Page 1 of 14 1. Appliance data – switchcraft & sensor remote models. Carmelo 1150 inset fire model numbers: nhwv00rn (ng) & nhwv00rp (lpg) installation, user and servicing instructions this appliance meets the requirements of the european gas directive model no. Nhwv00rn for use with natural gas (g2...
Page 2 of 14 installation & service record please ensure that installer completes the installation record below installation record appliance supplied by: ………………………….... Installation date: ……………serial no.: ….……... Installed by: …………..…...Corgi no.: …..…… signed by installer: ………………………..… record of 1...
Page 3 of 14 contents page no. Installation & service record 2 list of components 4 appliance data 4 g eneral i nstallation r equirements 4 fitting the appliance 4 fitting the firebox 7 filling the burner 9 placing of decorative refractory shapes 9 c ommissioning 9 check for spillage 9 briefing the ...
Page 4 of 14 before fitting this appliance, ensure that the following components are enclosed a) upper & lower firebox complete with burner and controls. B) installation, servicing & users instructions c) 1 packet of burner fill granules d) roll of sealing tape e) 1 handset control unit, 1 power sup...
Page 5 of 14 which are large enough or can be altered to accept this appliance. The fireplace should be made from or lined with non-combustible material. The appliance dimensions are shown in figure 1. If the fireplace has to be altered a lintel may be required to support the masonry over the openin...
Page 6 of 14 this appliance may be connected to an ‘exhausto’ power flue system where no suitable chimney is available. Details may obtained from exhausto ltd., unit 3, lancaster court, coronation road, cressex business park, high wycombe, hp12 3td tel; 01494 465166. The ‘post purge’ option must be ...
Page 7 of 14 plate and then the plate can be fixed in place with the four self tapping screws supplied. Fitting the firebox 1 check that the fireplace is of the correct size or has been modified to accept the selected firebox. (see figure 1). 2 it is recommended that, before proceeding further, a si...
Page 8 of 14 into the rear and bottom of the lower firebox. 7 slide the firebox into the opening. If a decorative infill panel is going to be used and is not yet in place make sure that the firebox flange clears the front face of the fire opening by the thickness of the infill panel. Ensure that the...
Page 9 of 14 filling the burner warning this product uses fuel effect pieces containing refractory ceramic fibre (rcf), which are man-made vitreous silicate fibres along with fibrous glass and mineral wool. Excessive exposure to these materials may cause temporary irritation to eyes, skin and respir...
Page 10 of 14 briefing the user 1 demonstrate the full operation of the appliance to the customer, referring them specifically to the ceramic granules, any decorative ceramic shapes and the removal of soot as described in these instructions. 2 inform the customer that all cleaning procedures should ...
Page 11 of 14 operation of the fire 1 it should be noted that your fire is fitted with a flame supervision device, which cuts off the gas supply to your fire if, for any reason the pilot light is extinguished. It also monitors constantly the oxygen in the room. The pilot flame heats the thermocouple...
Page 12 of 14 4 adjusting the flame height to lower the flame height press and hold the down button until the flame is at the desired height. To turn the main burner off and just leave the pilot burner alight continue to press and hold the down button until the main burner does out. To re- light the...
Page 13 of 14 s ervice and m aintenance warning this product may use fuel effect pieces containing refractory ceramic fibre (rcf). This material contains man-made vitreous silicate fibres along with fibrous glass and mineral wool. Excessive exposure to these materials may cause temporary irritation ...
Page 14 of 14 spare parts list in the event of a part requiring replacement the parts list is as follows part description part number electronic control & remote handset g6r-pisoa5a0s5 motorised control valve gv60m1c5a0d5k10l oxypilot (ng models) seagas p4-61 oxypilot (lpg models) seagas p4-58 b-112...
