1. DL manuals
  2. Vanox
  3. Indoor Fireplace
  4. LYRA VZB28BN
  5. Operation Instructions Manual

Vanox LYRA VZB28BN Operation Instructions Manual - Table of Contents

Manual is about: (and VRI28BN insert)

Summary of LYRA VZB28BN

  • Page 1

    Danger read and understand this manual. Improper installa- tion, adjustments, alterations, service or maintenance can cause serious injury, property damage or even death. For assistance or additional information consult a qualified installer, service agency or gas supplier. Notice installer: leave t...

  • Page 2: Introduction

    Introduction & operation instruction lyra vzb28bn (et vri28bn inserer) degagement zero bv chemi- nee au gaz vanox fireplace inc. Www.Vanoxfireplace.Com danger lire et comprendre ce manuel. Une mauvaise installa- tion, des ajustements, des modifications, de service ou d'entretien peuvent causer des b...

  • Page 3: Table of Contents

    Part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 3 table of contents notice you must read and understand this manual prior to installation, operation or troubleshooting this appliance. Please retain this owner’s manual for future reference and maintenance, avis vous dev...

  • Page 4: Safety Alert Key

    Safety alert key caution indicates a hazardous situation which, if not avoided, will result in minor or moderate injury. Attention indique une situation dangereuse qui, si elle n'est pas évitée, entraînera la mort ou des blessures ou des dommages matériels graves. Danger indicates a hazardous situat...

  • Page 5: Introduction

    Introduction thank you for choosing a vanox vzb28bn fireplace about the vzb28bn / vri28bn fireplace the vzb28bn includes a 18,000 btu linear burner. The vzb28bn is certified in canada and usa as a vented gas fireplace (ansi z21.50 -2016 / csa 2.22 -2016) and is avail- able in two versions. • vzb28bn...

  • Page 6

    Notice installation and repairs should be done by an authorized fireplace service technician. The appliance should be inspected before use and at least annualy by a preofes- sional. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. It is imperative t...

  • Page 7: Section 1:

    Installing overview and product dimensions please review the installation checklist on page 4 for gen- eral information on preparing for a successful installation of your fireplace. The vzb28bn fireplace may be installed in any location that maintains proper clearances to air condi- tioning ducts, e...

  • Page 8

    Installing the fireplace the fireplace dimensions are shown below: figure 3. Fireplace dimensions (vzb28bn). Figure 4. Fireplace corner dimensions (vzb28bn). Clearances these clearances apply to all dimensions except the framed opening, where the clearance to combustibles are listed on page 6, secti...

  • Page 9: Section 3:

    The vzb28bn is certified for use with standard 4” -5 “and 6” inch b-vent, and requires no b-vent appliance connector. Simply attach the b-vent to the fireplace 5” flue collar, and secure it using 1/4” sheet metal screws. Refer to the current can/cga b-149.1 or ansi z223.1 / nfpa54, gas installation ...

  • Page 10

    Installation of vzb28bn and vri28bn with vanox pv1500 powervent. Figure 7. Pv1500 installation schematic note: for installation with 4” flex in combustible con- struction (wood stud construction) and isulated jacket must be used upstream and downstream of the power- venter. Figure 8. Power vent syst...

  • Page 11: Section 4:

    9” 8” 7” 6” 20” 18” 12” 6” mantels & surrounds note: national canadian gas association mantel test requirements are for fire hazard prevention to combustible materials. New technology, to meet consumer and government demands for the wise use of energy, has prompted us to manufacture many models of f...

  • Page 12: Section 5:

    Gas control and pilot wiring sit millivolt valve, 820.618, with on/off. Section 5: wiring figure 16. Sit millivolt valve, vbn28bn fireplace. Blue wire to valve coil pilot hood thermopile safety spill switch black wire black wire on-off thermopile blue wire con- nected to valve warning combustible ob...

  • Page 13

    Gas control and pilot wiring: ipi system spare parts vzb28bn / vri28bn spill switch figure 17. Ipi electronic gas valve, vzb28bn / vri28bn fireplace. Warning electrical grounding instructions. This appliance is equipped with a three-pronged (grounding) plug for your protection against shock hazzard ...

  • Page 14

    Figure 18. Vzb28bn spill switch. Spill switch wiring: spill switch wiring: sit820 valve. Connect the limit switch in series, between the tpth sit valve terminal, and the blue wire to the valve coil figure 19. Vzb28bn & vri28bn spill switch. 5.5 spill switch vri28bn existing montigo 28 series firepla...

  • Page 15: Section 6:

    Section 6: removing the door figure 21. Removal of door. Removing the door & safety screen: steps to remove the door and replace. 1). Remove front cover on v2b28bn (only) by lifting up and out. 2). Unscrew the upper screen trim to unlock the screen. 3). Unscrew the bottom glass door and then remove....

  • Page 16

    4.) remove bottom door rail. 5.) remove logs and buner assembly. 6.) remove the heat deflector by removing the 3 (three) bolts / nuts. 7.) remove the rear baffle. For models ep28 -2 /4/5, once you remove the burner tray the inner shell has a 1/2” lip all around to support the new- lyra vri28bn. For ...

  • Page 17

    2.) install the limit switch as per detail from page 14. 3.) install the fan support and the fan as per detail from page 25. 4.) install the fan powerline prior to the installation of the lyra vr128bn as per. Can/cga 22231/nfpa codes. 5.) install the insert following these steps. A. Remove the scree...

  • Page 18: Section 7:

    Gasline installation: this gas appliance should be installed by a qualified installer in accordance with local building codes and with current can/cga - b149.1 or .2 installation codes for gas burning appliances and equipment in canada. Installations in the usa must conform to the local codes or in ...

  • Page 19: Section 8:

    Section 8: operation: lighting instructions sit millivolt valve: for your safety -r ead before lighting: warning: if you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lit ...

  • Page 20

    Part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 20 sit millivolts valve:.

  • Page 21

    Sit ipi valve: part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 21.

  • Page 22

    Part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 22.

  • Page 23: Section 9:

    Installation and servicing: the vzb28bn and vri28bn gas fireplace is factory equipped with a 120vac, 60hz. Circulating blower. The circulating fan has been designed to increase the ef- ficiency of convection heat by providing a very quiet air flow over the combustion chamber of the fireplace and dis...

  • Page 24

    Figure 34. Wiring the fan and fan speed control. 115 vac hz rel fan motor wht gnd blk fsc fan speed control blkb lk blk quick connectors quick connector strain relief 120f fan thermo disc crimped bell connector figure 35. Fan wiring schematic. Gnd fsc fan switch hn fan 115vac 60hz glass media placem...

  • Page 25: Operation

    Lighting instructions: see page 19 - 20 & 21 - 22. Burner adjustment: the vzb28bn and vri28bn gas fireplace is a fixed flame height, no adjustment is neccessary. Air shutter adjustment: the burner aeration is factory set for glass but i may re- quire adjusting due to local gas supply, high altitude ...

  • Page 26: Maintenance

    Gas control valve: maintenance figure 40. Sit nova 820 gas valve. Pilot burner adjustment: 1. Locate pilot adjustment screw. (see figure 19.) 2. Adjust pilot screw to provide properly sized flame as shown in figure 19). 3. After installing or servicing, leak test with a soap solution with main burne...

  • Page 27

    Part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 27 the warranty the companies warrants the vanox gas appliance to be free from defects in materials and workmanship at the time of manufacture. On the vanox fireplace,there is a ten-year warranty on the firebox and its co...

  • Page 28

    Part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 28 ma code - co detector (for the state of massachusetts only) 5.08: modifications to nfpa-54, chapter 10 (2) revise 10.8.3 by adding the following additional requirements: (a) for all side wall horizontally vented gas fu...

  • Page 29: Notes

    Notes part. No. Vzb28bn-man-101817-a vzb28bn gas fireplace vanox fireplace inc. Page 29 1. The referenced “special venting system” instructions shall be included with the appliance or equipment installation instruc- tions; and 2. The “special venting systems” shall be product approved by the board, ...

  • Page 30

    Vanox fireplaces inc. Port coquitlam bc vanox fireplace inc. P r i n t e d i n c a n a d a.