1. DL manuals
  2. Yamaha
  3. Recording Equipment
  4. AW2816
  5. Service Manual

Yamaha AW2816 Service Manual

Manual is about: PROFESSIONAL AUDIO WORKSTATION

Summary of AW2816

  • Page 1

    Aw2816 1 service manual pa 011573 1.386k-3012 printed in japan ’01.08 hamamatsu, japan contents dimensions ............................................................ 3 specifications ................................................ 4/8 panel layout .................................. 12 circuit boa...

  • Page 2: Warning

    Aw2816 2 impor tant notice for the united kingdom connecting the plug and co connecting the plug and co connecting the plug and co connecting the plug and co connecting the plug and corrrrrd d d d d important. T h e w i r e s i n t h i s m a i n l e a d a r e c o l o u r e d i n accordance with the ...

  • Page 3: Dimensions

    Aw2816 3 lithium ba tter y handling this product uses a lithium battery for memory back-up. Warning : lithium batteries are dangerous because they can be exploded by improper handling. Observe the following pre- cautions when handling or replacing lithium batteries. Leave lithium battery replacement...

  • Page 4: Specifications

    Aw2816 4 specifications general specifications frequency response 0 +1/-3 db (mic/line in - stereo out) 20 hz~20 khz (nominal input/output level) 20 khz lpf dynamic range 109 db typ. 103 db min. 104 db typ. 98 db min. Da converter (stereo out) da converter (stereo out) ad + da (line in to stereo out...

  • Page 5

    Aw2816 5 mixer section input/output mic/line input channel 1, 2 (balanced, xlr-type, trs phone jack) -3 db (clipping level) 3 k Ω -46 db to +4 db -52 db +22 db +48v dc phantom powering peak led input impedance nominal input level minimum input level maximum input level mic/line input channel 3-8 (ba...

  • Page 6

    Aw2816 6 digital mixer input channel (channel 1-8, playback 1-16) attenuator, phase (normal, reverse), eq (4-band peq), dynamics, delay, on/off, fader (60 mm motorized), pan, bus assign (stereo, bus, aux, solo, direct out) internal effects return attenuator, phase (normal, reverse), eq (4-band peq),...

  • Page 7

    Aw2816 7 controls analog section input (channel 1-8) input (channel 1, 2) output gain (variable) +48v (phantom switch) phones level, monitor out level mixer section work navigate buttons unit buttons mixer buttons fader mode buttons mixing layer buttons on & sel buttons, faders on & sel buttons, enc...

  • Page 8

    Aw2816 8.

  • Page 9

    Aw2816 9.

  • Page 10

    Aw2816 10

  • Page 11

    Aw2816 11.

  • Page 12: Panel Layout

    Aw2816 12 top panel 1 2 3 4 [gain] control [peak] indicators [phones] (headphones) control [monitor out] control analog input/output section 1 2 3 4 [song] key [file] key [cd] key [quick rec] (quick record) key work navigate section unit section 1 2 3 4 [setup] key [utility] key [midi] key [patch] k...

  • Page 13

    Aw2816 13 fader mode section 1 2 3 4 1 2 3 4 [home] key [aux 5]/[aux 6] keys [aux 1]~[aux 4] keys [remote] key mixing layer section 1 2 3 input [1-8] key recorder [1-8] key recorder [9-16] key 1 2 3 fader section 1 2 3 4 5 1 2 3 4 5 [sel] keys (1-8/stereo/rtn 1/rtn 2) [on] keys (1-8/stereo/rtn 1/rtn...

  • Page 14

    Aw2816 14 1 2 3 4 recorder section 1 2 3 4 [track] key [edit] key [undo] key [redo] key 1 2 3 4 1 2 3 4 rec track select section [cue] key [meter] key rec track select [1]–[16]/[st] [all safe] key display section 1 2 3 4 5 6 display [shift] key [f1]-[f5] (function 1-5) keys [ctrl] (control) key cont...

  • Page 15

    Aw2816 15 1 2 [automix] key [scene] key automation section scene memory section 1 2 3 [store] key [ ]/[ ] keys [recall] key 1 2 1 2 3 cursor/jog&shuttle section 1 2 3 4 5 [jog on] key [data/jog] dial [shuttle] dial cursor [ ]/[ ]/[ ]/[ ] keys [enter] key 1 2 3 4 5.

  • Page 16

    Aw2816 16 7 8 9 10 11 12 13 1 2 3 4 5 6 1 2 3 4 5 10 11 12 13 1 4 7 8 9 5 6 2 3 transport section 1 2 3 4 5 rew [ ] (rewind) key ff [ ] (fast-forward) key stop [ ] key play [ ] key rec [ ] (record) key [num locate] key mark search [ ]/[ ] keys [mark] key [auto punch] key last rec [in]/[out] (last re...

  • Page 17

    Aw2816 17 12 13 14 15 16 17 18 19 20 21 1 2 3 4 5 6 7 8 9 10 11 front panel 1 cd-rw drive cover 1 [phantom +48v on/off] switch input 1/2 (xlr) jacks input 1/2 (trs phone) jacks input 3–8 (trs phone) jacks input 8 (hi-z) jack option i/o slot stereo out jacks monitor out jacks omni out jacks phones ja...

  • Page 18: Circuit Board Layout

    Aw2816 18 circuit board layout 〈 bottom view 〉 power supply unit sub-my sub-fader main cn503 cn2 cn3 cn1 cn4 cn504 sub-my cn5 sec a-a a a cn403 cn402.

  • Page 19

    19 aw2816 cn502 cn503 cn101 cn303 cn201 cn401 cn305 cn301 cn601 cn702 cn703 cn307 cn302 cn101 cn306 cn103 cn104 cn102 cn501 cn101 pn sub-inv sub-fader sub-cpu main lcd cn301 cn502 〈 bottom view 〉 〈 bottom view 〉.

  • Page 20: Block Diagram

    Aw2816 20 block diagram 〈 analog section 〉 peak -1 ba ha +48v phantom ha peak -1 ba ha peak -1 ba ba mic/line ch 1,2 mic/line ch 3~7 mic/line ch 8 hi-z dsp section 8ch adc/dac ic 301(28p) ch input 1,2 omni out 1,2 ic 304(28p) ch input 3,4 omni out 3,4 ic 307(28p) ch input 5,6 stereo out l,r ic 310(2...

  • Page 21

    21 aw2816 〈 main cpu section 〉 main cpu ic 501 (112p) main gate array ic 606 (128p) lcd control ic 502 (60p) 256k sram ic 503 (28p) 16m dram ic 505 (42p) 16m flash ic 504 (48p) dsp section real time clock ic 608(24p) recorder cpu ic 703 (112p) dpram ic 711 (52p) mtc out out/thru in to host ic 601 (1...

  • Page 22

    Aw2816 22 〈 dsp section 〉 dsp 6 ic 404 (176p) ( effect ) 16m dram ic 407(42p) 16m dram ic 410(42p) option i/o slot recorder gate array ic 705 (160p) 8ch adc/dac ic 301 ic 304 ic 307 ic 310 dir2 dit2 ic 409 (16p) ic 408 (44p) main cpu ic 501 (112p) dsp section digital stereo in out dsp 7 ic 412 (208p...

  • Page 23

    23 aw2816 〈 recorder cpu section 〉 recorder ic 703 (112p) cpu ic 711 (52p) dpram main ic 501 (112p) cpu ic 706 (48p) 8m flash ic 708 (42p) 16m dram recorder ic705 (160p) gate array 64m sdram ic 701 (54p) 64m sdram ic 702 (54p) ic 719 (100p) scsi control cd-rw scsi 2.5 inch hdd dsp section recording ...

  • Page 24

    Aw2816 24 〈 sub cpu section 〉 sub cpu ic 301 (112p) sub gate array ic 302 (128p) main cpu ic 501 (112p) ic 107 (16p) (9p) vr101-109 ic103-106,ic108-112 to power supply unit multiplexer motor driver (x 9) 60mm motorized faders ( x 9 ) foot sw sw / led matrix data/jog shuttle encoder rtn 1 rtn 2 main ...

  • Page 25: Disassembly Procedure

    25 aw2816 word direction cd-rw cover [720a] [700a] [700a] [700a] [700a] [720b] [770] bottom cover hdd cover connector cover disassembly procedure 1. Bottom cover (time required: about 5 minutes) 1-1 remove the four (4) screws marked [720a] and turn over the hdd cover, and then pull out the hdd cable...

  • Page 26

    Aw2816 26 3. Sub-my circuit board and power supply unit (time required: about 15 minutes each) 3-1 remove the bottom cover. (see procedure 1.) 3-2 remove the five (5) screws marked [700c]. The bottom chassis assembly can then be removed. (fig.3) 3-3 sub-my circuit board: remove the two (2) screws ma...

  • Page 27

    27 aw2816 [700f] [700g] [700g] sub-cpu main [700g] 5. Pn, sub-inv circuit boards and lcd (time required: about 30 minutes each) 5-1 remove the jog knob, the shuttle knob, the two (2) knobs marked [t130] and the knobs marked [410], [420], [440] and [450] from the control panel side. (fig.2) 5-2 remov...

  • Page 28

    Aw2816 28 5-6 remove the four (4) screws marked [700j]. The cd- rw holder can then be removed. (fig.3) 5-7 remove the thirteen (13) screws marked [700k]. The sub chassis can then be removed. (fig.7) 5-8 remove the four (4) screws marked [700l]. The lcd support can then be removed. (fig.8) 5-9 pn cir...

  • Page 29

    29 aw2816 installing an internal hard disk • hard disks are precision devices. Do not subject them to physical shock or static electricity, etc. • do not place a hard disk nearby devices that pro- duce a strong magnetic field, or in locations of extreme cold, heat, or moisture. • before you handle a...

  • Page 30

    Aw2816 30 from the bottom, unfasten the hard disk cover plate to which the internal 2.5 inch ide hard disk will be attached. The screws you remove will be used again to fasten the cover plate, so be careful not to lose them. Turn over the hard disk cover plate. As shown in the illustration, place th...

  • Page 31

    31 aw2816 • even if the connector is difficult to insert, do not attempt to insert it by applying excessive force. Doing so may damage the hard disk, or you may injure yourself. • when inserting the connector, be careful that it is not mis-aligned up/down or left/right. As shown in the illustration ...

  • Page 32: Installing A Cd-Rw Drive

    Aw2816 32 cd-rw drive settings insert the jumper (included with the cd-rw drive) into the jumper switch on the rear panel of the cd- rw drive to set your cd-rw drive to function as a slave unit. The aw2816 will not start up if the cd- rw is set to a mode other than slave. • if you are installing a c...

  • Page 33

    33 aw2816 installation procedure you will need the following items. • the aw2816 itself • internal cd-rw drive (option) • four screws (included with the aw2816) for attaching the cd-rw drive • philips (+) screwdriver • work surface • in order to install the cd-rw drive you will need to turn the aw28...

  • Page 34

    Aw2816 34 turn the cd-rw drive over, and insert it lit- tle by little, stopping when the connector end of the cd-rw drive enters the opening in the bottom of the aw2816. Connect the flat cable ( q ) and cd-rw drive power supply connector ( w ) (from inside the aw2816) to the connectors of the cd-rw ...

  • Page 35

    35 aw2816 align the fastening screw-holes on the bot- tom of the cd-rw drive with the screw- holes in the aw2816, and using a screw- driver and the included screws, fasten it in four locations. Re-attach the cd-rw drive cover and the bottom panel that you removed in step 4. At this time, remove the ...

  • Page 36: Installing I/o Card

    Aw2816 36 installing i/o card make sure that the power of the aw2816 is turned off. For safety’s sake, disconnect the power cable from the ac outlet. Always switch off the power for the main unit and all peripherals, unplug the power cord for the main unit from the outlet, then disconnect the cables...

  • Page 37: Lsi Pin Description

    37 aw2816 lsi pin description s1d13305f00b100 (xq595a00) lcdc (lcd controller) .... 37 hd6437042ag12f (x0592a00) cpu .................................... 38 hd6437042af65f (xw647a00) cpu ................................... 38 yss910-s (xv988a00) dsp6 (digital signal processor) .... 39 yss919-h (xz69...

  • Page 38

    Aw2816 38 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 tioc4/dack0/pe14 pe15 vss a0 a1 a2 a3 a4 a5 a6 a7 a8 a9 a10 a11 a12 a13 a14 a15...

  • Page 39

    39 aw2816 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 8...

  • Page 40

    Aw2816 40 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 8...

  • Page 41

    41 aw2816 ground serial data input ground not used dram address bus ground dram address bus power supply +3.3v not used test pin power supply +3.3v ground cpu address bus ground power supply +5v ground cpu data bus ground cpu data bus power supply +5v cpu data bus ground cpu data bus ground power su...

  • Page 42

    Aw2816 42 fader control ground power supply system data bus ground system data bus power supply system address bus read write chip select reset fader reset power supply ground system clock input key control test pin key control ground led control pin name i/o function no. Pin name i/o function no. L...

  • Page 43

    43 aw2816 system address bus signal ground power supply system data bus ground system data bus power supply mtc out mtc in fl data fl chip select fl clock ground port a power supply ground port a port b ground port x port y clock pin name i/o function no. Pin name i/o function no. Lr38792 (xy630a00)...

  • Page 44

    Aw2816 44 power supply +3.3v port dma data bus ground scsi i/o signal (low active) power supply +5v scsi req signal (low active) ground scsi c/d signal (low active) scsi sel signal (low active) ground scsi msg signal (low active) scsi rst signal (low active) ground scsi ack signal (low active) power...

  • Page 45

    45 aw2816 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 mot n.C n.C ad0 ad1 ad2 ad3 ad4 ad5 ad6 ad7 gnd i i/o i/o i/o i/o i/o i/o i/o i/o bus type selection multiplexed address / data bus ground 13 14 15 16 17 18 19 20 21 22 23 24 /cs as r//w n.C ds /reset /irq n.C n...

  • Page 46

    Aw2816 46 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 daux hdlt dout vfl opt sync mcc wc mcb mca sksy xi xo p256 lockn vss tst2 dim1 dim0 dom1 dom0 km1 i o o o o o o o o o i i o o o o i i i i i auxiliary input for audio data asynchrono...

  • Page 47: Ic Block Diagram

    47 aw2816 ic block diagram hd74hc02fpel (xl091a00) sn74hc02nsr (xw791a00) quad 2 input nor main: ic421 1 2 3 1y 1b 4 2y 5 2a 6 2b 7 vss 1a 14 13 12 vdd 4a 11 4b 10 3y 9 3a 8 3b 4y tc74vhc04ft (x0195a00) 74vhc04mtcx (x0292a00) tc74hct04af-t1 (xi297a00) hd74ls06fpel (xh610a00) hex inverter main: ic515...

  • Page 48

    Aw2816 48 tc74vhct245aft (xt744a00) tc74vhc245ft (xu797a00) tc74hc245af (xs720a00) mm74hc245asjx (xw107a00) octal 3-state bus transceiver main: ic401, 402, 506, 509-512, 607, 709, 710, 712, 716-718 1 2 3 4 5 6 7 20 19 18 17 16 15 14 vcc g b1 b2 b3 b4 b5 b6 b7 b8 8 9 10 12 11 gnd a8 a7 a6 a5 a4 a3 a2...

  • Page 49

    49 aw2816 mc26ls30d (xl334a00) line driver main: ic602 njm2904m (xv190a00) dual operational amplifier main: ic420 1 2 3 4 5 6 7 vcc input a input b/ enable ab gnd input c/ enable cd input d v ee mode 16 15 14 13 12 11 sr-a output a output b sr-b sr-c output c output d 8 9 10 sr-d input a enable ab s...

  • Page 50: Circuit Boards

    Aw2816 50 to main-cn504 to main-cn503 option i/o slot component side pattern side sub-my circuit board 3na-v748650-2 2 note: see parts list for details of circuit board component parts. Sub-my circuit board (xz717b0) ................................................ 50 sub-inv circuit board (xz717b0)...

  • Page 51

    51 aw2816 to main -cn502 hdd green to lcd to lcd sub-inv circuit board component side pattern side 3na-v748650-2 2.

  • Page 52

    Aw2816 52 a a' phantom +48v on/off cn503: to sub-my-cn402 cn504: to sub-my-cn403 not installed to sub-cpu-cn201 to sub-inv-cn503 to power supply unit-cn2 bal bal 3 4 5 6 7 b 1 bal bal 2 bal mic/line input main circuit board 3na-v748630-2 3.

  • Page 53

    53 aw2816 a a' 1 to sub-cpu-cn303 to cd-rw drive to 2.5" hdd drive to power supply unit-cn3 bal hi-z phones scsi to host in out digital stereo 8 ic with internal lithium battery (ds12887)real time clock part no.Xv618a00 main circuit board ic608 component side 3na-v748630-2 3.

  • Page 54

    Aw2816 54 main circuit board 3na-v748630-3 2 b b' 8 phones monitor out.

  • Page 55

    55 aw2816 pattern side b b' 1 2 3 4 5 6 7 8 mic/line input 3na-v748630-3 2.

  • Page 56

    Aw2816 56 pn circuit board c c' to sub-cpu -cn301 work navigate unit cd play ch view pan/ routing eq/att/ grp recorder 1-8 recorder 9-16 input 1-8 sel1/9 on1/9 on2/10 on3/11 on4/12 on5/13 on6/14 on7/15 on8/16 on stereo sel2/10 sel3/11 sel5/13 sel6/14 sel7/15 sel8/16 sel stereo sel4/12 dyn/ dly mixer...

  • Page 57

    57 aw2816 c c' to sub-cpu -cn305 to sub-cpu -cn301 data/jog/shuttle 7/mark search 5/last rec out 9/mark 4/last rec in 2/b 6/set 3/roll back -/+/ 0/rtz 1/a 8/mark search > on stereo sel stereo rec track select recorder scene memory automation cursor reset component side 3na-v748640-2 4.

  • Page 58

    Aw2816 58 to sub-fader-cn102 to main-cn301 to sub-fader-cn104 to sub-fader-cn103 l stereo out unbal(-10dbv) monitor out bal(+4db) omni out unbal(0db) r l 1 2 3 4 r d d' e e' sub-cpu circuit board 3na-v748650-2 2.

  • Page 59

    59 aw2816 to main-cn601 to pn-cn102 to pn-cn101 4 foot sw in out/thru mtc out midi d d' e e' 3na-v748650-2 2 component side pattern side.

  • Page 60

    Aw2816 60 sub-fader circuit board to power supply unit -cn4 to sub-cpu-cn307 to sub-cpu-cn302 to sub-cpu-cn306 1 2 3 4 5 6 7 8 stereo fader 3na-v748650-2 2 component side.

  • Page 61

    61 aw2816 pattern side 3na-v748650-2 2.

  • Page 62: Test Program

    Aw2816 62 test program 1. Getting ready 1-1 rear panel (1) insert the slot check card (tx800810) into an optional i/o slot. (2) connect an external hard disk drive unit to the scsi connector (50-pin half-pitch connector). *1 the capacity of the external hard disk drive must be at least 4gb, and the ...

  • Page 63

    Aw2816 63 3-4 canceling a test (1) you can cancel a test that is currently running by pressing the cancel key. * the operation method for canceling (exit) the currently executed test is displayed at the bottom left of the screen. (example) exit: [solo] + [cancel] 3-5 displaying the test results === ...

  • Page 64

    Aw2816 64 • 2: cpu interface (data bus) ...Ng (“0” is displayed for the bits whose write and read values match.) • 3: cpu interface (chip select, txb) ...Ng ic404 cs error • 4: cpu interface (address bus) ...Ng (“0” is displayed for the bits whose write and read values match.) • 5: cpu interface (bu...

  • Page 65

    Aw2816 65 4-8 jog/shuttle function test (08 jog/shuttle) “=== jog/shuttle ===” is displayed on the lcd. (1) test content 1) checks jog/shuttle functions. 2) the illustration of the jogs/shuttles to be tested and operation instructions will appear, so carry out the test in accordance with the instruc...

  • Page 66

    Aw2816 66 2) if the following ng messages appear: • fs clock check ng 256fs → connection problem with 256fsmy, wcmy 128fs → connection problem with 128fsmy, wcmy 64fs → connection problem with 64fsmy, wcmy sync → connection problem with syncmy, wcmy fs → connection problem with fsmy, wcmy • bus chec...

  • Page 67

    Aw2816 67 (2) judgment 1) if all the test results are “ok” press the enter key. The test menu will reappear with displayed to the left of the test item (to host), and the cursor advances to the next test in the menu. 2) if the following ng messages appear: • main tx/rx → signal error with tx1 (pin 1...

  • Page 68

    Aw2816 68 4-15 digital i/o function test (16 digital i/o) “=== digital i/o ===” is displayed on the lcd. (1) test content 1) checks whether the digital i/o (spdif format) signal can be sent and received correctly. 2) checks the digital audio signals. (2) judgment 1) if all the test results are “ok” ...

  • Page 69

    Aw2816 69 5. Miscellaneous (1) some switches have no led, and they are indicated by a gray square in the illustration below. These switches will not light up during the led test (test 2 in the test menu). However, do not make judgment that they are defective. (2) the fader aging test (test 30 in the...

  • Page 70

    Aw2816 70

  • Page 71

    Aw2816 71.

  • Page 72

    Aw2816 72.

  • Page 73

    Aw2816 73.

  • Page 74

    Aw2816 74.

  • Page 75

    Aw2816 75.

  • Page 76

    Aw2816 76.

  • Page 77

    Aw2816 77.

  • Page 78: Display Message List

    Aw2816 78 display message list messages automix disabled. Automix is not enabled, and cannot be recorded. Automix memory full! Automix memory has no free area. Automix not running. Automix has been stopped, so recording is not possible. Pause the recorder, and then playback. Automix rec aborted. Aut...

  • Page 79

    79 aw2816 make new mix. There are no events to be edited. Please create a new mix. Mark erased the mark has been erased. Mark set the mark has been set. Memory full!! The song has no more free space. One song can use a maximum of 6.4 gb. Midi bulk received a bulk data dump was received. Midi in: dat...

  • Page 80

    Aw2816 80 popup messages this song is protected. This song is protected, and cannot be edited or recorded. To host: data framing error! Invalid data may have been received at the to host connector. To host: data overrun! Invalid data may have been received at the to host connector. To host: data par...

  • Page 81

    81 aw2816 messages at power-on no song to backup! There is no song to backup. No song to edit! There is no song has been selected for editing. No song to load! There is no song to load. No song to restore! There is no song to restore. No song to save! There is no song to save. No song to write! No s...

  • Page 82

    Aw2816 82.

  • Page 83

    83 aw2816.

  • Page 84

    Aw2816 84.

  • Page 85

    85 aw2816.

  • Page 86

    Aw2816 86 yamaha [professional audio workstation] date: mar 29, 2001 model: aw2816 midi implementation chart version: 1.0 function... Transmitted recognized remarks basic channel default changed 1–16 1–16 1–16 1–16 memorized memorized mode default messages altered x x ************** omni off/omni on...

  • Page 87: Parts List

    Parts list contents overall assembly .............................................. 2 bottom chassis assembly ...... 5 electrical parts ............................................. 6 warning components having special characteristics are marked and must be replaced with parts having specification eq...

  • Page 88: Overall Assembly

    Aw2816 2 overall assembly 380 410 t130 450 440 280 t10 top cover assembly t70 t80 t40 t50 t30 t90 700 700 700 250 240 300 50a 50b 50 290 30d 420 30c 740 310 330 320 660 720 710 720 700 700 30a 120 130 590 720 700 580 770 810 610 600 720 300b 300a 140 110 70 10 700 400 700 670 260 t20 700 730 620 340...

  • Page 89

    Aw2816 3 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * * * * overall assembly aw2816 overall assembly j (v748600) overall assembly u,c,v (v748610) overall assembly h,b,w (v748620) 10 circuit board main 30 circuit board sub (v748650) 30...

  • Page 90

    Aw2816 4 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * ac cord csa u,c,v 07 ac cord vde h,w 08 ac cord bs 3p b 10 top panel assembly (v801530) t10 top cover assembly t10a top cover (v674360) t10b cover, fader t10c lens c36 peak 1-8 8 t10d es...

  • Page 91: Bottom Chassis Assembly

    Aw2816 5 bottom chassis assembly : new parts ref no. Part no. Description remarks qty rank rank: japan only bottom chassis assembly aw2816 (v674350) 10 bottom chassis 20 support, my 04 30 shield, ac c36 40 escutcheon, power switch 03 50 fan motor dc f412r-12llb 08 60 bind head tapping screw-s 3.0x6 ...

  • Page 92: Electrical Parts

    Aw2816 6 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * electrical parts electrical parts aw2816 circuit board main (xz715b0) circuit board pn (xz716b0) circuit board sub-cpu (v748650)(xz717b0) circuit board sub-fader (v748650)(xz717b0) circuit board sub-inv...

  • Page 93

    Aw2816 7 : new parts ref no. Part no. Description remarks qty rank rank: japan only c162 electrolytic cap. (chip) 4.7 50v 01 c163 monolithic ceramic cap. F 0.100 25v z 01 c164 monolithic ceramic cap. B 0.047 25v k 01 c165 monolithic ceramic cap. Sl 10p 50v d 01 c166 monolithic ceramic cap. B 220p 50...

  • Page 94

    Aw2816 8 : new parts ref no. Part no. Description remarks qty rank rank: japan only c238 monolithic ceramic cap. B 220p 50v k 01 c239 electrolytic cap. (chip) 4.7 50v 01 c240 monolithic ceramic cap. F 0.100 25v z 01 c241 monolithic ceramic cap. B 0.047 25v k 01 c242 monolithic ceramic cap. Sl 10p 50...

  • Page 95

    Aw2816 9 : new parts ref no. Part no. Description remarks qty rank rank: japan only c316 electrolytic cap. (chip) 10 16v 01 -319 electrolytic cap. (chip) 10 16v 01 c320 monolithic ceramic cap. B 470p 50v k 01 c321 mylar capacitor (chip) 0.0033 16v j c322 monolithic ceramic cap. B 470p 50v k 01 c323 ...

  • Page 96

    Aw2816 10 : new parts ref no. Part no. Description remarks qty rank rank: japan only c396 monolithic ceramic cap. Sl 22p 50v j 01 c397 monolithic ceramic cap. B 470p 50v k 01 c398 monolithic ceramic cap. F 0.100 25v z 01 c399 monolithic ceramic cap. F 0.100 25v z 01 c400 mylar capacitor (chip) 0.001...

  • Page 97

    Aw2816 11 : new parts ref no. Part no. Description remarks qty rank rank: japan only -505 monolithic ceramic cap. F 0.100 25v z 01 c506 electrolytic cap. (chip) 100 16v 01 c551 monolithic ceramic cap. F 0.100 25v z 01 c552 monolithic ceramic cap. F 0.100 25v z 01 c553 monolithic ceramic cap. Sl 18p ...

  • Page 98

    Aw2816 12 : new parts ref no. Part no. Description remarks qty rank rank: japan only * cn301 connector base post ph 12p te 01 cn401 connector base post ph 9p te 03 cn502 connector base post ph 12p te 01 cn503 connector, ffc 52045 35p te 01 cn504 connector, ffc 52045 35p te 01 cn601 connector base po...

  • Page 99

    Aw2816 13 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * ic503 ic w24257s-70ll-el10 05 ic504 ic mbm29f160be-70tn flash rom 16m ic505 ic msm5118160d-60jsr1 dram 16m 12 ic505 ic msm5118160f-60j ic505 ic k4f151611d-jl6000 08 ic506 ic tc74vhc245ft ...

  • Page 100

    Aw2816 14 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * jk201 microphone jack ykb21-5245 mic/line input 5-8 bal 02 -204 microphone jack ykb21-5245 02 jk205 phone jack ykb21-5313 mic/line input 8 hi-z 03 jk301 phone jack ykb21-5257 black phones 02 jk401 pin ja...

  • Page 101

    Aw2816 15 : new parts ref no. Part no. Description remarks qty rank rank: japan only r31 carbon resistor (chip) 4.7k 0.1 j 01 r32 metal film resistor (chip) 6.8k 1/10 d 01 r33 metal film resistor (chip) 6.8k 1/10 d 01 r34 carbon resistor (chip) 330.0 0.1 j 01 r35 carbon resistor (chip) 8.2k 0.1 j 01...

  • Page 102

    Aw2816 16 : new parts ref no. Part no. Description remarks qty rank rank: japan only r101 metal film resistor (chip) 4.7k 1/10 d 01 r102 metal film resistor (chip) 30.0k 1/10 d 01 r103 metal film resistor (chip) 8.2k 1/10 d 01 r104 metal film resistor (chip) 8.2k 1/10 d 01 r105 carbon resistor (chip...

  • Page 103

    Aw2816 17 : new parts ref no. Part no. Description remarks qty rank rank: japan only r178 metal film resistor (chip) 4.7k 1/10 d 01 r179 metal film resistor (chip) 30.0k 1/10 d 01 r180 metal film resistor (chip) 8.2k 1/10 d 01 r181 metal film resistor (chip) 8.2k 1/10 d 01 r182 carbon resistor (chip...

  • Page 104

    Aw2816 18 : new parts ref no. Part no. Description remarks qty rank rank: japan only r248 carbon resistor (chip) 330.0 0.1 j 01 r249 carbon resistor (chip) 8.2k 0.1 j 01 r250 metal film resistor (chip) 330.0 1/10 d 01 r251 metal film resistor (chip) 3.3k 1/10 d 01 r252 metal film resistor (chip) 2.2...

  • Page 105

    Aw2816 19 : new parts ref no. Part no. Description remarks qty rank rank: japan only r333 metal film resistor (chip) 4.7k 1/10 d 01 r334 metal film resistor (chip) 180.0 1/10 d 01 r335 metal film resistor (chip) 4.7k 1/10 d 01 r336 carbon resistor (chip) 10.0k 0.1 j 01 r337 metal film resistor (chip...

  • Page 106

    Aw2816 20 : new parts ref no. Part no. Description remarks qty rank rank: japan only r403 carbon resistor (chip) 75.0 0.1 j 01 r404 metal film resistor (chip) 18.0k 1/10 d 01 r405 metal film resistor (chip) 16.0k 1/10 d 01 r406 carbon resistor (chip) 75.0 0.1 j 01 r407 metal film resistor (chip) 10....

  • Page 107

    Aw2816 21 : new parts ref no. Part no. Description remarks qty rank rank: japan only r611 carbon resistor (chip) 1.0m 0.1 j 01 r612 carbon resistor (chip) 1.0k 0.1 j 01 r613 carbon resistor (chip) 10.0k 0.1 j 01 r616 carbon resistor (chip) 0.0 0.0 j 01 r617 carbon resistor (chip) 10.0k 0.1 j 01 r618...

  • Page 108

    Aw2816 22 : new parts ref no. Part no. Description remarks qty rank rank: japan only tr107 transistor 2sa2sa1576at106 01 tr108 transistor 2sc2sc4081t106 01 tr109 transistor 2sc2240 gr,bl 01 tr110 transistor 2sc2240 gr,bl 01 tr111 transistor 2sa2sa1576at106 01 tr112 transistor 2sc2sc4081t106 01 tr113...

  • Page 109

    Aw2816 23 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * ld214 led slr-322yct32 sel 3/11 ld215 led slr-322yct32 sel 4/12 ld216 led slr-322yct32 on 1/9 ld217...

  • Page 110

    Aw2816 24 : new parts ref no. Part no. Description remarks qty rank rank: japan only sw112 push switch skqnaa dyn/dly 01 sw113 push switch skqnaa aux1 01 sw114 push switch skqnaa aux2 01 sw115 push switch skqnaa aux3 01 sw116 push switch skqnaa aux4 01 sw117 push switch skqnaa aux5 01 sw118 push swi...

  • Page 111

    Aw2816 25 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * sw182 push switch skqnaa jog on 01 sw183 push switch skqnaa up 01 sw184 push switch skqnaa down 01 sw185 push switch skqnaa left 01 sw186 push switch skqnaa right 01 sw187 push switch skqnaa enter 01 sw188...

  • Page 112

    Aw2816 26 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * -206 monolithic ceramic cap. F 0.100 25v z 01 c301 electrolytic cap. (chip) 100 16v 01 c302 electrolytic cap. (chip) 100 16v 01 c303 monolithic ceramic cap. F 0.100 25v z 01 c305 monolithic ceramic cap. F ...

  • Page 113

    Aw2816 27 : new parts ref no. Part no. Description remarks qty rank rank: japan only l502 150uh lhl 08tb151k ld501 led gl3eg44 01 r101 flame proof c. Resistor 2.2 1/4 j 01 r102 carbon resistor (chip) 100.0 0.1 j 01 r103 metal film resistor (chip) 3.0k 1/10 d 01 r104 carbon resistor (chip) 390.0 0.1 ...

  • Page 114

    Aw2816 28 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * r503 carbon resistor (chip) 39.0k 0.1 j 01 r504 carbon resistor (chip) 1.2k 0.1 j 01 r505 carbon resistor (chip) 5.6k 1/4 j 01 r506 carbon resistor (chip) 5.6k 1/4 j 01 r507 carbon resistor (chip) 330.0 0.1 ...

  • Page 115

    12 11 10 9 8 7 6 5 4 3 2 1 a b c d e f g h i j k l m n o p q 12 11 10 9 8 7 6 5 4 3 2 1 a b c d e f g h i j k l m n o p q aw2816 aw2816 aw2816 note : see parts list for details of circuit board component parts aw2816 overall circuit diagram 1/5 (main1/3) main 1/3 (ha1) (ha2) (ad/da) 38cc1-8820119-2 ...

  • Page 116

    1 2 3 4 5 6 7 8 9 10 11 12 a b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 a b c d e f g h i j k l m n o p q aw2816 aw2816 aw2816 main 2/3 (dsp) (cpu) aw2816 overall circuit diagram 2/5 (main2/3) 38cc1-8820119-5 2 38cc1-8820119-6 5 dsp6 dram 16m dram 16m dsp7 sdram 16m buffer buffer dit...

  • Page 117

    1 2 3 4 5 6 7 8 9 10 11 12 a b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 a b c d e f g h i j k l m n o p q aw2816 aw2816 aw2816 aw2816 overall circuit diagram 3/5 (main3/3) note : see parts list for details of circuit board component parts : ceramic capacitor (ga) 38cc1-8820119-7 6 38...

  • Page 118

    12 11 10 9 8 7 6 5 4 3 2 1 a b c d e f g h i j k l m n o p q 12 11 10 9 8 7 6 5 4 3 2 1 a b c d e f g h i j k l m n o p q (sw) (led) 38cc1-8820120-2 38cc1-8820120-3 aw2816 overall circuit diagram 4/5 (pn, sub-cpu) pn sub-cpu 38cc1-8820121-4 3 38cc1-8820121-3 3 aw2816 aw2816 aw2816 to sub-f ader - cn...

  • Page 119

    1 2 3 4 5 6 7 8 9 10 11 12 a b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 a b c d e f g h i j k l m n o p q note : see parts list for details of circuit board component parts : ceramic capacitor : metal film resistor : flame proof c.Resistor sub-fader aw2816 overall circuit diagram 5/5...

  • Page 120

    L k j i h g f e d c b a 1 2 3 4 5 6 7 8 9 10 11 12 aw2816 m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 q p o n m l k j i h g f e d c b a aw2816 aw2816 aw2816 wiring aw2816 software block diagram q w e r t y u i o -1 o -2 !0 !1 !2 !3 !4 !5 !6 -1 !6 -2 !7 -1 !7 -2 location unit name parts list ref no. Part no...