Bulldog Scrubbers SS20 User manual - page 4
4
Safety Instructions
IMPORTANT SAFETY INSTRUCTIONS
Operators must read and understand this manual before operating or maintaining this machine.
Do not operate this machine in fl ammable or explosive areas.
This machine is designed solely for scrubbing dirt and dust in an indoor environment. The Manufacturer does not recommend
using this machine in any other capacity.
The following information below may cause a potential hazard to the operator and equipment. Read this manual carefully
and be aware when these conditions can exist. Take necessary steps to locate all safety devices on the machine and train
the personnel operating the machine. Report any machine damage or faulty operation immediately.
Do not use machine
if it is not in proper operating condition.
FOR SAFETY DURING OPERATION
Keep hands and feet clear of moving parts while machine is in operation.
Make sure all safety devices are in place and operate properly. All covers, doors and latches must be closed and fastened
before use.
During operation, attention should be paid to other persons in the work area and especially if small children are present.
Electric motors and components can cause an explosion when operated near explosive materials or vapor. Do not operate
this machine near fl ammable materials such as solvents, thinners, fuels, grain dust, etc.
Store or park this machine on a level surface only. To prevent unauthorized use, machine should be stored or parked with
the key removed.
This machine is designed for level operation only.
Do not operate on ramps or inclines greater than 2%
.
This machine is not suitable for picking up hazardous dusts.
Use caution when moving this machine into areas that are below freezing temperatures. Any water in the tanks or hoses
can cause damage to the machine.
FOR SAFETY WHEN SERVICING or MAINTAINING MACHINE
Stop on level surface.
Disconnect the power to the machine by unplugging the red Battery connector located under the recovery tank near the
batteries.
Avoid moving parts. Do not wear loose jackets, shirts, or sleeves when working on machine.
Avoid contact with battery acid. Battery acid can cause burns. When working on or around batteries, wear protective
clothing and safety glasses. Remove metal jewelry. Do not lay tools or metal objects on top of batteries.
Charging batteries generates explosive gasses.
Do not charge batteries when open fl ames or sparks are present. Do not smoke.
Make sure the charger is turned off before disconnecting it from the machine.
Charge the batteries in a well-ventilated area with the battery cover removed completely.
Do not clean machine with a pressure washer.
Authorized personnel must perform repairs and maintenance. Use Manufacturer supplied replacement parts.
SAVE THESE INSTRUCTIONS
Unpacking Instructions
Inspection
Carefully unpack and inspect your
Walk-Behind Scrubber
for shipping damage. Follow unpacking instructions on
shipping pallet. Each unit has been tested and thoroughly inspected before shipment. Any damage is the responsibility
of the delivery carrier who should be notifi ed immediately.
Electrical
This machine is battery operated and designed to operate on 24 volts DC (2) 12-volt batteries.
Batteries
The recommended batteries are rated 140Ah WET (Manufacturer’s P/N 956140) or 100Ah MAINTENANCE FREE
GEL (Manufacturer’s P/N 956100). We do not recommend mixing AMP hour capacities. Alternate battery sets can
be used if they equal physical size and capacity. If alternate battery sets are used please contact the manufacturer
for on board charger settings.
Operator Responsibility
Read this manual carefully before operating this machine.
The operator is responsible for taking care of the daily maintenance and check ups of the machine to keep it
in good working condition. The operator must inform the service mechanic or supervisor when the scheduled
maintenance intervals are required as stated in the
MAINTENANCE
section of this manual.
Before starting familiarize yourself with the machine and its controls (see “Machine Overview, Front”, “Machine
Overview, Rear”, “Control Console” diagrams).
Factory
Cleaning
Equipment,
Inc.
800-793-3790
www.thesweeper.com