Sussman SSB 12-18 Installation, Operation And Maintenance Manual
TABLE OF CONTENTS
Dimensional Information and
Component Identification
. . . . . . . . . . . . . . . . . 2
Dimensional & Clearing Specifications
. . . . . . . . . 3
Wiring Diagrams
. . . . . . . . . . . . . . . . . . . . . . . . . 4-5
Installation
Piping, Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Pre-Operation Check
. . . . . . . . . . . . . . . . . . . . . . . . 7
Pressure Controls, Operation & Testing
. . . . . . . . 7
Operation
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Blowdown
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Timing Switch
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Digital Timer Operation Instructions
. . . . . . . . . . 10
Maintenance
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Standard Equipment
Auxiliary Low Water Cut Off
. . . . . . . . . . . . . . . . 12
Line Pressure Water Feed System
. . . . . . . . . . . . . 12
Optional Equipment
. . . . . . . . . . . . . . . . . . . . . . . 12
High Pressure Water Feed System
. . . . . . . . . . . . . 12
Automatic Blowdown System
. . . . . . . . . . . . . . . . 12
Blowdown Separators
. . . . . . . . . . . . . . . . . . . . . 13
Control Voltage Stepdown Transformer
. . . . . . . . 13
Multistage Load Progressive Sequencers
. . . . . . . . 13
Blowdown Separator Tanks
. . . . . . . . . . . . . . . . . 14
Specification Charts
. . . . . . . . . . . . . . . . . . . . . . . 15
Sizing
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Gauge Glass Installation
. . . . . . . . . . . . . . . . . . . . 17
Gauge Glass Use and Care
. . . . . . . . . . . . . . . . . . 18
Element Replacement
. . . . . . . . . . . . . . . . . . . . . . 19
SSB Boilers have Stainless Steel all wetted metal parts. SSB
boilers shall be operated using only deionized water, having
a maximum conductance of 1 microSiemen per cm
(1
µ
S/cm) [minimum specific resistivity of 1 megohm per cm
(1
ΜΩ
/cm)].
PRODUCTS COVERED BY THIS MANUAL:
Max
Series
KW Range
Steam Rate*
BHP
Design Pres.
Work Pres.
______________________________________________________________________
SSB
12-180
36-542 lbs/hr 1.2-18.4
0-100 psig
85 psig
*Steam Rate- Steam @ 212 F with 50 F feed water
A Division of Sussman-Automatic Corporation
43-20 34th Street, Long Island City, NY 11101 • 718-937-4500
1-800-238-3535 • Fax: 718-937-4676 • email: seb@sussmancorp.com
www.sussmanboilers.com
PUR 101137SSB
3/13
states a hazard
which may cause serious injury or
death if precautions are not followed.
signals a situation where
minor injury or product damage may occur
if you do not follow instructions.
IMPORTANT NOTE:
This highlights information that is especially
relevant to a problem-free installation.
IMPORTANT NOTE:
As you follow these instructions, you will notice warning and caution symbols. This blocked information is important for the safe and efficient
installation and operation of electric boilers. These are two types of potential hazards that may occur during this installation and operation:
Model No. SSB- __________________
Boiler Serial No. _________________
National Board No.
______________
Safety Valve Set Pressure________psig
Power Circuit Voltage
____________
Control Circuit Voltage ___________
Amps _____ Phase _____ HZ ______
IMPORTANT:
This data file contains the National Board
Registration Certificate approving your boiler. It must be
kept near the boiler at all times.
M A D E I N U S A
!
C A U T I O N
!
WA R N I N G
SSB Installation, Operation
and Maintenance Manual