Factory Cat 29 Operator's Manual & Service Book - . D
PAGE 18
DAILY PRE-CHECK AND INSPECTION
Before each shift (every eight hours of operation), It is the operator's responsibility to carry
out the following checks and inspections before beginning operation of the sweeper:
*
WARNING DEVICES: Battery condition gauge. Green "ignition-on" light.
*
BATTERIES: Visually inspect connections. Look for spills & Wipe Them Up.
Use bakingsoda to neutralize spilled acid.
*
CLEAN THE RECOVERY TANK. Drain it completely every day through the
drain hose. Hose out and check condition by looking in the flush-out door on
top of the tank. If still full of debris, open the cleanout door (at back of the
tank) and clean out the floor of the tank.
*
CLEAN OFF MACHINE: If dusty, clean machine with compressed air. To
maintain paint, use S.C. Johnson's "Pledge" furniture polish and soft cloth, or
an equivalent product.
We do not recommend washing, and especially do not recommend
pressure washing this machine as misdirected water could damage
electricals.
I
F
THE
MACHINE
IS
IN
NEED
OF
REPAIR
OR
IN
ANY
WAY
UNSAFE
OR
CON
-
TRIBUTES
TO
AN
UNSAFE
CONDITION
,
THE
MATTER
MUST
BE
REPORTED
IMMEDIATELY
TO
THE
SHIFT
SUPERVISOR
. D
O
NOT
OPERATE
THE
MA
-
CHINE
UNTIL
IT
IS
RESTORED
TO
PROPER
OPERATING
CONDITION
.