Www.U-lineservice.Com phone (414) 354-0300 • fax (414) 354-7905 service & parts tech lines phone (800) 779-2547 • fax (414) 354-5696 onlineservice@u-line.Com ©2005 u-line corporation 02/2005 2075wc wine captain ® and 2075wcol wine captain ® with overlay installation guide ™.
2075wc/2075wcol wine captain ® www.U-lineservice.Com 2 02/2005 ™ contents exterior cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 cut-out dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 product dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . ...
02/2005 3 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® general precautions use this appliance for its intended purpose only and follow these general precautions along with those listed throughout this guide: warning shock hazard — electrical grounding required. • keep the unit unplugged th...
2075wc/2075wcol wine captain ® www.U-lineservice.Com 4 02/2005 ™ after all the protective coating has been removed from the unit/door, clean all stainless steel surfaces with claire stainless steel polish and cleaner or comparable product or a mild detergent and warm water solution and soft cloth. D...
02/2005 5 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® product dimensions please note that the unit has adjustable feet that can add one additional inch to height during leveling or to match adjacent cabinets (see figure 29 on page 13). Door swing/clearances information black, white and wo...
2075wc/2075wcol wine captain ® www.U-lineservice.Com 6 02/2005 ™ 2. Remove plastic screw plugs (3 each, top and bottom) from new hinge location. Do not discard (see figure 6). 3. Remove top hinge (3 screws), reinstall hinge screw pin, and remount on opposite side bottom (see figure 7). 4. Remove the...
02/2005 7 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® side-by-side installation instructions for a complete refreshment center, install your 2075wc or 2075wcol unit beside a u-line refrigerator, ice maker or combo model (see figure 11 for typical cut-out). Note that each side-by-side inst...
2075wc/2075wcol wine captain ® www.U-lineservice.Com 8 02/2005 ™ staining wood trim a different color 1. Remove each wine rack by sliding it out and up. See figure 12. 2. Remove and save screws securing wood trim to the racks. 3. Apply minwax water-based wood stain to wood with a synthetic foam brus...
02/2005 9 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® 2. Typical routing dimensions are shown in figure 14. 3. Create a relief for pivot plate by cutting notch in top corner and coinciding back corner of overlay frame. Refer to figure 15 for exact specifications. Route notch in top corner...
2075wc/2075wcol wine captain ® www.U-lineservice.Com 10 02/2005 ™ installation instructions preparing door note: door is not attached. It is in a separate box inside the unit box and taped to the unit. 1. Lay door on a clean, flat surface with the gasket facing up. 2. Pull gasket completely out of t...
02/2005 11 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® 3. Secure the front of the door to the back of the overlay frame using tape on all four corners, as shown in figure 20. Make sure all four edges are aligned. 4. Place door and overlay frame on a flat, clean protective surface. Use the...
2075wc/2075wcol wine captain ® www.U-lineservice.Com 12 02/2005 ™ checking door alignment the unit’s door is aligned at the factory before shipment. However, its alignment could have been disturbed during shipment or during overlay frame installation. Important properly aligned, the door should be 1...
02/2005 13 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® electrical specifications caution electrical installation must observe all state and local codes. This unit requires connection to a grounded (three- prong), polarized receptacle that has been placed by a qualified electrician. The un...
2075wc/2075wcol wine captain ® www.U-lineservice.Com 14 02/2005 ™ anti-tip bracket installation 1. Locate two anti-tip brackets included inside the unit. 2. Place the unit into the area where it will be installed. Check the door, sides and top for a proper fit. Also test to make sure the door opens ...
02/2005 15 www.U-lineservice.Com ™ 2075wc/2075wcol wine captain ® installation troubleshooting problem q: the door remains open unless it is pushed closed. Solution a: the hinges should be self-closing when the door is open approximately 8". If this is not the case, make sure the closers (at the bot...
™ ©2005 u-line corporation publication no. 30054e 02/2005 rev. A u-line corporation, located in milwaukee, wi, is a family operated manufacturer of built-in undercounter icemakers, combo ® icemaker/refrigerators, wine captain ® wine storage units, refrigerators, refrigerated drawers and refrigerator...
