Weber Summit 450 Step-by-step Manual - Install Condiment

Other manuals for Summit 450: Operating Manual, Step-by-step Manual, Operating Manual, Step-by-step Manual, Operating Manual, Instructions Manual

Manual is about: LP Gas Barbecues

Page of 21

Download

Print this page

Bookmark us

INSTALL CONDIMENT

HOLDERS AND WORK

SURFACES

Figure 11

You will need: two condiment holders, two stainless steel

work surfaces, and four wing nuts.

Place the condiment holders on the left and right side of

the frame. Figure 11(a). Set the work surfaces over the

condiment holders on both sides of the barbecue. The

studs of the work surface go through the holes in the

top of the condiment holder and through the frame rail.

Thread on the wing nuts on the front and back and

tighten. Figure 11(b).

Studs

underneath

work surfaces

FILL LIQUID PROPANE

CYLINDER

Note - The liquid propane cylinder manufacturer is

responsible for the materials, workmanship and

performance of the cylinder. If the cylinder has a defect,

malfunctions, or you have a question regarding the

cylinder, call the cylinder manufacturer’s customer service

center. The phone number is on the warning decal, which

is permanently attached to the cylinder. If the cylinder

manufacturer has not resolved the issue to your

satisfaction, then contact the Customer Service

Representative in your region using the contact

information sheet provided with your manual.

To fill, take the liquid propane cylinder and filler adapter to

an RV center or look up gas-propane in the phone book

for other sources of liquid propane gas.

WARNING: We recommend that your liquid propane

cylinder be filled at an authorized liquid propane gas

dealer by a qualified attendant, who fills the tank by

weight.

IMPROPER FILLING IS DANGEROUS.

Tell your liquid propane dealer that this is a new liquid

propane cylinder. The air must be removed from a new

liquid propane cylinder before the initial filling. Your liquid

propane cylinder dealer is equipped to do this.

The liquid propane cylinder must be installed, transported

and stored in an upright position, and should not be

dropped or handled roughly.

Never store or transport the liquid propane cylinder where

temperatures can reach 125° Fahrenheit (too hot to hold

by hand – for example: do not leave the liquid propane

cylinder in a car on a hot day).

For full instructions on safe handling of liquid propane

cylinders, see Section “Operating”.

CHECKING THE FUEL

LEVEL IN YOUR TANK

Check the fuel level by viewing the color indicator

level line on the side of the tank scale.

Empty

Medium

Full

(1)

(2)

(3)

« ‹ Prev 6 7 8 9 10 11 12 Next › »

Summary of Summit 450

Page 1
Summit tm 450 & 650 lp gas barbecues step-by-step guide 72627 10/25/00 w e b e r w e b e r w e b e r w e b e r danger if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid 4. If odor continues, keep away from the appliance and immediately call your gas suppli...
Page 2: Continue to Remove
“u” rails (2) continue to remove packaged contents 2 tools needed supplies needed 7/16 inch open end or an adjustable wrench you will need a soap and water solution to check for gas leaks. (see step "check for gas leaks.") note - the hardware size of nuts, bolts and screws is given. For example "1/4...
Page 3: Remove Packaged
3 remove packaged contents (continued) cylinder hanger stainless steel work surface (2) condiment holder (2) tool holder (4) bottom shelf warm-up basket 1/4-20 wing nuts (4) thermometer.
Page 4: Install “U” Rails
4 a) b) install “u” rails figure 1 “u” rail support mounts tabs frame rails “u” rail supports note: lock the casters before starting assembly. You will need: two “u” rails, eight 1/4-20 x 1/2 inch bolts, eight nylon washers, and a 7/16 inch or adjustable wrench. Insert the tabs of the “u” rail into ...
Page 5: Install Steam-N-Chips
5 install steam-n-chips smoker you will need: smoker box. Remove the center flavorizer bar (the one that is not over a burner). Set the handles of the steam-n-chips smoker on the flavorizer bar holder. Note: for directions on how to use the steam-n-chips smoker, see the operating guide. Install flav...
Page 6: Add Cooking Grates
6 add cooking grates you will need: (1) cooking grate and (1) hinged cooking grate . The cross-rail of the cooking grate goes down. Set the cooking grates in place next to each other. Warning: use heat-resistant barbecue mitts or gloves when adding wood to the steam-n-chips smoker. Use a barbecue to...
Page 7: Install Warm-Up
7 install warm-up basket you will need: warm-up basket. Install one end of the warm-up basket into the hole on the right end of the lid and the other end into the slot in the left end of the lid. Summit 450 summit 650 install bottom tray you will need: bottom tray, catch pan holder, catch pan, and o...
Page 8: Install Bottom Shelf
8 install bottom shelf place the bottomshelf under the cart between the frame supports. Lift up one end of the shelf so it clears the crosspiece. Continue to lift until the opposite end clears the opposite crosspiece. Set the shelf in place on both crosspieces. 8 slide the bottom tray into the mount...
Page 9: Install Condiment
9 install condiment holders and work surfaces figure 11 you will need: two condiment holders, two stainless steel work surfaces, and four wing nuts. Place the condiment holders on the left and right side of the frame. Figure 11(a). Set the work surfaces over the condiment holders on both sides of th...
Page 10: Important Lp
10 important lp cylinder information failure to follow these danger statements exactly may result in a fire causing death or serious injury. Danger never store a spare lp cylinder under or near this barbecue. Never fill the tank beyond 80% full. Your weber gas grill is equipped with a cylinder suppl...
Page 11: Safe Handling Tips
11 safe handling tips for liquid propane gas cylinders • liquid propane (lp) gas is a petroleum product as are gasoline and natural gas. Lp gas is a gas at regular temperatures and pressures. Under moderate pressure, inside a cylinder, lp gas is a liquid. As the pressure is released, the liquid read...
Page 12: Check For Gas Leaks
12 check for gas leaks remove burner control knobs, control panel(1) and front panel(2) remove the burner control knobs. The control panel(1) is separate from the front panel(2). The control panel needs to be removed before the front panel can be removed. Front edge of the control panel put your fin...
Page 13: Check For Gas Leaks
13 pull the front panel(1) up and out of the cooking box assembly. Summit 450 summit 650 danger do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. This will result in a fire or explosion which can cause serious bodily in...
Page 14
14 14 manifold a) b) c) manifold figure 19 check for leaks by wetting the connections with the soap and water solution and watching for bubbles. If bubbles form or if a bubble grows there is a leak. Warning: do not ignite burners while checking for leaks. Check: a) left valves to manifold connection...
Page 15: Reinstall Front
15 figure 20 (b) (a) a) hose to regulator connection. Figure 20 (a). B) regulator to tank connection. Figure 20 (b). Warning: if there is a leak at connections 19 (a), 19 (b), 20 (a), or 20 (b) turn off the gas. Do not operate the barbecue. Contact your dealer. When leak checks are complete, turn ga...
Page 16: Reinstall Control
16 reinstall control panel front panel control panel you will need: control panel. Pull igniter buttons up until they stay in the up position. Place the control panel into the grooves on either side of the front of the cooking box. Push the control panel into place, using even pressure while pushing...
Page 17: Reinstall Burner
17 reinstall burner control knobs you will need: four burner control knobs. Push on the burner control knobs. Summit 450 summit 650 install tool holders you will need: four tool holders. Place the tool holder under the control panel(1) and over the front panel(2). Set the tool holder on top of the f...
Page 18
18 18 summit 450 lp 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 36 35 72 66 67-71 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 39 40 38 37.
Page 19
19 19 19 1 left pivoting endcap 2 shroud assembly 3 stainless steel handle 4 thermometer 5 hinged cooking grate 6 stainless steel work surface (2) 7 condiment holder (2) 8 steam-n-chips smoker 9 flavorizer bar / cooking grate holder (2) 10 igniter (2) 11 manifold mounting clips (2) 12 manifold assem...
Page 20
20 20 20 w eb er w e b e r 1 2 3 4 5 6 7 8 9 10 11 12 13 14-17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 40 38 39 37 41 42 43 44 45 47 46 48 49 50 51 55 56 57 62 60 64-67 58 69 70 71 72 75 76 61 68 63 74 73 52 54 53 59 35 36 33 34 summit 650 lp.
Page 21
21 summit 650 lp w e b e r w e b e r warning: use only weber factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty. 1 left pivoting endcap 2 shroud assembly 3 stainless steel handle 4 cooking grates (2) 5 flavorizer bars(11) ...