1. DL manuals
  2. U-Line
  3. Refrigerator
  4. CLRCO2075
  5. Installation Manual

U-Line CLRCO2075 Installation Manual

Manual is about: Echelon Series

Summary of CLRCO2075

  • Page 1

    Www.U-lineservice.Com phone (414) 354-0300 • fax (414) 354-7905 service & parts tech lines phone (800) 779-2547 • fax (414) 354-5696 onlineservice@u-line.Com ©2005 u-line corporation 02/2005 clrco2075 — clear ice maker/refrigerator installation guide ™.

  • Page 2

    Www.U-lineservice.Com 2 02/2005 ™ clrco2075 — clear ice maker/refrigerator contents exterior cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 cut-out dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 product dimensions . . . . . . . . . . . . . . . . . . . . . ...

  • Page 3

    02/2005 3 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator general precautions use this appliance for its intended purpose only and follow these general precautions along with those listed throughout this guide: warning shock hazard — electrical grounding required. • keep the unit un...

  • Page 4

    Www.U-lineservice.Com 4 02/2005 ™ clrco2075 — clear ice maker/refrigerator after all the protective coating has been removed from the unit/door, clean all stainless steel surfaces with claire stainless steel polish and cleaner or comparable product or a mild detergent and warm water solution and sof...

  • Page 5

    02/2005 5 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator product dimensions please note that the unit has adjustable feet that can add one additional inch to height during leveling or to match adjacent cabinets (see figure 43 on page 17). Door swing/clearances information black and...

  • Page 6

    Www.U-lineservice.Com 6 02/2005 ™ clrco2075 — clear ice maker/refrigerator 4. Remove the two door closer inserts from the existing bottom hinge and install as shown on the new bottom hinge (see figure 8). 5. Remove existing bottom hinge (3 screws) and remount on opposite side top. Remove hinge screw...

  • Page 7

    02/2005 7 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator side-by-side installation instructions for a complete refreshment center, install your clrco2075 clear ice maker/refrigerator beside a u-line drawer or wine captain model (see figure 11 for typical cut-out). Note that each si...

  • Page 8

    Www.U-lineservice.Com 8 02/2005 ™ clrco2075 — clear ice maker/refrigerator 3. Pull door gasket out of groove (top edge of door only). Start in the middle and pull outward, moving toward the edge (see figure 13). This may take some force. Do not remove the three screws behind gasket. 4. Remove two ou...

  • Page 9

    02/2005 9 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator route notch in top corner of overlay panel as shown (see top and side views). Top of notch is entire depth of panel, front to back. Width: 13/16" depth: 1/8" route notch in backside of top corner of overlay panel (see back an...

  • Page 10

    Www.U-lineservice.Com 10 02/2005 ™ clrco2075 — clear ice maker/refrigerator 5. Remove the top handle and discard. (this handle will be replaced with the modified handle included in the full overlay door panel kit.) 6. Remove the two screws located on both sides of the lower handle. Remove the handle...

  • Page 11

    02/2005 11 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator 5. Remove the existing bottom pivot plate and replace with the full overlay pivot plate (see figure 23). Important door panel and overlay panel must be aligned properly or the door will not operate correctly. Assembling the ...

  • Page 12

    Www.U-lineservice.Com 12 02/2005 ™ clrco2075 — clear ice maker/refrigerator checking door alignment the unit’s door is aligned at the factory before shipment. However, its alignment could have been disturbed during shipment or during door panel installation. Important properly aligned, the door shou...

  • Page 13

    02/2005 13 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator caution plumbing installation must observe all state and local codes. All water and drain connections must be made by a licensed/qualified plumbing contractor. Failure to follow recommendations and instructions may result in...

  • Page 14

    Www.U-lineservice.Com 14 02/2005 ™ clrco2075 — clear ice maker/refrigerator important before installing your u-line clrco2075 with factory- installed u-line p60 pump, it is extremely important to check and test all hose connections at the drain pump. There is a possibility that hose connections may ...

  • Page 15

    02/2005 15 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator 5. Place a suitable container beneath the pump’s discharge tube. (the bucket must be able to hold a minimum of one gallon.) 6. Plug the ice maker power cord into a properly grounded, polarized electrical outlet. 7. Verify pu...

  • Page 16

    Www.U-lineservice.Com 16 02/2005 ™ clrco2075 — clear ice maker/refrigerator 3. Carefully bend the water supply line into position and connect the line to the solenoid valve (see figure 39). Avoid kinking the water supply line. Important normal operation creates some vibration. A water supply line co...

  • Page 17

    02/2005 17 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator leveling information important it is extremely important that the unit is level. If it is not level, the ice mold will not fill evenly. A unit that is not level can cause a reduction in ice rate, uneven sized cubes or water ...

  • Page 18

    Www.U-lineservice.Com 18 02/2005 ™ clrco2075 — clear ice maker/refrigerator installation of the clrco2075 1. Open the water supply valve in the main water source. 2. Make sure the cycle selector switch is in the off (middle) position (see figure 46). Note: if the cycle selector switch is in the on o...

  • Page 19

    02/2005 19 www.U-lineservice.Com ™ clrco2075 — clear ice maker/refrigerator initial start-up once installation and leveling is complete, the unit is ready for initial start-up and operation. The cycle selector switch is located in the front grille (see figure 46). 1. Open the door and remove the cov...

  • Page 20

    Www.U-lineservice.Com 20 02/2005 ™ clrco2075 — clear ice maker/refrigerator start-up troubleshooting problem q: unit does not appear to turn on when switch is set to on. Solution a: remember that the compressor will not operate until the water has been filling for about 3 minutes. Make sure unit is ...

  • Page 21

    ™ ©2005 u-line corporation publication no. 30052e 02/2005 rev. A u-line corporation, located in milwaukee, wi, is a family operated manufacturer of built-in undercounter icemakers, combo ® icemaker/refrigerators, wine captain ® wine storage units, refrigerators, refrigerated drawers and refrigerator...