the end of the day, repeat the above procedure, and then:
1. Remove the Cooking Basket Assembly from the Quik n’ Crispy, and
with the use of oven mitts, lift the Removable Front Panel that is located
directly above the Cooking Basket by applying slight upward pressure.
Pull the Splashguard out of the top of the cooking chamber and then
remove the Drip Tray from the cooking chamber. After you have
allowed the Separation Wall to cool down, remove it from the interior of
the Quik n’ Crispy (The time to cool the Separation Wall can be reduced
by turning on the fan motor only with the power switch pushed to the left
“Fan Only” position).
2. Place the Cooking Basket, Drip Tray, Splashguard, the two piece
Removable Front Panel, and Separation Wall (which has been removed
according to a reversal of the installation procedures on pages 7 and 8 of
this manual) into a sink containing a pre-soak solution with a commercial
degreaser. We suggest that the use of a wire brush for cleaning the
Cooking Basket and green scrubbing pad for other stainless steel items.
The items should then be cleaned according to local health department
guidelines. This usually requires the steps of washing, rinsing, sanitizing,
and air-drying.
An alternative to cleaning these 4 parts in your sink is to soak them
overnight in a solution of Dip Tank Cleaner (DTC-2), and water.
CAUTION: ALWAYS WEAR RUBBER GLOVES AND EYE
PROTECTION WHEN HANDLING CAUSTIC CHEMICALS.
DTC-2 is a caustic chemical available from either your Quik n' Crispy
distributor or QNC, Inc. Please call 1-888-668-3687 for more
information. A complete 2 lb. Jar of DTC-2 should be added to 8 gallons
of water in a 10-gallon storage container. This solution should be reused
for 30 to 45 days depending on the quantity and types of foods prepared
in the Quik n’ Crispy. A minimum of 4 hours of soaking is
recommended to remove baked-on carbonized grease that may be on
these parts. During this time the grease will dissolve and the Cooking
Basket, Drip Tray, Splashguard, two piece Removable Front Panel, and
Separation Wall will be cleaned of the carbonized build-up. Prior to re-
inserting these parts into your Quik n' Crispy, wash, rinse and sanitize
them. Allow them to air dry and then place them back into the Quik n'
Crispy.
3. Depending on the amount of carbonized food accumulation on the inside
of the Quik n' Crispy, it may be necessary to clean the inside of the