Water heater unit upgrading auxiliary heater thermo top v installation instructions e1 00 0018 warning! Hazard warning: incorrect installation or repair of webasto heating systems may cause a fire or result in the emission of carbon monoxide, which can be fatal. Serious or fatal injuries can be caus...
2 vw passat validity vehicle and engine types, equipment variants and national specifications not listed in these installation instructions have not been tested. However, installation according to these installation instructions may be possible. The installation location of a digital timer and summe...
3 vw passat heater unit/installation kit also required: and/or other required tools: attention no heater control is included in the delivery scope. The desired heater control must be ordered separately. Foreword these installation instructions apply to vw passat diesel vehicles with an auxiliary hea...
4 4 special features are highlighted using the following symbols: mechanical work electrical system the arrow in the vehicle icon indicates the position on the vehicle and the viewing angle. Vw passat specific risk of injury or fatal accidents. Specific risk of damage to components. Specific risk of...
5 vw passat heater unit installation location 1 heater unit installation location 1 1 preliminary work warning! - disconnect the battery "earth" or "ground" connection. - completely remove the battery. - remove the battery carrier. - copy the factory number from the original type label to the duplic...
6 vw passat electrical connections wiring harness pass through 1 protective rubber plug wiring routing wiring harness installation diagram ground connection 1 original vehicle bolt 2 ground wire digital timer 1 digital timer 2 1 3 + - i 4 1 2 5 1.
7 vw passat climatic fan controller produce connections as shown in wiring diagram. Position of free sockets dependent on equipment variant. 1 relay k3 installing k3 relay produce connections as shown in wiring diagram. 2 red/black (rt/sw) wire from fuse slot 41 6 red/black (rt/sw) wire to a/c contr...
8 vw passat climatic wiring diagram webasto components vw passat components colors and symbols legend hg tt-v heater unit sc41 40 a fan fuse rt red x1 6-pin connector kb control unit for air conditioning - j301 ws white f1 1 a fuse wg resistor group - n24 sw black f2 fuse 40a gm fan motor - v2 br br...
9 vw passat climatronic fan controller produce connections as shown in wiring diagram. 1 relay ipcu 2 k3 relay installing ipcu module, k3 relay integrating on fuse holder. Produce connections as shown in wiring diagram. 1 fuse holder 2 mount red/black (rt/sw) wire in socket 35 or free socket (termin...
10 vw passat 2 remove sealing plug (chamber 2) 1 yellow (ge) wire 3 8-pin connector to heater unit control of heater unit clima- tronic wiring diagram webasto components vw passat components colors and symbols legend hg tt-v heater unit sc56 fuse 40a rt red x1 6-pin connector kb climatronic control ...
11 vw passat remote option (telestart) route antenna cable to duct behind relay carrier. 1 antenna on windshield installing antenna position bracket of receiver 2 over fuse holder and fasten with original vehicle bolt 3 . 1 receiver installing receiver 1 receiver of radio remote control position- in...
12 vw passat to establish communication to heater control unit, an unassigned serial or usb port must be used. 1 dongle 2 laptop 3,5 diagnosis adapter (serial version shown) 4 plug adapter installing software 1 connector of wiring harness of digital timer 2 plug adapter con- necting connector read r...
Vw passat webasto ag postfach 80 - 82132 stockdorf, germany - hotline +49- (0)1805-932278 hotfax +49-(0)395-5592-353 - http://www.Webasto.De feel the drive final work warning! Apply the warranty sticker in an easily visible location on the relay carrier bracket. Reassemble the disassembled component...
14 14 vw passat operating instructions for end customer please remove page and add to the vehicle operating instructions. To ensure proper operation of the additional heater, the fuel level in the tank must be above the "reserve" level. The sensitivity of the passenger compartment monitoring has bee...
