B&D Firmadoor Series Installation Instructions Manual - page 11
PART NO: 51621. REVISION 6 - OCTOBER 2016
NYLON WOVEN
RUNNING STRIP
LEGS GO UNDER
NYLON WOVEN STRIP
SNAP OVER
CURTAIN EDGE
LEGS
(a)
(b)
HOOK
THIS END FIRST
LOCK C ORRUGATIO N
(c)
LOCK BODY
LOCK ARM
CUT-
LOCK BAR C OVER
FACE PLATE
(c)
(g)
(f)
(i)
(d)
LOCK BAR
DOUBLE SIDED
ADHESIVE TAPE
LOCK BAR C OVER
a) Raise the curtain until the lock corrugation is visible
above the door guides.
b) Install locking bar retainer in line with lock
corrugation by pushing retainer towards door
edge, sliding the legs under the nylon woven strip
and hooking them over the curtain edge (it is
easier to hook legs one at a time). Ensure lock bar
retainers sit squarely on door curtain. See Fig (b).
c) Fit faceplate to outside of door where the hook will
latch onto curtain edge, then slide faceplate as
far to the right as possible. Use adhesive tape on
outside to hold in position.
d) Attach the lock body to the faceplate from the
inside, using the mounting screws and washers.
Do not over tighten the screws. See Fig (d).
e) With the door in the closed position slide the
end of the locking bars through the locking bar
retainers, and while holding the bars level mark the
side of the guides.
f) Drill and file out a rectangular slot no longer than
25mm and no wider than 10mm. Ensure top of slot
remains in line with top of locking bar.
g) Slide bars through the guide slot, then back onto
lock arms. Screw on securely using the 4mm x 6mm
screws supplied. Ensure that locking bars do not
protrude more than 20mm beyond guide when
engaged in locked position. It may be necessary
to adjust the length of the bars.
h) Ensure a clean and dry guide surface. Wipe guide
with clean rag.
i) Peel off lining from lock bar cover and position
over hole. Check that the movement of the
locking bar is free.
NOTE: the fitting of the lock bar covers is important
to prevent possible finger entrapment - particularly
important when the door is fitted with an automatic
garage door opener.
2.8 centre lift lock
NYLON WOVEN
RUNNING STRIP
LEGS GO UNDER
NYLON WOVEN STRIP
SNAP OVER
CURTAIN EDGE
LEGS
(a)
(b)
HOOK
THIS END FIRST
LOCK C ORRUGATIO N
(c)
LOCK BODY
LOCK ARM
CUT-
LOCK BAR C OVER
FACE PLATE
(c)
(g)
(f)
(i)
(d)
LOCK BAR
DOUBLE SIDED
ADHESIVE TAPE
LOCK BAR C OVER
11
Firmadoor
®
Series 1 Installation Instructions