1. DL manuals
  2. Eaton
  3. UPS
  4. Powerware 5125
  5. User Manual

Eaton Powerware 5125 User Manual - Ups Rear Panels

Manual is about: (500 VA – 60 kVA)

Summary of Powerware 5125

  • Page 1

    Powerware series eaton 5125 tower ups 1000–2200 va user's guide ®.

  • Page 2

    Requesting a declaration of conformity units that are labeled with a ce mark comply with the following harmonized standards and eu directives: s harmonized standards: iec/en 62040-1-1 and iec/en 62040-2 s eu directives: 73/23/eec, council directive on equipment designed for use within certain voltag...

  • Page 3: Class A Emc Statements

    Class a emc statements (1000–1500 va models) fcc part 15 note this equipment has been tested and found to comply with the limits for a class a digital device, pursuant to part 15 of the fcc rules. These limits are designed to provide reasonable protection against harmful interference when the equipm...

  • Page 4: Special Symbols

    Special symbols the following are examples of symbols used on the ups or accessories to alert you to important information: risk of electric shock - observe the warning associated with the risk of electric shock symbol. Caution: refer to operator’s manual - refer to your operator's manual for additi...

  • Page 5

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality i table of contents 1 introduction 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 safety warnings 3 . . . . . . . . . . . . . . . . . . ...

  • Page 6

    Table of contents eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality ii 7 specifications 49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 troubleshooting 53 . . . . . . . . . . . . . . . . . ....

  • Page 7

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 1 chapter 1 introduction eaton ® 5125 uninterruptible power system (ups) protects your sensitive electronic equipment from basic power problems such as power failures, power sags, power surges, brownouts, an...

  • Page 8

    Introduction eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 2 providing outstanding performance and reliability, the eaton 5125's unique benefits include: s buck and double boost regulation that ensures consistent voltage to your load by correcting volta...

  • Page 9: Save These Instructions

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 3 chapter 2 safety warnings important safety instructions save these instructions this manual contains important instructions that you should follow during installation and maintenance of the ups and batteri...

  • Page 10: Sikkerhedsanvisninger

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 4 c a u t i o n s batteries can present a risk of electrical shock or burn from high short-circuit current. Observe proper precautions. Servicing should be performed by qualified service pers...

  • Page 11: Bewaar Deze Instructies

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 5 a d v a r s e l s batterierne kan give risiko for elektrisk stød eller brandsår forårsaget af høj kortslutningsstrøm. Overhold gældende forsigtighedsregler. Servicering skal udføres af kval...

  • Page 12

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 6 s teneinde de kans op brand of elektrische schok te verminderen dient deze ups in een gebouw met temperatuur‐ en vochtigheidregeling te worden geïnstalleerd, waar geen geleidende verontrein...

  • Page 13: Tarkeita Turvaohjeita

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 7 tarkeita turvaohjeita tÄrkeitÄ turvaohjeita - suomi sÄilytÄ nÄmÄ ohjeet tämä käyttöohje sisältää tärkeitä ohjeita, joita on noudatettava ups-virtalähteen ja akkujen asennuksen ja huollon yh...

  • Page 14: Consignes De Sécurité

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 8 consignes de sécurité consignes de sÉcuritÉ importantes conserver ces instructions ce manuel comporte des instructions importantes que vous êtes invité à suivre lors de toute procédure d'in...

  • Page 15: Sicherheitswarnungen

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 9 a t t e n t i o n ! S les batteries peuvent présenter un risque de choc électrique ou de brûlure provenant d'un courant de court-circuit haute intensité. Observez les précautions appropriée...

  • Page 16: Avvisi Di Sicurezza

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 10 s um die brand‐ oder elektroschockgefahr zu verringern, diese usv nur in gebäuden mit kontrollierter temperatur und luftfeuchtigkeit installieren, in denen keine leitenden schmutzstoffen v...

  • Page 17

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 11 a v v e r t e n z a s l'ups contiene la propria fonte di energia (batterie). Le prese d'uscita possono essere sotto tensione anche quando l'ups non è collegato all'alimentazione elettrica ...

  • Page 18: Gjem Disse Instruksjonene

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 12 viktig sikkerhetsinformasion viktige sikkerhetsinstruksjoner gjem disse instruksjonene denne håndboken inneholder viktige instruksjoner som du bør overholde ved montering og vedlikehold av...

  • Page 19: Regulamentos De Segurança

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 13 f o r s i k t i g s batterier kan utgjøre en fare for elektrisk støt eller brannsår pga. Høy kortsluttingsstrøm. Treff passende forholdsregler. Service bør utføres av kvalifisert servicepe...

  • Page 20

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 14 s para reduzir o risco de incêndios ou choques elétricos, instale a ups em ambiente interno com temperatura e umidade controladas e livres de contaminadores condutíveis. A temperatura ambi...

  • Page 21

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 15 Ï Ð Å Ä Ó Ï Ð Å Æ Ä Å Í È Å s äàííîì ÈÁÏ óñòàíîâëåíû ñîáñòâåííûå èñòî÷íèêè ýíåðãèè (áàòàðåè). Íà âûõîäíûõ ðîçåòêàõ ìîæåò áûòü íàïðÿæåíèå, äàæå åñëè ÈÁÏ íå ïîäêëþ÷åí ê ñåòè ïåðåìåííîãî òîêà...

  • Page 22: Advertencias De Seguridad

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 16 advertencias de seguridad instrucciones de seguridad importantes guarde estas instrucciones este manual contiene instrucciones importantes que debe seguir durante la instalación y el mante...

  • Page 23: Säkerhetsföreskrifter

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 17 p r e c a u c i Ó n s las baterías pueden constituir un riesgo de descarga eléctrica o quemaduras por corriente alta de corto circuito. Adopte las precauciones debidas. Personal calificado...

  • Page 24

    Safety warnings eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 18 s minska risken för brand eller elektriska stötar genom att installera denna ups-enhet inomhus, där temperatur och luftfuktighet är kontrollerade och där inga ledande föroreningar förekomm...

  • Page 25: Inspecting The Equipment

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 19 chapter 3 installation this section explains: s equipment inspection s ups internal battery connection s ups installation s ups rear panels inspecting the equipment if any equipment has been damaged durin...

  • Page 26

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 20 connecting the ups internal battery to ensure proper battery operation: 1. Verify that the ups is off and unplugged. 2. Remove the ups front cover (see figure 2). Figure 2. Removing the ups f...

  • Page 27

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 21 note a small amount of arcing may occur when connecting the batteries. This is normal and does not damage the unit or present any safety concern. 5. Connect the internal battery connector(s) ...

  • Page 28: Installing The Ups

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 22 installing the ups note do not make unauthorized changes to the ups or accessories; otherwise, damage may occur to your equipment and void your warranty. Figure 6 shows a typical installation...

  • Page 29

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 23 4. Plug the equipment to be protected into the appropriate ups output receptacles (see page 39 for more information on load segments). Note do not protect laser printers with the ups because ...

  • Page 30: Ups Rear Panels

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 24 ups rear panels this section shows the rear panels of the eaton 5125 models. X-slot communication bay 6‐ft power cord with 5‐15 plug battery connector network transient protector six 5-15r re...

  • Page 31

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 25 10a, iec‐320 input connector battery connector network transient protector six 10a, iec 320-c13 receptacles x-slot communication bay communication port figure 9. Pw5125 1000i and pw5125 1500i...

  • Page 32

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 26 6‐ft power cord with 5‐15 plug battery connector network transient protector six 5-15r receptacles x-slot communication bay communication port figure 11. Pw5125 1000j rear panel battery conne...

  • Page 33

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 27 6-ft power cord with l5-30 plug battery connector network transient protector six 5-15r receptacles two 5-20r receptacles x-slot communication bay communication port figure 13. Pw5125 2200j r...

  • Page 34

    Installation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 28.

  • Page 35: Turning The Ups On

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 29 chapter 4 operation this section describes: s turning the ups on and off s starting the ups on battery s initiating the self‐test s operating modes turning the ups on after the ups is connected to a power...

  • Page 36: Turning The Ups Off

    Operation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 30 turning the ups off note pressing the off button while the ups is in battery mode causes the ups to shut down immediately. To turn off the ups: 1. Prepare your equipment for shutdown. 2. Press a...

  • Page 37: Operating Modes

    Operation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 31 operating modes the eaton 5125 front panel indicates the ups status through the ups indicators. Figure 15 shows the ups front panel indicators and controls. Normal mode indicator (solid green) s...

  • Page 38

    Operation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 32 normal mode during normal mode, the indicator illuminates and the front panel displays the percentage of ups load capacity being used by the protected equipment (see figure 16). The ups monitors...

  • Page 39

    Operation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 33 battery mode when the ups is operating during a power outage, the alarm beeps once every four seconds and the + - indicatorilluminates. When utility power returns, the ups transfers to normal mo...

  • Page 40

    Operation eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 34.

  • Page 41: X-Slot Cards

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 35 chapter 5 additional ups features this section describes: s x-slot cards s network transient protector s load segments x-slot cards x-slot cards allow the ups to communicate in a variety of networking env...

  • Page 42

    Additional ups features eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 36 multi-server card relay interface card usb card modbus card connectups-x web/snmp card x-slot communication bay (single-port card shown) figure 18. Optional x-slot cards single-por...

  • Page 43

    Additional ups features eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 37 table 1. Communication port pin assignment pin number signal name function direction from the ups 1 low batt low battery relay contact; 20 ma, 30 vdc contact rating out 2 txd trans...

  • Page 44: Network Transient Protector

    Additional ups features eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 38 network transient protector the network transient protector, shown in figure 20, is located on the rear panel and has jacks labeled in and out. This feature accommodates a single r...

  • Page 45: Load Segments

    Additional ups features eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 39 load segments load segments are sets of receptacles that can be controlled by power management software, providing an orderly shutdown and startup of your equipment. For example, d...

  • Page 46

    Additional ups features eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 40

  • Page 47: Ups and Battery Care

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 41 chapter 6 ups maintenance this section explains how to: s care for the ups and batteries s transport the ups s store the ups and batteries s replace the batteries s test new batteries s recycle used batte...

  • Page 48: When To Replace Batteries

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 42 storing the ups and batteries if you store the ups for a long period, recharge the battery every 6 months by plugging the ups into a power outlet. The batteries charge to 90% capacity in a...

  • Page 49

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 43 how to replace internal batteries c a u t i o n pull the battery out onto a flat, stable surface. The battery is unsupported when you pull it out of the ups. To replace the ups internal ba...

  • Page 50

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 44 3. 1000 va models. Disconnect the red battery cable on the front of the battery (see figure 25). Pull the battery out onto a flat, stable surface. Disconnect the black battery cable on the...

  • Page 51

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 45 4. 1500 and 2200 va models. Pull the battery out onto a flat, stable surface (see figure 26). Press on the black tab on the battery cable connector to disconnect the battery. See “recyclin...

  • Page 52: Testing New Batteries

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 46 how to replace extended battery modules to replace the extended battery modules (ebms): 1. Unplug the ebm cable from the ups. If additional ebms are installed, unplug the ebm cable from th...

  • Page 53

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 47 recycling the used battery or ups contact your local recycling or hazardous waste center for information on proper disposal of the used battery or ups. W a r n i n g s do not dispose of th...

  • Page 54

    Ups maintenance eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 48.

  • Page 55

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 49 chapter 7 specifications this section provides the following specifications: s model list s dimensions and weights s electrical input and output s environmental and safety s battery table 2. Model specifi...

  • Page 56

    Specifications eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 50 table 4. Power connections input connection output receptacles pw5125 1000 6-ft, 5-15p power cord (6) 5-15r pw5125 1500 6-ft, 5-15p power cord (6) 5-15r pw5125 2200 6-ft, 5-20p power cord (...

  • Page 57

    Specifications eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 51 table 6. Environmental and safety low voltage models high voltage models operating temperature 10°c to 40°c (50°f to 104°f) optimal battery performance: 25°c (77°f) storage temperature 0°c ...

  • Page 58

    Specifications eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 52 table 8. Battery runtimes (in minutes at full/half load) model ups internal batteries +1 ebm +2 ebms +3 ebms +4 ebms 1000 va 5/14 25/60 55/170 83/199 109/228 1500 va 6/17 33/79 63/146 92/17...

  • Page 59

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 53 chapter 8 troubleshooting this section explains: s ups alarms and conditions s how to silence an alarm s service and support audible alarms and ups conditions the ups has an audible alarm feature to alert...

  • Page 60

    Troubleshooting eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 54 silencing an audible alarm before silencing an alarm, check the alarm condition and perform the applicable action to resolve the condition (see table 9). To silence the alarm for an existi...

  • Page 61

    Troubleshooting eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 55 table 9. Troubleshooting guide (continued) action possible cause alarm or condition 1 beep every 4 seconds. The ups is on battery (see “battery mode” on page 33 for more information). The ...

  • Page 62

    Troubleshooting eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 56 table 9. Troubleshooting guide (continued) action possible cause alarm or condition the self-test failed. Plug the ups into a power outlet for at least 3 hours to charge the battery. Press...

  • Page 63: Service and Support

    Troubleshooting eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 57 service and support if you have any questions or problems with the ups, call your local distributor or the help desk at one of the following telephone numbers and ask for a ups technical r...

  • Page 64

    Troubleshooting eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 58.

  • Page 65: Warranty (Us and Canada)

    Eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 59 chapter 9 warranty two-year limited warranty with extension to three-year limited warranty (us and canada) eaton ups models: 3105, 5110, 5115, 5125, and 5130 warrantor: the warrantor for the limited warra...

  • Page 66

    Warranty eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 60 what this limited warranty does not cover: this warranty does not cover any defects or damages caused by: (a) failure to properly store the product before installation, including the charge of ba...

  • Page 67

    Warranty eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 61 costs not related to warranty: the end-user shall be invoiced for, and shall pay for, all services not expressly provided for by the terms of this warranty, including without limitation, site cal...

  • Page 68

    Warranty eaton 5125 tower ups (1000–2200 va) user's guide s 05147304 rev c www.Eaton.Com/powerquality 62 what this guaranty does not cover: any reimbursement or repair to end-user's equipment does not include reimbursement for or restoration of any data loss. This guaranty does not cover any defects...